NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
194 reportsClear category filterMileage unknown · Jun 20, 2024
Electrical SystemEnginePower Train
So back in October 2023 ,I noticed a lot of things go wrong at once lime the radiator had to be replaced because it was leaking everywhere. The steering went bad and started leaking. The rear main seal started leaking. The clock spring went bad. there isntons of water always in the passenger floorboard and passenger door. The fu…
Read full complaint
So back in October 2023 ,I noticed a lot of things go wrong at once lime the radiator had to be replaced because it was leaking everywhere. The steering went bad and started leaking. The rear main seal started leaking. The clock spring went bad. there isntons of water always in the passenger floorboard and passenger door. The fuel gauge is all over the place and never reads right. The oil pressure gauge always has been on high. The engine light, air bag light slip light, and abs light have always been on. The right rear window stopped going up and the controls on the drivers door sometimes work and sometimes don't. The Manuel shifter has never worked and I cannot put the transmission in 2,3, or 4th gear from a stand still. Always been weird knocking sound in the suspension
NHTSA ODI #11595412
153,000 miles · Mar 29, 2022
Electrical SystemEnginePower Train
The contact's son owns a 2006 Nissan Titan. The contact stated while his son was driving approximately 35-45 MPH, the vehicle stalled inadvertently. The contact was unsure whether there were any warning lights illuminated. The contact's son was able to restart the vehicle and continued to drive; however, the failure reoccurred s…
Read full complaint
The contact's son owns a 2006 Nissan Titan. The contact stated while his son was driving approximately 35-45 MPH, the vehicle stalled inadvertently. The contact was unsure whether there were any warning lights illuminated. The contact's son was able to restart the vehicle and continued to drive; however, the failure reoccurred several times while driving. The vehicle was taken to Pep Boys and diagnosed the failure as a vehicle dynamic control switch, acceleration, and power train systems failure. The vehicle was not repaired. Additionally, the contact stated that the instrument cluster had failed. The dealer was not notified of the failures. The manufacturer was notified of the failure and informed the contact that the VIN was not included in any recalls. The failure mileage was approximately 153,000.
NHTSA ODI #11458845
235,483 miles · Apr 26, 2021
Electrical SystemPower TrainVehicle Speed Control
I HAVE HAD TO REPLACE MY TRANSFER CASE 2 TIMES, MY FRONT DRIVE SIDE HUB ASSEMBLY 2 TIMES IN LESS THAN 2 YEARS. I HAVE REPLACE FRONT AXLE AND AND REAR. NOW MY PASSENGER SIDE LEAKS OUT FROM UNDER THE GLOVE BOX EVERY TIME IT RAINS INTO MY FLOOR KEEPING IT WET. JUST YESTERDAY MY TRANSMISSION WENT ITNO LIMP MODE AND I KNOW IT CAN BE…
Read full complaint
I HAVE HAD TO REPLACE MY TRANSFER CASE 2 TIMES, MY FRONT DRIVE SIDE HUB ASSEMBLY 2 TIMES IN LESS THAN 2 YEARS. I HAVE REPLACE FRONT AXLE AND AND REAR. NOW MY PASSENGER SIDE LEAKS OUT FROM UNDER THE GLOVE BOX EVERY TIME IT RAINS INTO MY FLOOR KEEPING IT WET. JUST YESTERDAY MY TRANSMISSION WENT ITNO LIMP MODE AND I KNOW IT CAN BE A NUMBER OF THINGS . I LOOK AT THE 04 THRU 07 TITANS AND THEY HAVE A LOT OF ISSUES LIKE HAVE BUT HAVEN'T LISTED THEM ALL, BUT THE ISSUES IAM HAVING ARE NOT ON RECALL LIST FOR MY 2006, BUT ARE FOR THE OTHER YEARS??? THIS IS MY ONLY VEHICLE AND I CAN'T AFFORD TO KEEP DROPPING $ INTO IT. BACK DRIVER WINDOW MOTOR STOPPED AND WINDOW FELL AND BROKE, MANIFOLD TICKING IS A RECALL FOR THE 2005, BUT NOT MY 2006. I COULD KEEP GOING BUT I AM GETTING SO FRUSTRATED. I WAS GOING DOWN THE ROAD AT ABOUT 45 MHP WHEN IT JUST WENT INTO LIMP MODE, SO I PULLED OVER TURNED IT OFF AND BACK ON THEN IT WOULD WORK FOR ABOUT 3 MIN. STOP DO IT AGAIN TO GET HOME. IT WILL GO INTO GEAR, AND THE RPM'S REV AND GO UP ,BUT I AM NOT GETTING VERY FAR AT ALL. MY TRANS FLUID IS GOOD. I HAVE ALSO REPLACED THE THROTTLE POSITION SENSOR. ALL FUSES ARE GOOD AND CODES RESET AND IT STILL GOES LIMP MODE.
NHTSA ODI #11414007
63,000 miles · Oct 15, 2020
Power Train
REAR AXLE SEAL FAILS AND CAUSES DIFFERENTIAL OIL TO LEAK OUT CAUSING A MAJOR SAFETY ISSUE WHILE DRIVING.
NHTSA ODI #11364441
120,000 miles · Jul 14, 2019
EnginePower Train
OVERHEATED, ENGINE WOULD NOT START, TRANSMISSION WOULD NOT SHIFT TO GO MOSTLY SLUGGISH. THIS IS MY 3RD TIME TITAN OVERHEATED, HAD TO BE TOWED.
NHTSA ODI #11231671
218,800 miles · Apr 1, 2019
EnginePower TrainVehicle Speed Control
MY TRUCK HAS BEEN SHOWING P0335 CODE ISSUES, WHICH IS CRANKSHAFT SENSOR, WHICH HAS BEEN REPLACED, MY RPM'S JUMP/SPUTTER BUT THE TRUCK STARS & RUNS BUT FEELS LIKE ITS RUNNING ROUGH, ALSO I FORGOT TO MENTION THAT MY DASHBOARDS "SLIP" LIGHT REMAINS ON... AND THE BIGGEST PROBLEM WITH IT IS THAT, NO "PROFESSIONALS" SEEM TO KNOW WHA…
Read full complaint
MY TRUCK HAS BEEN SHOWING P0335 CODE ISSUES, WHICH IS CRANKSHAFT SENSOR, WHICH HAS BEEN REPLACED, MY RPM'S JUMP/SPUTTER BUT THE TRUCK STARS & RUNS BUT FEELS LIKE ITS RUNNING ROUGH, ALSO I FORGOT TO MENTION THAT MY DASHBOARDS "SLIP" LIGHT REMAINS ON... AND THE BIGGEST PROBLEM WITH IT IS THAT, NO "PROFESSIONALS" SEEM TO KNOW WHAT IT IS, NOR HAVE THEY BEEN ABLE TO FOGURE IT OUT AS OF YET.
NHTSA ODI #11193232
228,000 miles · Mar 26, 2019
Power Train
RADIATOR FLUID MIXING WITH TRANSMISSION FLUID VIA INTERNAL COOLER IN RADIATOR CAUSING VEHICLE TO STOP MOVING ALTHOUGH MOTOR FUNCTIONING PROPERLY.
NHTSA ODI #11191745
250,000 miles · Mar 22, 2019
Power Train
REAR END LOCKED UP AND HAD TO BE REPLACED. OVER THE YEARS, THE REAR SEALS WOULD CONSTANTLY LEAK AND WERE REPLACED MULTIPLE TIMES AND WAS USUALLY BROUGHT TO MY ATTENTION DURING OIL CHANGES/INSPECTIONS. I GUESS THEY DIDNT CATCH IT LEAKING AND CAUSED MY REAR END TO LOCK UP WHICH WAS VERY DANGEROUS AND COULD HAVE CAUSED A MAJOR AC…
Read full complaint
REAR END LOCKED UP AND HAD TO BE REPLACED. OVER THE YEARS, THE REAR SEALS WOULD CONSTANTLY LEAK AND WERE REPLACED MULTIPLE TIMES AND WAS USUALLY BROUGHT TO MY ATTENTION DURING OIL CHANGES/INSPECTIONS. I GUESS THEY DIDNT CATCH IT LEAKING AND CAUSED MY REAR END TO LOCK UP WHICH WAS VERY DANGEROUS AND COULD HAVE CAUSED A MAJOR ACCIDENT. I WAS HEADING TO WORK AROUND 4-5 AM IN THE MORNING AND ALL MY LIGHTS ON MY TRUCK CAME ON KIND OF FELT LIKE I BLEW A TIRE AND STARTED PULLING VERY HARD. I WAS ABLE TO GET OFF THE ROAD RATHER QUICKLY AND HAD IT TOWED. I KNOW PLENTY OF PEOPLE THAT HAVE HAD THIS ISSUES WITH THE EARLY MODEL NISSAN TITANS. BESIDES THAT THOUGH I HAVE BEEN PLEASED WITH MY TITAN. I HAVE OVER 500K MILES ON IT CURRENTLY. FYI THIS HAPPENED YEARS BACK BUT I WAS READING A FORUM THAT WE SHOULD TRY TO GET THIS RECALLED AND IT DID COST ME ALOT TO HAVE THE REAR END FIXED.
NHTSA ODI #11190872
87,000 miles · Mar 12, 2019
Power Train
REAR AXEL SEAL LEAKS CAUSES FLUID TO GET ON BRAKES AND CAN CAUSE ABS FEATURE TO FAIL. PRESENTING A HAZAROUNDAFE SITUATION
NHTSA ODI #11186031
140,000 miles · Feb 14, 2019
Power Train
TRANSMISSION HAS BEEN STUCK IN 4TH GEAR WHILE IN DRIVE. IT. WILL SWITCH INTO PARK, REVERSE AND NEUTRAL. WHEN THE TRUCK IS PUT ON THE COMPUTER THERE ARE NO ERROR CODES SHOWING THAT WOULD REQUIRE REPAIR THEREFORE NISSAN REFUSES TO SUBMIT ANY DOCUMENTATION HIGHER TO ADDRESS THIS ISSUE WITH THIS STANDARD TRANSMISSION IN ALL OF THEIR…
Read full complaint
TRANSMISSION HAS BEEN STUCK IN 4TH GEAR WHILE IN DRIVE. IT. WILL SWITCH INTO PARK, REVERSE AND NEUTRAL. WHEN THE TRUCK IS PUT ON THE COMPUTER THERE ARE NO ERROR CODES SHOWING THAT WOULD REQUIRE REPAIR THEREFORE NISSAN REFUSES TO SUBMIT ANY DOCUMENTATION HIGHER TO ADDRESS THIS ISSUE WITH THIS STANDARD TRANSMISSION IN ALL OF THEIR VEHICLES. ON A SIDE NOTE, I'VE HAD 2 OTHER NISSANS WITH A CENTRAL VARIABLE TRANSMISSION THAT HAVE ALL DONE THIS AS WELL. I'VE SINCE BEEN ABLE TO GET RID OF THOSE VEHICLES, BUT I AM STUCK WITH THIS ONE.
NHTSA ODI #11180168
Official recalls
5Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration