NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
36 reportsClear category filter150,000 miles · Aug 12, 2016
Air BagsEngine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY BEGAN TO VIBRATE AND SHUTTER. AFTER STOPPING THE VEHICLE, THE FAILURE WOULD SUDDENLY CEASE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS CAUSED BY RADIATOR FLUID LEAKING INTO THE TRANSMISSION. THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY BEGAN TO VIBRATE AND SHUTTER. AFTER STOPPING THE VEHICLE, THE FAILURE WOULD SUDDENLY CEASE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS CAUSED BY RADIATOR FLUID LEAKING INTO THE TRANSMISSION. THE FAILURE WAS NOT REPAIRED. ALSO, WHILE OPERATING THE VEHICLE, THE AIR BAG SENSOR LIGHT WOULD BLINK ON AND OFF. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10895279
96,000 miles · Aug 2, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE THE VEHICLE WAS STATIONARY, THE EXHAUST MANIFOLD FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #10892446
65,000 miles · Jul 29, 2015
Engine And Engine CoolingService Brakes
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL BUT THE BRAKES FAILED TO ENGAGE IMMEDIATELY. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER A TEN SECOND WAIT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO NOTICED AN ABNORMAL NOISE AND LEAK FROM THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL BUT THE BRAKES FAILED TO ENGAGE IMMEDIATELY. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER A TEN SECOND WAIT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO NOTICED AN ABNORMAL NOISE AND LEAK FROM THE EXHAUST MANIFOLD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE EXHAUST MANIFOLD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
NHTSA ODI #10744637
117,000 miles · Sep 29, 2014
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE PASSENGER SIDE MANIFOLD WAS CRACKED. A LOUD EXHAUST NOISE COULD BE HEARD FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE FAILURE EXISTED FOR THE PAST TWO YEARS. AN INDEPENDENT MECHANIC STATED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE PASSENGER SIDE MANIFOLD WAS CRACKED. A LOUD EXHAUST NOISE COULD BE HEARD FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE FAILURE EXISTED FOR THE PAST TWO YEARS. AN INDEPENDENT MECHANIC STATED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10639768
Mileage unknown · Jun 17, 2013
Engine And Engine Cooling
2006 NISSAN TITAN EXHAUST MANIFOLDS CRACKED AGAIN. FIXED AT DEALER AT 62,837, REPLACED BOTH EXHAUST MANIFOLDS WITH NEW ONES. NOW AT 118023 MANIFOLDS ARE CRACKED AGAIN, OUT OF WARRANTY AND DEALER WILL NOT REPLACE. THIS IS NOT A CHEAP REPAIR SOMEWHERE AROUND $2900 TO FIX BOTH. I HAVE HEARD MANY OTHER COMPLAINTS ABOUT THIS AND HAD …
Read full complaint
2006 NISSAN TITAN EXHAUST MANIFOLDS CRACKED AGAIN. FIXED AT DEALER AT 62,837, REPLACED BOTH EXHAUST MANIFOLDS WITH NEW ONES. NOW AT 118023 MANIFOLDS ARE CRACKED AGAIN, OUT OF WARRANTY AND DEALER WILL NOT REPLACE. THIS IS NOT A CHEAP REPAIR SOMEWHERE AROUND $2900 TO FIX BOTH. I HAVE HEARD MANY OTHER COMPLAINTS ABOUT THIS AND HAD I KNOWN PREVIOUSLY I WOULD NOT HAVE PURCHASED THIS VEHICLE. NISSAN REPLACED THE FAULTY MANIFOLDS WITH THE SAME NEW FAULTY MANIFOLDS. *TR
NHTSA ODI #10520248
Mileage unknown · Apr 25, 2013
Engine And Engine Cooling
HAVE TAKEN IT TO TWO DIFFERENT REPAIR SHOPS AND HAVE BOTH (DRIVERS/PASSENGER SIDE) EXHAUST MANIFOLD ARE CRACKED. HAVE GONE TO NISSAN FOR THE REPAIRS .NISSAN HAS STATED THAT ITS A KNOWN ISSUE ON NISSAN TITANS FOR THE YEARS OF 2004-2007 BUT WON'T REPLACE IT. WAS QUOTED FOR THE REPAIR OF $3,000. ITS JUST OUT OF THE MILES ON THE 80K…
Read full complaint
HAVE TAKEN IT TO TWO DIFFERENT REPAIR SHOPS AND HAVE BOTH (DRIVERS/PASSENGER SIDE) EXHAUST MANIFOLD ARE CRACKED. HAVE GONE TO NISSAN FOR THE REPAIRS .NISSAN HAS STATED THAT ITS A KNOWN ISSUE ON NISSAN TITANS FOR THE YEARS OF 2004-2007 BUT WON'T REPLACE IT. WAS QUOTED FOR THE REPAIR OF $3,000. ITS JUST OUT OF THE MILES ON THE 80K/8YEAR EMISSIONS WARRANTY, BUT STILL TIME FRAME.
NHTSA ODI #10509602
84,000 miles · Aug 24, 2012
Engine And Engine CoolingPower Train
MY 2006 TITAN STARTED VIBRATING LIKE RUNNING OVER RUMBLE STRIPS ON SIDE OF HIGHWAY. TOOK STRAIGHT TO DEALERSHIP. WAS TOLD THAT THE COOLING SYSTEM SPLIT AND CONTAMINATED THE TRANSMISSION. I HAD TO HAVE THE TRANSMISSION AND RADIATOR REPLACED $7313.56. THERE WAS NO WARNING OR ANYTHING. AFTER READING MANY COMPLAINTS FOR THE SAME THI…
Read full complaint
MY 2006 TITAN STARTED VIBRATING LIKE RUNNING OVER RUMBLE STRIPS ON SIDE OF HIGHWAY. TOOK STRAIGHT TO DEALERSHIP. WAS TOLD THAT THE COOLING SYSTEM SPLIT AND CONTAMINATED THE TRANSMISSION. I HAD TO HAVE THE TRANSMISSION AND RADIATOR REPLACED $7313.56. THERE WAS NO WARNING OR ANYTHING. AFTER READING MANY COMPLAINTS FOR THE SAME THING ON OTHER NISSAN VEHICLES, THERE NEEDS TO BE AN INVESTIGATION AND A RECALL ON THE COOLING SYSTEM THAT CAN CAUSE THIS AMOUNT OF DAMAGE. *TR
NHTSA ODI #10472357
84,093 miles · Apr 26, 2012
Engine And Engine Cooling
LEFT AND RIGHT SIDE EXHAUST MANIFOLDS ARE CRACKED. THEY ARE NORMALLY COVERED UNDER THE EMISSIONS WARRANTY OF 8YR/80K MILES. I AM OUT OF WARRANTY BY 4,000 MILES. I PUT 4K MILES EVERY 3 MONTHS AND I HAVE HEARD THE TICKING NOISE WHEN THE VEHICLE IS COLD FOR OVER THIS TIME PERIOD. I CONTACTED NISSAN USA FOR LOYAL CUSTOMER ASSISTANCE…
Read full complaint
LEFT AND RIGHT SIDE EXHAUST MANIFOLDS ARE CRACKED. THEY ARE NORMALLY COVERED UNDER THE EMISSIONS WARRANTY OF 8YR/80K MILES. I AM OUT OF WARRANTY BY 4,000 MILES. I PUT 4K MILES EVERY 3 MONTHS AND I HAVE HEARD THE TICKING NOISE WHEN THE VEHICLE IS COLD FOR OVER THIS TIME PERIOD. I CONTACTED NISSAN USA FOR LOYAL CUSTOMER ASSISTANCE AND WAS DENIED. I FILED AN APPEAL AND WAS DENIED WITHIN 2 HOURS. I HAVE OWNED (3) NISSANS IN THE PAST 7 YEARS AND EXPECT SOME COMPENSATION. THIS IS A MAJOR PROBLEM ON ALL TITANS 2004 TO 2007. THIS SHOULD BE UNDER RECALL FOR EXHAUST GASES GETTING INTO THE PASSENGER COMPARTMENT. *TR
NHTSA ODI #10456592
33,691 miles · Mar 30, 2012
Engine And Engine Cooling
REPEATED CRACKED EXHAUST MANIFOLDS WHICH CAN LEAK DANGEROUS AND LETHAL EXHAUST FUMES AND CARBON MONOXIDE INTO THE CABIN INTERIOR. *JS
NHTSA ODI #10453598
120,000 miles · Mar 26, 2012
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
CATALYTIC CONVERTER WENT OUT & NEEDED TO BE REPLACED IN ORDER TO PASS A SMOG! $2400 TO FIX AND THE MECHANIC SAID THERE WAS NOTHING LEFT OF THE HONEYCOMB INSIDE WHEN THERE SHOULD BE!! RECALL NEEDS TO BE ISSUED!! *TR
NHTSA ODI #10453118
Official recalls
5Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration