NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
46 reportsClear category filter150,000 miles · Sep 11, 2013
Electrical SystemEngineEquipment Adaptive/mobilityFire
WHILE WAITING FOR MY WIFE TO COME OUT OF A STORE WITH TRUCK RUNNING I NOTICED A LIGHT FLICKERING IN THE STORE WINDOW. MY WIFE CAME OUT OF THE STORE AND GOT INTO THE TRUCK. WHILE BACKING OUT I NOTICED THE FLICKERING LIGHT IN THE WINDOW COMING WITH ME. WHEN I STOPPED THE TRUCK I NOTICED SMOKE COMING UP OVER MY HOOD THEN THE CAB OF…
Read full complaint
WHILE WAITING FOR MY WIFE TO COME OUT OF A STORE WITH TRUCK RUNNING I NOTICED A LIGHT FLICKERING IN THE STORE WINDOW. MY WIFE CAME OUT OF THE STORE AND GOT INTO THE TRUCK. WHILE BACKING OUT I NOTICED THE FLICKERING LIGHT IN THE WINDOW COMING WITH ME. WHEN I STOPPED THE TRUCK I NOTICED SMOKE COMING UP OVER MY HOOD THEN THE CAB OF THE TRUCK STARTED TO GET WARM. I NOTICED A BURNING SMELL AND TOLD MY WIFE THAT I THINK MY TRUCK WAS ON FIRE. I GOT OUT OF THE TRUCK, WENT TO THE FRONT AND SAW THE CONDENSER FAN MOTOR ON FIRE. I WAS ABLE TO EXTINGUISH THE FIRE WITH A CAN OF COKE THAT WAS ON THE GROUND. A LITTLE WHILE LATER IT FLAMED UP AGAIN AND HAD TO GET A BUCKET OF WATER FROM THE STORE CLERK. THE FIRE CAUSED OVER $4100.00 IN DAMAGE. I HAD A RECALL ON THIS CONDENSER FAN MOTOR, HAD IT TAKEN CARE OF IN FEBRUARY 2012. CAUGHT FIRE ON 09/02/2013. *TR
NHTSA ODI #10543012
111,000 miles · Aug 2, 2013
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 NISSAN TITIAN. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED TO THE CONTACT THAT THE AIR CONDITIONING CONDENSER FAN HAD MELTED THE ENGINE WIRING HARNESS, WHICH NEEDED TO BE REPLACED. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITIAN. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED TO THE CONTACT THAT THE AIR CONDITIONING CONDENSER FAN HAD MELTED THE ENGINE WIRING HARNESS, WHICH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
NHTSA ODI #10533284
103,000 miles · Aug 1, 2013
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, SMOKE EMERGED FROM THE HOOD AS THE VEHICLE CAUGHT FIRE UNDER THE HOOD AREA. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT AND A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTI…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, SMOKE EMERGED FROM THE HOOD AS THE VEHICLE CAUGHT FIRE UNDER THE HOOD AREA. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT AND A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT INSPECTED TO DETERMINE THE CAUSE OF THE FIRE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.
NHTSA ODI #10533147
31,740 miles · May 31, 2013
Electrical SystemExterior Lighting
GOING HOME FROM WORK, WHILE DRIVING EVERY TIME I PUT THE RIGHT TURN SIGNAL ON I NOTICED THE LIGHT AT THE DASHBOARD FLASHES SO WEIRD AND THEN DISAPPEAR. I MADE FIVE RIGHT TURNS THAT NIGHT ALL ACTING THE SAME THING. THE NEXT DAY I TOOK THE TRUCK TO THE GARAGE AND HAD IT CHECKED THEY FOUND OUT THAT THE WIRING INSIDE THE LAMP ASSEMB…
Read full complaint
GOING HOME FROM WORK, WHILE DRIVING EVERY TIME I PUT THE RIGHT TURN SIGNAL ON I NOTICED THE LIGHT AT THE DASHBOARD FLASHES SO WEIRD AND THEN DISAPPEAR. I MADE FIVE RIGHT TURNS THAT NIGHT ALL ACTING THE SAME THING. THE NEXT DAY I TOOK THE TRUCK TO THE GARAGE AND HAD IT CHECKED THEY FOUND OUT THAT THE WIRING INSIDE THE LAMP ASSEMBLY WAS MELTED, THE WIRE WAS TIED WITH PLASTIC STRING WRAP SO TIGHT THAT MADE THE INSULATION OF THE WIRE MELTS AND CREATED A SHORT CIRCUIT. THE WHOLE INSIDE OF THE COMBINATION LAMP ASSEMBLY REAR, RH OF MY TRUCK WAS MELTED. THEY CUT THE PLASTIC STRING WRAP AND THEN PUT SOME ELECTRICAL TAPE ON THE WIRES, THEY HAVE A HARD TIME OF PUTTING THE LAMP ASSEMBLY BACK INTO THE TRUCK AND UNTIL NOW I DID NOT REPLACE THE RH REAR COMBINATION LAMP ASSEMBLY. *TR
NHTSA ODI #10514460
Mileage unknown · Jun 12, 2012
Electrical SystemEngineEquipment
2006 NISSAN TITAN. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE AND RECALL ISSUES *TGW THE CONSUMER STATED THE BRAKE BOOSTER WAS DEFECTIVE AND HAS NOT WORKED PROPERLY, SINCE THE VEHICLE WAS PURCHASED. IT WOULD TAKE EXTREME FORCE TO STOP THE VEHICLE. THE FUEL LEVEL SENDING UNIT, AIR CONDITIONING CONDENSER FAN MOTOR, ENGINE CONT…
Read full complaint
2006 NISSAN TITAN. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE AND RECALL ISSUES *TGW THE CONSUMER STATED THE BRAKE BOOSTER WAS DEFECTIVE AND HAS NOT WORKED PROPERLY, SINCE THE VEHICLE WAS PURCHASED. IT WOULD TAKE EXTREME FORCE TO STOP THE VEHICLE. THE FUEL LEVEL SENDING UNIT, AIR CONDITIONING CONDENSER FAN MOTOR, ENGINE CONTROL MODULE RELAY, INSTRUMENT PANEL FUEL GAUGE ALL MALFUNCTIONED. ALSO, THE LOWER CONTROL LINKS THAT ATTACHED TO THE CHASSIS MOUNTING FAILED.
NHTSA ODI #10461531
92,450 miles · May 10, 2012
Electrical System
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THE WIRING HARNESS IS BROKEN BETWEEN ON THE REAR DRIVER SIDE DOOR. THE DEALER WAS NOTIFIED OF THE PROBLEM. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 92,450 AND THE CURRENT MILEAGE 92,850.
NHTSA ODI #10458006
120,000 miles · Mar 26, 2012
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
CATALYTIC CONVERTER WENT OUT & NEEDED TO BE REPLACED IN ORDER TO PASS A SMOG! $2400 TO FIX AND THE MECHANIC SAID THERE WAS NOTHING LEFT OF THE HONEYCOMB INSIDE WHEN THERE SHOULD BE!! RECALL NEEDS TO BE ISSUED!! *TR
NHTSA ODI #10453118
94,000 miles · Jan 3, 2012
Electrical SystemEngine And Engine Cooling
TRAVELING IN HEAVY MORNING TRAFFIC AND THE VEHICLE SIMPLY QUIT IN THE MIDST OF HUNDREDS OF VEHICLES. IT WOULD NOT FULLY RESTART BUT WOULD ONLY ROUGH IDLE A TIME OR TWO. VEHICLE HAD TO BE TOWED AND IT WAS DETERMINED THAT THE IPDM/ECM HAD FAILED. THE PARTS WERE REPLACED AND AS SOON AS I BEGAN LEAVE THE REPAIR FACILITY THE "SERV…
Read full complaint
TRAVELING IN HEAVY MORNING TRAFFIC AND THE VEHICLE SIMPLY QUIT IN THE MIDST OF HUNDREDS OF VEHICLES. IT WOULD NOT FULLY RESTART BUT WOULD ONLY ROUGH IDLE A TIME OR TWO. VEHICLE HAD TO BE TOWED AND IT WAS DETERMINED THAT THE IPDM/ECM HAD FAILED. THE PARTS WERE REPLACED AND AS SOON AS I BEGAN LEAVE THE REPAIR FACILITY THE "SERVICE ENGINE SOON" LIGHT CAME ON. IT WAS DETERMINED THAT ONE OF THE CATALYTIC CONVERTERS HAD FAILED...DUE TO RAW FUEL BEING DUMPED INTO IT AS RESULT OF THE FAILURE OF THE IPDM/ECM. A FEW DAYS LATER, AS I WAS RESEARCHING CATALYTIC CONVERTERS ONLINE, I CAME ACROSS A NISSAN RECALL - NHTSA CAMPAIGN ID 10V517000 AND REALIZED THAT THIS WAS THE EXACT SITUATION BUT THAT I HAD NOT RECEIVED NOTICE OF SAID RECALL. I CONTACTED NISSAN REGARDING THIS SITUATION AND REIMBURSEMENT FOR THE REPAIRS AND THEY ADVISED THAT I'D HAVE TO TAKE THE VEHICLE TO ONE OF THEIR DEALERS FOR INSPECTION BEFORE THEY'D CONSIDER REIMBURSING. I DID SO AND THEY DID REIMBURSE FOR THE IPDM/ECM REPAIRS. HOWEVER, WHEN I ASKED ABOUT THE CATALYTIC CONVERTER FAILURE...WHICH WAS AN IMMEDIATE RESULT OF THE IPDM/ECM FAILURE, THE DEALER (AND NISSAN CONSUMER AFFAIRS) INDICATED THAT I'D HAVE TO GET AN ESTIMATE & "RESTART" THE PROCESS. WHILE DOING SO, I LEARNED OF NUMEROUS EXAMPLES OF THIS VERY SAME THING HAPPENING WHEN IPDM/ECM FAILS & DUMPS RAW FUEL INTO THE CATALYTIC CONVERTER. SO, I OBTAINED THE ESTIMATE FROM A NISSAN DEALER AND RECONTACTED NISSAN CONSUMER AFFAIRS AND BEGAN THE PROCESS AGAIN. IN THE MEANTIME, I DID LEARN THAT IT IS NOT SAFE TO DRIVE A VEHICLE WITH A DAMAGED CONVERTER AS IT CAN CAUSE THE ENGINE TO FAIL...THEREBY CAUSING A DANGEROUS SITUATION ON THE ROAD...FOR MYSELF AND OTHERS. NISSAN HAS NOW REFUSED TO PAY TO REPAIR THE CATALYTIC CONVERTER WHICH WAS DAMAGED BY THE FAILURE OF THEIR RECALLED PART...AND I AM WONDERING IF YOUR OFFICE CAN HELP ME IN THIS PARTICULAR SITUATION. *TR
NHTSA ODI #10442154
Mileage unknown · Dec 6, 2011
Electrical SystemEngine And Engine Cooling
I OWN A 4X4 LOADED 2006 TITAN LE WHICH IS MY PRIMARY FAMILY VEHICLE. AROUND 80K, ECM MODULE WENT OUT CAUSING CAR TO STALL OUT AND LOSE ALL POWER IN THE MIDDLE OF TRAFFIC (WITH MY KIDS). LUCKY NOT TO BE NAILED BY AN ON-COMING CAR, I HAD THE CAR TOWED TO THE DEALERSHIP AND MODULE WAS REPLACED DUE TO RECALL. ONE WEEK LATER WHILE V…
Read full complaint
I OWN A 4X4 LOADED 2006 TITAN LE WHICH IS MY PRIMARY FAMILY VEHICLE. AROUND 80K, ECM MODULE WENT OUT CAUSING CAR TO STALL OUT AND LOSE ALL POWER IN THE MIDDLE OF TRAFFIC (WITH MY KIDS). LUCKY NOT TO BE NAILED BY AN ON-COMING CAR, I HAD THE CAR TOWED TO THE DEALERSHIP AND MODULE WAS REPLACED DUE TO RECALL. ONE WEEK LATER WHILE VACATIONING IN THE MOUNTAINS THE BATTERY RANDOMLY FRIED, WE REPLACED IT. HOWEVER IMMEDIATELY FOLLOWING, THE ANTI-THEFT ALARM WOULD RANDOMLY SOUND OFF, THE DVD PLAYER WOULDN'T WORK (HASN'T WORKED SINCE), THE SUNROOF WAS MALFUNCTIONING AND WOULDN'T OPEN AND CLOSE PROPERLY. ONCE WE RETURNED, THE DEALERSHIP COULDN'T FIND ANYTHING WRONG (EXCEPT THE DVD PLAYER, WHICH NO ONE COULD EXPLAIN). ABOUT TWO WEEKS LATER THE CHECK ENGINE LIGHT CAME ON AND WE FOUND THAT THE FIRST CATALYTIC CONVERTER ON THE PASSENGER SIDE HAD BLOWN..FOLLOWED NOT LONG AFTER BY CRACKED EXHAUST MANIFOLDS AND THE DRIVERS SIDE CATALYTIC CONVERTER BAD..DEALERSHIP WANTS $3000 JUST FOR THE CATALYTIC CONVERTERS!!! I SHOULD NOT BE RESPONSIBLE FOR THE COST OF REPLACEMENT! THIS CLEARLY IS A MANUFACTURERS DEFECT AND NOT A ISOLATED CASE, NISSAN MUST DO SOMETHING ABOUT THIS! I HEAR RUMORS OF A CLASS ACTION...IT IS A HUGE SAFETY HAZARD!! I'M HOPING THEY DO THE RIGHT THING AND JUST FIX IT, WITHOUT HAVING TO GET LAWYERS INVOLVED. *TR
NHTSA ODI #10438791
136,000 miles · Aug 19, 2011
Electrical System
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 30 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE PROBLEM MIGHT HAD BEEN CAUSED BY A DEFECTIVE FUEL FILTER OR BATTERY. AS A PRECAUTION THE CONTACT REPLACED BOTH PARTS. THE REPAIR DID NOT CORRECT THE FAILURE. THE MA…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 30 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE PROBLEM MIGHT HAD BEEN CAUSED BY A DEFECTIVE FUEL FILTER OR BATTERY. AS A PRECAUTION THE CONTACT REPLACED BOTH PARTS. THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO REFERRED HIM TO THE DEALER TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 136,000.
NHTSA ODI #10420130
Official recalls
5Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration