Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reports
220,000 miles · Mar 5, 2018
Electrical System
I WAS DRIVING DOWN THE HWY AND MY ENGINE SHUT DOWN. I MADE IT TO THE SHOULDER, PUT IT IN PARK TURN THE KEY OFF THEN STARTS RIGHT BACK UP. STARTED YESTERDAY, AND DOES IT ABOUT EVERY TEN MILES. STARTS RIGHT BACK UP EVERY TIME. SOUNDS LIKE THE IPDM BUT FENTON NISSAN IN LEES SUMMIT MISSOURI SAID MY TRUCKS NOT RECALLED. PLEASE HELP! …
Read full complaint
I WAS DRIVING DOWN THE HWY AND MY ENGINE SHUT DOWN. I MADE IT TO THE SHOULDER, PUT IT IN PARK TURN THE KEY OFF THEN STARTS RIGHT BACK UP. STARTED YESTERDAY, AND DOES IT ABOUT EVERY TEN MILES. STARTS RIGHT BACK UP EVERY TIME. SOUNDS LIKE THE IPDM BUT FENTON NISSAN IN LEES SUMMIT MISSOURI SAID MY TRUCKS NOT RECALLED. PLEASE HELP! NO SPIT AND SPUTTER, IT JUST DIES OUT OF NO WHERE. IT ALMOST CAUSED A REAR END COLLISION WHILE PULLIN ON INTERSTATE. THIS RELAY PROBLEM IS VERY UNSAFE. PLEASE HELP!
NHTSA ODI #11076245
190,000 miles · Feb 28, 2018
Power Train
COMPLETE TRANSMISSION FAILURE DUE TO FAULTY RADIATOR DESIGN. COOLANT MIXED WITH ATF, FROM INTERNAL TRANSFER COOLER LEAK.
NHTSA ODI #11075451
165,000 miles · Feb 11, 2018
Power Train
THE AXLE SHAFT ON THE FRONT DIFFERENTIAL CAME OUT CAUSING FAILURE TO THE FRONT DIFFERENTIAL
NHTSA ODI #11072162
Mileage unknown · Jan 29, 2018
Electrical System
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WITHOUT WARNING AND RESTARTED AFTER SEVERAL ATTEMPTS. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WITHOUT WARNING AND RESTARTED AFTER SEVERAL ATTEMPTS. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11065621
150,447 miles · Nov 27, 2017
Electrical SystemSeat Belts
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WIRING HARNESS FAILED. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER FRONTAL SEAT BELTS MAY NOT OPERATE AS INTENDED IN THE EVENT OF A CRASH. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER SEAT BELTS MAY RETRACT ABNORMALLY AND CAUSE EXTREME T…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WIRING HARNESS FAILED. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER FRONTAL SEAT BELTS MAY NOT OPERATE AS INTENDED IN THE EVENT OF A CRASH. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER SEAT BELTS MAY RETRACT ABNORMALLY AND CAUSE EXTREME TIGHTNESS. THE CONTACT WAS REPAIRING THE VEHICLE HIMSELF. THE CONTACT LOCATED THE WIRING HARNESS ON THE REAR PASSENGER DOOR AND DISCOVERED THAT IT DID NOT HAVE A PROTECTIVE SHIELD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 150,447.
NHTSA ODI #11048741
124,000 miles · Nov 8, 2017
Service Brakes
I AM THE ORIGINAL OWNER 2005 TITAN LE. I HAVE EXPERIENCED A BRAKING ISSUE 8-10 TIMES. WHILE DRIVING IN NORMAL TRAFFIC CONDITIONS ON THE FREEWAY TRAFFIC BEGINS TO SLOW, I APPLIED THE BRAKES. THE ENTIRE TRUCK BEGAN TO VIOLENTLY SHUTTER, THE RED BRAKE ICON ON THE DASH CAME ON, AND THE BRAKE PEDDLE WENT ALMOST ALL THE WAY TO THE …
Read full complaint
I AM THE ORIGINAL OWNER 2005 TITAN LE. I HAVE EXPERIENCED A BRAKING ISSUE 8-10 TIMES. WHILE DRIVING IN NORMAL TRAFFIC CONDITIONS ON THE FREEWAY TRAFFIC BEGINS TO SLOW, I APPLIED THE BRAKES. THE ENTIRE TRUCK BEGAN TO VIOLENTLY SHUTTER, THE RED BRAKE ICON ON THE DASH CAME ON, AND THE BRAKE PEDDLE WENT ALMOST ALL THE WAY TO THE FLOOR. I HAD TO PULL TO THE RIGHT TO AVOID HITTING THE VEHICLE IN FRONT OF ME. THE HARDER YOU PUSH THE MORE THE BRAKES SEEM TO FAIL AND THE TRUCK SHAKES HARDER. THE ONLY THING THAT FIXES THE ISSUE IS TO STOP THE TRUCK AND TURN IT OFF AND RESTART IT. EVERYTHING GOES BACK TO NORMAL AS IF IT DIDN'T HAPPEN. THIS HAS HAPPENED TO ME 8-10 TIMES SINCE OWNING THIS TRUCK AS NEW. I HAVE READ MANY INCIDENTS ONLINE IN BLOGS ETC.THAT ARE ALMOST EXACTLY AS I HAVE DESCRIBED. THE DEALER SAID IT WAS AN ISOLATED INCIDENT. I WHOLE HEARTILY DISAGREE WITH THEM. THIS IS AN ISSUE THAT IS ULTIMATELY GOING TO CAUSE INJURY OR DEATH. THIS HAS HAPPENED TO ME AT FREEWAY SPEEDS, NORMAL RESIDENTIAL SPEEDS (25MPH) AND EVERYWHERE IN BETWEEN. LAST INCIDENT OCCURRED ON 11/8/2017.
NHTSA ODI #11044711
Mileage unknown · Sep 18, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER (RIVERHEAD NISSAN, 1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) WHO STATED THAT THEY REPAIRED THE VEHICLE WITH A WARRANTY REPAIR CONCERNING THE EXHAUST MANIFOLD. THE CONTACT REPORTED TO THE DEALER AND THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER (RIVERHEAD NISSAN, 1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) WHO STATED THAT THEY REPAIRED THE VEHICLE WITH A WARRANTY REPAIR CONCERNING THE EXHAUST MANIFOLD. THE CONTACT REPORTED TO THE DEALER AND THE MANUFACTURER THAT THE REPLACEMENT PART FAILED AGAIN AND WAS UNCERTAIN IF THE MANUFACTURER WOULD PROVIDE A SOLUTION WITH NO RECALL CAMPAIGN. THE WARRANTY REPLACEMENT PART PROVIDED NO SOLUTION AND, A FEW YEARS LATER, THERE WAS A CRACK AND LEAK WHICH FROM THE EXHAUST MANIFOLD. IN ADDITION, THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISOCNNECT.
NHTSA ODI #11024081
Mileage unknown · Aug 16, 2017
Air Bags
TAKATA RECALL .A RECALL HAS BEEN NOTED FFOR THIS MATTER. I TOOK MY TRUCK TO THE DEALER THE DAY AFTER I FOUND OUT THROUGH MEDIA. THE DEALER INFORMED ME THEY COULD NOT COMPLETE THE RECALL DUE TO A SYSTEM ISSUE WITH MY TRUCK NOT ALLOWING THE UPLOAD OF DATA. THE DEALER STATED TO COMPLETE THE RECALL I WOULD NEED TO PURCHASE A $900 UN…
Read full complaint
TAKATA RECALL .A RECALL HAS BEEN NOTED FFOR THIS MATTER. I TOOK MY TRUCK TO THE DEALER THE DAY AFTER I FOUND OUT THROUGH MEDIA. THE DEALER INFORMED ME THEY COULD NOT COMPLETE THE RECALL DUE TO A SYSTEM ISSUE WITH MY TRUCK NOT ALLOWING THE UPLOAD OF DATA. THE DEALER STATED TO COMPLETE THE RECALL I WOULD NEED TO PURCHASE A $900 UNIT TO ALLOW MY TRUCK TO UPLOAD THE DATA REQUIRED. I AM FURIOUS THAT DUE TO A RECALL, I NEED TO PAY $900 TO COMPLETE THE PROCESS. THERE ARE NO AFTERMARKET PARTS ON MY TRUCK SO EVERYTHING IS FACTORY ISSUED.
NHTSA ODI #11015620
Mileage unknown · Aug 16, 2017
Power Train
I HAVE BOTH LEFT AND RIGHT REAR AXLE SEALS REQUIRING REPLACEMENT DUE TO SEVERE LEAKING. DEALER ESTIMATE AT $600.00. I HAVE READ FORUMS REGARDING THIS ISSUE AND IT APPEARS TO BE JUST SHORT OF A RECALL? 2005 NISSAN TITAN 2WD WITH 84,000 MILES ON IT.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration