Illustration2005 NISSAN TITAN COMPLETE REAR END FAILURE. NO WARNING JUST LOCKED UP WHILE GOING DOWN THE ROAD. *TR
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsDRIVERS DOOR IS DIFFICULT TO OPEN WHEN OUTSIDE TEMP IS BELOW 15 DEGREES, AND WHEN I GET THE DOOR OPEN AND CLOSE IT, IT WILL NOT OPEN AGAIN WHEN I CLOSE IT TRAPPING ME INSIDE. I HAVE TO CRAWL OVER THE PASSENGER SEAT TO GET OUT. I THINK THAT THIS IS A SAFETY CONCERN BECAUSE IF THE VEHICLE CAUGHT ON FIRE I WOULD NOT BE ABLE TO GE…
Read full complaint
DRIVERS DOOR IS DIFFICULT TO OPEN WHEN OUTSIDE TEMP IS BELOW 15 DEGREES, AND WHEN I GET THE DOOR OPEN AND CLOSE IT, IT WILL NOT OPEN AGAIN WHEN I CLOSE IT TRAPPING ME INSIDE. I HAVE TO CRAWL OVER THE PASSENGER SEAT TO GET OUT. I THINK THAT THIS IS A SAFETY CONCERN BECAUSE IF THE VEHICLE CAUGHT ON FIRE I WOULD NOT BE ABLE TO GET OUT OR IF I GOT STUCK ON TRAIN TRACKS ETC. NISSAN IS AWARE OF THE PROBLEM AND EVEN HAS A TECHNICAL SERVICE BULLETIN ON THEIR WEBSITE. THE BULLETIN IS NTB05-118A. I CONTACTED NISSAN AND THE REP STATED THAT IT WAS NOT THEIR PROBLEM. *TR
THERE WAS A NOISE FROM THE REAR OF THE TRUCK AND AN ODD ODOR. IT ALMOST FELT LIKE A TRANSMISSION SLIP ONCE IN A WHILE DRIVING. I DROVE IT HOME AS THE NOISE WAS GETTING WORSE AND HAD IT TOWED TO THE DEALER. THEIR TECH DROVE IT OFF THE LOT TO "CHECK IT OUT" AFTER I TOLD THEM ABOUT THE PROBLEM AND THAT IT WAS GETTING WORSE. THE…
Read full complaint
THERE WAS A NOISE FROM THE REAR OF THE TRUCK AND AN ODD ODOR. IT ALMOST FELT LIKE A TRANSMISSION SLIP ONCE IN A WHILE DRIVING. I DROVE IT HOME AS THE NOISE WAS GETTING WORSE AND HAD IT TOWED TO THE DEALER. THEIR TECH DROVE IT OFF THE LOT TO "CHECK IT OUT" AFTER I TOLD THEM ABOUT THE PROBLEM AND THAT IT WAS GETTING WORSE. THE REAR END BLEW OUT AND SPRAYED FLUID ALL OVER THE UNDERCARRIAGE, THE BACK OF THE TAILGATE, EVERYWHERE. THE DEALER JUST SAID IT HAD TO BE REPLACED. PERIOD. THIS TRUCK IS WELL MAINTAINED BY THE SAME DEALERSHIP AND I AM TOLD THAT THE REAR END/DIFFERENTIAL IS SEALED AT THE FACTORY AND IS NOT A PART OF A MAINTENANCE ITEM. IT IS NOT USED FOR TOWING, OFF ROADING OR ANYTHING ELSE LIKE THAT. I AM THE ONLY ONE WHO DRIVES THE TRUCK. I THINK IT WOULD HAVE BEEN VERY DANGEROUS HAD IT GONE OUT WHILE I WAS DRIVING IT. THE DEALERSHIP HAD TO HAVE IT TOWED BACK TO THE SHOP. IT IS MY UNDERSTANDING THAT THIS IS A RATHER COMMON PROBLEM BASED ON THE COMPLAINTS THAT HAVE BEEN FILED. IT IS ALSO AN EXPENSIVE PROBLEM AT $2300.00 IN MY ESTIMATION. I REQUESTED THAT THEY KEEP THE PART FOR FURTHER EVALUATION. *TR
I OWN A 2005 NISSAN TITAN PICKUP WHICH I PURCHASED NEW. THE VEHICLE HAS 57,000 MILES. MY DRIVEWAY IS STEEP AS I LIVE IN A REMOTE LOCATION. ABOUT TWO WEEKS AGO I WAS HEADED TO TOWN. THE REAR END WENT OUT AND MY TITAN SLID OFF THE ROADWAY. THE MECHANIC WHO IS REPAIRING MY VEHICLE TOLD ME THIS WAS A VERY COMMON PROBLEM WITH M…
Read full complaint
I OWN A 2005 NISSAN TITAN PICKUP WHICH I PURCHASED NEW. THE VEHICLE HAS 57,000 MILES. MY DRIVEWAY IS STEEP AS I LIVE IN A REMOTE LOCATION. ABOUT TWO WEEKS AGO I WAS HEADED TO TOWN. THE REAR END WENT OUT AND MY TITAN SLID OFF THE ROADWAY. THE MECHANIC WHO IS REPAIRING MY VEHICLE TOLD ME THIS WAS A VERY COMMON PROBLEM WITH MY MODEL OF VEHICLE. I CHECKED ON LINE AND FOUND MANY SIMILAR INCIDENTS. I CONTACTED NISSAN AND FOUND THERE WAS NO RECALL REGARDING THIS. REPAIR COST IS NOW OVER $2000. *TR
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE BEFORE IT STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE REAR SUSPENSION BROKE IN HALF. HE WAS ALSO INFORMED THAT THIS WAS A KNOWN FAILURE. THE VEHICLE WAS BEING R…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE BEFORE IT STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE REAR SUSPENSION BROKE IN HALF. HE WAS ALSO INFORMED THAT THIS WAS A KNOWN FAILURE. THE VEHICLE WAS BEING REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 69,000. THE VIN WAS UNAVAILABLE.
2005 NISSAN TITAN REAR AXLE SEAL LEAKING AT 42,000 MILES. DEALER SAID THERE IS A DEFECT BUT NOT A RECALL. THEY WANT TO REPLACE WHOLE AXLE TO PREVENT SEAL LEAKING AGAIN. THERE ARE THOUSANDS OF COMPLAINTS ON THIS ISSUE AND IT IS A SAFETY ISSUE THAT SHOULD BE RECALLED. *TR
1. NORMAL, HIGHWAY AND LOCAL DRIVING OF VEHICLE. NO ABUSIVE VEHICLE TREATMENT. A MECHANIC WAS ABLE TO DO A TEMPORARY REPAIR TO ENABLE US TO DRIVE HOME AND WE THEN TOOK THE VEHICLE TO OUR LOCAL GARAGE TO HAVE IT FULLY INSPECTED. 2. THE FRONT RIGHT AXLE (HALF-SHAFT) OF THE FOUR WHEEL DRIVE FELL OUT OF THE FRONT DIFFERENTIAL …
Read full complaint
1. NORMAL, HIGHWAY AND LOCAL DRIVING OF VEHICLE. NO ABUSIVE VEHICLE TREATMENT. A MECHANIC WAS ABLE TO DO A TEMPORARY REPAIR TO ENABLE US TO DRIVE HOME AND WE THEN TOOK THE VEHICLE TO OUR LOCAL GARAGE TO HAVE IT FULLY INSPECTED. 2. THE FRONT RIGHT AXLE (HALF-SHAFT) OF THE FOUR WHEEL DRIVE FELL OUT OF THE FRONT DIFFERENTIAL UNIT. HAD THIS HAPPENED AT A HIGHER SPEED IN 4 WHEEL DRIVE OR EVEN 2 WHEEL DRIVE A LOSS OF VEHICLE CONTROL COULD OCCUR RESULTING IN A CRASH. 3. THE MANUFACTURER HAS NOT ISSUED A RECALL OF THE VEHICLE EVEN THOUGH THEY REALIZE THERE WAS A FAULTY BEARING DESIGN. THE BEARING HAS SINCE BEEN REDESIGNED BUT VEHICLES WITH THE DEFECTIVE BEARING ARE STILL IN SERVICE. THE LOCAL VEHICLE DEALER'S MECHANICS HAVE SAID THEY HAVE SEEN THESE INCIDENTS AND CAN REPLACE THE BEARING AT MY EXPENSE SINCE THE VEHICLE IS OUT OF WARRANTY (THE VEHICLE HAS 76,00 MILES -- NO OFFROAD -- AND THE WARRANTY IS ONLY GOOD FOR 60,000). HOWEVER, THIS IS A MANUFACTURER'S DEFECT THAT IS KNOWN TO THE MANUFACTURER AND SHOULD HAVE BEEN RECALLED AND REPLACED A LONG TIME AGO. I AM REQUESTING THAT YOU INVESTIGATE THIS MATTER AS THE MANUFACTURER SEEMS TO WANT TO IGNORE THIS SAFETY ISSUE. *TR
BOTH REAR AXLE SEALS LEAKING. *TR
EXHAUST MANIFOLD LEAKING FOR THE SECOND TIME. BANK 1 SIDE WAS BAD BEFORE THE 80 EMISSIONS WARRANTY WAS UP, HOWEVER DEALERSHIP WOULDN'T DO IT, SO WE PURCHASED ANOTHER OEM MANIFOLD/CAT AND HAD ANOTHER SHOP REPLACE IT. NOW 2 YEARS LATER THAT SIDE HAS FAILED AND IS LEAKING AGAIN. THE CATALYTIC CONVERTER HAS FAILED ON THAT SIDE ALSO…
Read full complaint
EXHAUST MANIFOLD LEAKING FOR THE SECOND TIME. BANK 1 SIDE WAS BAD BEFORE THE 80 EMISSIONS WARRANTY WAS UP, HOWEVER DEALERSHIP WOULDN'T DO IT, SO WE PURCHASED ANOTHER OEM MANIFOLD/CAT AND HAD ANOTHER SHOP REPLACE IT. NOW 2 YEARS LATER THAT SIDE HAS FAILED AND IS LEAKING AGAIN. THE CATALYTIC CONVERTER HAS FAILED ON THAT SIDE ALSO. NISSAN HAS NOT OFFERED A RECALL. EXHAUST MANIFOLD LEAKING ALLOWS EXHAUST FUMES TO NOT BE VENTED CORRECTLY AND THE FUMES CAN COME INTO THE CABIN OF THE VEHICLE. I HAVE SPOKEN WITH THE DEALERSHIP AND IT SHOULD BE NOTED I'M OUT OF THE 80 K EMISSIONS WARRANTY. THE OEM EQUIPMENT IS NOT UP TO PAR. *TR
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE DEALER WAS CONTACTED WHO STATED THAT THE FUEL PUMP WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS AWAITING A RESPONSE. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED DE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE DEALER WAS CONTACTED WHO STATED THAT THE FUEL PUMP WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS AWAITING A RESPONSE. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED DEALER. THE CURRENT MILEAGE WAS APPROXIMATELY 162,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.