NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
891 reports90,500 miles · Apr 24, 2017
Engine
CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NO…
Read full complaint
CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NOT SUPPORTING THE REQUIRED REPLACEMENT WHICH SHOULD BE FREE. THE REPAIR COST ARE IN THE THOUSANDS NOT ACCEPTABLE WHEN IT IS NISSAN POOR DESIGN ALL ALL TRUCKS WITH THESE MANIFOLDS ARE AFFECTED.
NHTSA ODI #10980273
145,000 miles · Apr 17, 2017
Power Train
THE FRONT DRIVERS SIDE AXLE KEEPS FALLING OUT OF THE TRANSFER CASE. I BELIEVE DUE TO A C-CLIP FAILURE. THIS HAPPENS WHEN THE TRUCK IS IN MOTION AND THE STEERING WHEEL IS TURNED.
NHTSA ODI #10978973
Mileage unknown · Mar 3, 2017
Fuel/propulsion System
ON FEBRUARY 25, 2017 MY SON WAS GOING DOWN THE ROAD AND HIS 2005 NISSAN TITAN TRUCK COMPLETELY DIED, LOST ALL POWER STEERING, BRAKES, EVERYTHING. MY SON WAS ABLE TO GET THE TRUCK OFF THE BUSY ROAD WITHOUT GETTING REAR ENDED, WHICH WAS HARD TO DO FOR A 20 YEAR OLD. ONCE WE HAD THE VEHICLE DIAGNOSED, WE WERE TOLD IT WAS A FAULTY…
Read full complaint
ON FEBRUARY 25, 2017 MY SON WAS GOING DOWN THE ROAD AND HIS 2005 NISSAN TITAN TRUCK COMPLETELY DIED, LOST ALL POWER STEERING, BRAKES, EVERYTHING. MY SON WAS ABLE TO GET THE TRUCK OFF THE BUSY ROAD WITHOUT GETTING REAR ENDED, WHICH WAS HARD TO DO FOR A 20 YEAR OLD. ONCE WE HAD THE VEHICLE DIAGNOSED, WE WERE TOLD IT WAS A FAULTY FUEL LEVEL SENSOR UNIT. THE VEHICLE SHOWED OVER 1/4 OF A TANK OF GAS, BUT IN FACT, IT WAS EMPTY. UPON DOING SOME RESEARCH, I FOUND OTHER 2005 NISSAN TITAN'S WERE RECALLED WITH THIS SAME ISSUE, HOWEVER, NISSAN TOLD ME, THAT MY VIN WAS NOT INVOLVED IN THE RECALL. THIS CONCERNS ME BECAUSE MY SON COULD HAVE BEEN SERIOUSLY INJURED OR KILLED FROM THE TRUCK DYING AS HE WAS GOING 50 MPH DOWN THE ROAD. I HAVE TRIED TO SPEAK WITH NISSAN, ASKING THEM TO LOOK INTO MY PARTICULAR VEHICLE, SINCE THERE IS A PAST HISTORY OF THIS PART FAILING ON OTHER TITANS. AFTER 3 PHONE CALLS, ALL THEY WILL TELL ME IS, IT ISN'T THEIR FAULT, THE VEHICLE IS OUT OF WARRANTY AND RECALL DOESN'T INVOLVE MY VIN. I AGAIN ASKED THEM TO CONSIDER EXPANDING THE RECALL TO INCLUDE MY VEHICLE AND WAS TOLD NO. THE TRUCK IS CURRENTLY IN THE SHOP TO GET THIS FIXED, BUT IT'S A SHAME THAT NISSAN WON'T EVEN CONSIDER LOOKING INTO THIS WHEN THEY KNOW IT'S AN ISSUE WITH OTHER TITANS. THIS TRUCK HAS BEEN IN THE FAMILY SINCE IT WAS PURCHASED BRAND NEW.
NHTSA ODI #10958520
125,000 miles · Feb 10, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO FUNCTION AND THE FUEL GAUGE FAILED TO PROVIDE THE ACTUAL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT I…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO FUNCTION AND THE FUEL GAUGE FAILED TO PROVIDE THE ACTUAL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #10953890
122,000 miles · Feb 9, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE F…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000. UPDATED 04/10/17 LJ *CN
NHTSA ODI #10953695
110,000 miles · Oct 28, 2016
Fuel System, OtherFuel/propulsion System
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM RECALL FOR 2005 NISSAN TITAN - NISSAN CLEARLY HAS A RECALL FOR THE 2005 NISSAN TITAN FUEL GAUGE THAT IS NOT DISPLAYING CORRECTLY. UPON CONTACTING NISSAN, THEY HAVE SAID THE VIN I PROVIDED IS NOT AFFECTED WHICH IS RIDICULOUS AS MY 2005 NISSAN HAS THE SAME PROBLEM AS THE 340,000 TRUCK…
Read full complaint
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM RECALL FOR 2005 NISSAN TITAN - NISSAN CLEARLY HAS A RECALL FOR THE 2005 NISSAN TITAN FUEL GAUGE THAT IS NOT DISPLAYING CORRECTLY. UPON CONTACTING NISSAN, THEY HAVE SAID THE VIN I PROVIDED IS NOT AFFECTED WHICH IS RIDICULOUS AS MY 2005 NISSAN HAS THE SAME PROBLEM AS THE 340,000 TRUCKS THAT ARE AFFECTED. NISSAN HAS CLEARLY NOT INCLUDED ALL VIN'S THAT ARE AFFECTED. THIS IS A DANGEROUS PROBLEM AS THERE IS NOT INDICATION OF HOW MUCH FUEL IS IN THE VEHICLE SINCE THE GAUGE WILL NOT FUNCTION PROPERLY. IF THE VEHICLE QUITS ON A HWY DUE TO RUNNING OUT OF FUEL, NISSAN SHOULD BE COMPLETELY LIABLE FOR ANY AND ALL DAMAGE, INJURIES THAT THIS MAY CAUSE ON AN OPEN HIGHWAY. *TR
NHTSA ODI #10919913
53,000 miles · Oct 19, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT HEARD AN ABNORMAL NOISE AND OBSERVED THAT THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS DIAGNOSED BY THE CONTACT HIMSELF. THE CONTACT STATED THAT HE WOULD ATTEMPT TO WELD THE MANIFOLD. IF NOT, THE EXHAUST MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED.…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT HEARD AN ABNORMAL NOISE AND OBSERVED THAT THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS DIAGNOSED BY THE CONTACT HIMSELF. THE CONTACT STATED THAT HE WOULD ATTEMPT TO WELD THE MANIFOLD. IF NOT, THE EXHAUST MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.
NHTSA ODI #10917437
92,000 miles · Oct 4, 2016
Service BrakesSuspension
REAR AXLE SEAL LEAKS IN THIS MODEL IT IS A KNOWN PROBLEM YET NISSAN STILL CHOOSES TO DO NOTHING ABOUT IT ,IT IS A HUGE SAFETY ISSUE IT LEAKS FLUID CONTINUOUSLY ON TO THE BACK BREAKING SYSTEM SO NOT ONLY COULD IT COMPRISE YOUR WHOLE BACK END BUT ALSO YOUR ABILITY TO STOP YOUR VEHICLE SAFELY,THIS HAS BEEN REPORTED THOUSANDS OF TIM…
Read full complaint
REAR AXLE SEAL LEAKS IN THIS MODEL IT IS A KNOWN PROBLEM YET NISSAN STILL CHOOSES TO DO NOTHING ABOUT IT ,IT IS A HUGE SAFETY ISSUE IT LEAKS FLUID CONTINUOUSLY ON TO THE BACK BREAKING SYSTEM SO NOT ONLY COULD IT COMPRISE YOUR WHOLE BACK END BUT ALSO YOUR ABILITY TO STOP YOUR VEHICLE SAFELY,THIS HAS BEEN REPORTED THOUSANDS OF TIMES TO YOUR AGENCY IN THE MEANTIME THE CONSUMERS CONTINUE TO REPLACE THESE EVERY 30-40,000 MILES JUST TO MAINTAIN THEIR SAFETY AND OTHERS ON THE ROAD WHEN I FEEL IT IS TIME NISSAN ADDRESS THIS AND TAKE THE NECESSARY STEPS TO ENSURE THE BRAKING SYSTEM IN THESE VEHICLES IS NOT CREATING A POTENTIAL HAZARD TOP THE DRIVER OR OTHERS ON THE ROAD . I TOOK MY VEHICLE IN FOR AN OIL CHANGE YESTERDAY ONLY TO FIND OUT MY SEAL IS LEAKING AGAIN AND NOW MY BACK BRAKES NEED TO BE REPLACED AGAIN BECAUSE THEY ARE NO LONGER SAFE DUE TO THE OIL LEAKING ON THEM AGAIN FROM THIS SEAL I DRIVE MY CHILDREN IN THIS VEHICLE DAILY TO SCHOOL TO GAMES AND IM THANKFUL THAT I HAPPENED TO NEED AN OIL CHANGE OR I WOULD HAVE HAD NO IDEA IT WAS LEAKING AGAIN OR JUST HOW UNSAFE MY DRIVING THIS VEHICLE COULD POTENTIALLY BE FOR MY CHILDREN AND MYSELF OR ANYBODY THAT IS DRIVING NEAR ME WHEN IT REQUIRES BRAKING TO STOP .
NHTSA ODI #10913738
80,000 miles · Sep 24, 2016
Service Brakes
THE BRAKES FAILED DUE TO A PIN HOLE IN THE LEFT FRONT BRAKE LINE. THERE ARE THREE FITTINGS THAT ARE IN THE SAME LOCATION ON THE TRUCK. ALL THREE SHOWED SIGNS OF CORROSION. THE ONE THAT FAILED LOOKS LIKE IT HAD BEEN DAMAGED ON INSTALLATION. THIS TRUCK IS OVER 11 YEARS OLD AND HAS SPENT MOST OF THE TIME OUTSIDE. IT HAS BEEN…
Read full complaint
THE BRAKES FAILED DUE TO A PIN HOLE IN THE LEFT FRONT BRAKE LINE. THERE ARE THREE FITTINGS THAT ARE IN THE SAME LOCATION ON THE TRUCK. ALL THREE SHOWED SIGNS OF CORROSION. THE ONE THAT FAILED LOOKS LIKE IT HAD BEEN DAMAGED ON INSTALLATION. THIS TRUCK IS OVER 11 YEARS OLD AND HAS SPENT MOST OF THE TIME OUTSIDE. IT HAS BEEN LOCATED IN SOUTH FLORIDA THE ENTIRE TIME SO HAS NOT SEEN ANY SALT. ALL THE OTHER FITTINGS AND LINES LOOK FINE. YOU CAN SEE FROM THE PICTURE THE FLAT SPOT ASSOCIATED WITH THE HOLE. THERE HAS BEEN NO WORK DONE ON THIS LINE SINCE THE TRUCK WAS NEW. (I AM THE ORIGINAL OWNER) I HAVE THE FAILED LINE. I REPAIRED IT MYSELF WITH PARTS FROM THE LOCAL NISSAN DEALER. THE FAILURE OCCURRED WITH THE TRUCK ON MY PROPERTY AND THERE WAS NO ACCIDENT INVOLVED. SEE ATTACHED PHOTO OF THE HOLE IN THE LINE. THIS LINE COMES FROM THE ABS UNIT TO A FITTING CLOSE TO THE FRONT WHEEL.
NHTSA ODI #10909456
130,000 miles · Sep 14, 2016
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE EXHAUST MANIFOLD WAS LEAKING FUMES IN THE ENGINE COMPARTMENT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE EXHAUST MANIFOLD WAS LEAKING FUMES IN THE ENGINE COMPARTMENT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10906430
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration