NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
65 reportsClear category filter90,000 miles · Jul 20, 2011
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THE REAR DRIVER'S SIDE LEAF SPRING BRACKET FRACTURED AND PUNCTURED A SMALL HOLE ON THE REAR OF THE VEHICLE NEAR THE WHEEL. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE PRO…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THE REAR DRIVER'S SIDE LEAF SPRING BRACKET FRACTURED AND PUNCTURED A SMALL HOLE ON THE REAR OF THE VEHICLE NEAR THE WHEEL. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10413772
85,000 miles · Jun 21, 2011
SuspensionTires
THIS IS A 2005 NISSAN TRUCK WITH 85,000 MILES USED VERY LIGHTLY THE TRUCK STARTED TO MAKE A NOISE, BROUGHT IT IN TO BE LOOKED AT 4000.00 REPAIR NEEDED FOR COMPLETE REAR END REPLACEMENT IF NOT FIXED IT COULD CAUSE REAR TIRES TO LOCK UP IS THERE ANY OTHER COMPLAINTS ABOUT THIS. *TR
NHTSA ODI #10407695
128,000 miles · Jun 7, 2011
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS DRIVING 20 MPH AS THE VEHICLE BEGAN TO ABNORMALLY PULL TO THE RIGHT. THE VEHICLE WAS TAKEN IN FOR NUMEROUS WHEEL ALIGNMENTS BUT THE REPAIR DID NOT CORRECT THE FAILURE. THE CONTACT STATED THAT A CAMBER KIT WAS MISSING. THE CAMBER KIT ALLOWED THE FRONT END TO ADJUST PROP…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS DRIVING 20 MPH AS THE VEHICLE BEGAN TO ABNORMALLY PULL TO THE RIGHT. THE VEHICLE WAS TAKEN IN FOR NUMEROUS WHEEL ALIGNMENTS BUT THE REPAIR DID NOT CORRECT THE FAILURE. THE CONTACT STATED THAT A CAMBER KIT WAS MISSING. THE CAMBER KIT ALLOWED THE FRONT END TO ADJUST PROPERLY DURING WHEEL ALIGNMENT. THE CONTACT STATED THAT THE VEHICLE WAS MANUFACTURED WITHOUT A CAMBER KIT AND HAS TO BE PURCHASED AS AN AFTERMARKET PART. THE CONTACT CALLED THE MANUFACTURER REGARDING THE CAMBER KIT AND THE MANUFACTURER STATED THAT THE CAMBER KIT WAS AN AFTERMARKET PART PURCHASED AT THE CONTACT'S EXPENSE. THE CONTACT STATED THAT THE CAMBER KIT SHOULD HAVE COME WITH THE VEHICLE SINCE IT WAS A SAFETY DEVICE. THE CONTACT BELIEVED THE VEHICLE TO BE UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10405388
106,000 miles · Jan 27, 2011
Suspension
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT STATED THAT HE HEARD A HOWLING NOISE FROM THE REAR OF THE VEHICLE. WHEN HE ATTEMPTED TO CHANGE LANES, THE REAR END LOCKED UP AND SKIDDED ABOUT ONE HUNDRED FEET BEFORE IT STOPPED, CAUSING THE REAR DRIVE AXLE TO POP OFF. THE VEHICLE WAS TOWED …
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT STATED THAT HE HEARD A HOWLING NOISE FROM THE REAR OF THE VEHICLE. WHEN HE ATTEMPTED TO CHANGE LANES, THE REAR END LOCKED UP AND SKIDDED ABOUT ONE HUNDRED FEET BEFORE IT STOPPED, CAUSING THE REAR DRIVE AXLE TO POP OFF. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE REAR END NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED WHO INFORMED THE CONTACT THAT HIS VEHICLE WAS NO LONGER UNDER WARRANTY AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS REPAIRED BY A PRIVATE MECHANIC. THE CURRENT AND FAILURE MILEAGES WERE 106,000. UPDATED 03/16/11 *BF UPDATED 12/20/11 *CN
NHTSA ODI #10379277
70,000 miles · Jan 10, 2011
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING SHACKLES THAT HELD THE BRACKETS WAS PUNCHING A HOLE THROUGH THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE SPRING WOULD NEED TO BE REPLACED AT THE CONTACTS EXPENSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANI…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING SHACKLES THAT HELD THE BRACKETS WAS PUNCHING A HOLE THROUGH THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE SPRING WOULD NEED TO BE REPLACED AT THE CONTACTS EXPENSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED WHO STATED THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10375467
42,186 miles · Jan 9, 2011
Power TrainService Brakes, HydraulicSuspension
MULTIPLE FAILURES OF RIGHT REAR AXLE SEAL. FAILURES AT MILEAGES OF 42186/86082/106492/131033. SAME PARTS REPLACED 43252-7S200 REAR AXLE SEAL, 43070-7S200 REAR SPACER, 40210-7S210 AXLE BEARING. AXLE FLUID DRAINS DIRECTLY ON TO BRAKE CAUSING LOSS OF FUNCTION ON RIGHT REAR WHEEL. ALSO HAS CAUSED POSSIBLE PREMATURE SHOCK ABSORBER WE…
Read full complaint
MULTIPLE FAILURES OF RIGHT REAR AXLE SEAL. FAILURES AT MILEAGES OF 42186/86082/106492/131033. SAME PARTS REPLACED 43252-7S200 REAR AXLE SEAL, 43070-7S200 REAR SPACER, 40210-7S210 AXLE BEARING. AXLE FLUID DRAINS DIRECTLY ON TO BRAKE CAUSING LOSS OF FUNCTION ON RIGHT REAR WHEEL. ALSO HAS CAUSED POSSIBLE PREMATURE SHOCK ABSORBER WEAR.
NHTSA ODI #10376113
69,000 miles · Dec 8, 2010
Suspension
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE BEFORE IT STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE REAR SUSPENSION BROKE IN HALF. HE WAS ALSO INFORMED THAT THIS WAS A KNOWN FAILURE. THE VEHICLE WAS BEING R…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE BEFORE IT STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THE REAR SUSPENSION BROKE IN HALF. HE WAS ALSO INFORMED THAT THIS WAS A KNOWN FAILURE. THE VEHICLE WAS BEING REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 69,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10369642
51,589 miles · Nov 30, 2010
Power TrainSteeringSuspension
2005 NISSAN TITAN CREW CAB 4X4 WITH OFF-ROAD PACKAGE, WITHIN 10,000 MILES THERE WERE LOOSE BOLTS ON THE TRANSFER CASE. AT 38,500 MILES THE LEFT FRONT DIFFERENTIAL SEAL FAILED AND LEAKED. AT 39,800 MILES THE POWER STEERING HOSE WENT BAD AND LEAKED. AT 51,000 MILES THE CIRCULAR CLIP ON THE AXLE AT FRONT LEFT DIFFERENTIAL DEFORMED …
Read full complaint
2005 NISSAN TITAN CREW CAB 4X4 WITH OFF-ROAD PACKAGE, WITHIN 10,000 MILES THERE WERE LOOSE BOLTS ON THE TRANSFER CASE. AT 38,500 MILES THE LEFT FRONT DIFFERENTIAL SEAL FAILED AND LEAKED. AT 39,800 MILES THE POWER STEERING HOSE WENT BAD AND LEAKED. AT 51,000 MILES THE CIRCULAR CLIP ON THE AXLE AT FRONT LEFT DIFFERENTIAL DEFORMED CAUSING AXLE TO BEGIN TO FALL OUT OF VEHICLE!!! THANKFULLY ALL HAS BEEN COVERED UNDER OUR EXTENDED WARRANTY, AND DEALERSHIPS HAVE REPLACED PARTS, BUT WHEN IT RUNS OUT THESE WILL COME FROM OUR POCKET, AND NO ONE CAN GUARANTEE THE NEW PARTS ARE NOT JUST REPLACEMENTS OR ANY BETTER. THIS COULD HAVE RESULTED IN DEATH OR INJURY TO US OR SOMEONE ELSE HAD THAT AXLE FELL FROM VEHICLE, AND COULD OCCUR AGAIN. *TR
NHTSA ODI #10368424
86,000 miles · Nov 2, 2010
Suspension
LEAF SPRING SHACKLE BROKE AT WELD, AND REAR PASSENGER LEAF SPRING PUSHED THROUGH THE BODY OF MY PICKUP BED . IT WASN'T THAT DISTINGUISHABLE, IT SOUNDED LIKE A CLUNK IN THE REAR AND THAT WAS IT. I WILL CONTACT NISSAN AND SEE WHAT THEY SAY. HOWEVER, I WILL BE PURCHASING AFTERMARKET SHACKLES TODAY FOR INSTALL. *TR
NHTSA ODI #10363650
64,130 miles · Oct 7, 2010
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHEN THE CONTACT PULLED TO A STOP SIGN, THE REAR DIFFERENTIAL LOCKED UP. THE VEICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS AWAITING INSPECTION BY THE DEALER TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE MILEAGE WAS 64,130 AND THE CURRENT MILEAGE WAS 65,130.
NHTSA ODI #10359517
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration