TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE LEAKED ONTO THE BRAKES AND THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY RE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE LEAKED ONTO THE BRAKES AND THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S RECALL FOR THE SUSPENSION. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 12,000.
NHTSA ODI #10535159
74,000 miles · Aug 9, 2013
Suspension
LEAF SPRING SQUEAKING NOISE AND ALSO JUST HAD THE REAR REPLACE ON THIS VEHICLE I JUST BOUGHT THIS VEHICLE A YEAR AGO I DON'T DO NO HAULING WAS SO EVER ON THIS TRUCK I DID SOME RESEARCH AND NISSAN KNOWS ABOUT THIS PROBLEM BUT THE DON'T WANT TO DO NOTHING REAR,SHACKLES,LEAF SPRING. *TR
NHTSA ODI #10534460
65,000 miles · Apr 6, 2013
Equipment Adaptive/mobilitySuspension
A-ARM BROKE TIRE RIPPED IN TO SIDE OF TRUCK
NHTSA ODI #10507356
128,000 miles · Jan 16, 2013
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WHILE DRIVING 40 MPH, THE REAR OF THE VEHICLE STARTED EXHIBITING A CLICKING SOUND AND FELT AS IT WERE ATTEMPTING TO SEIZE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE DRIVE KNUCKLE THAT WAS WITHIN THE DIFFERENTIAL HAD FAILED. THE DEALER AL…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WHILE DRIVING 40 MPH, THE REAR OF THE VEHICLE STARTED EXHIBITING A CLICKING SOUND AND FELT AS IT WERE ATTEMPTING TO SEIZE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE DRIVE KNUCKLE THAT WAS WITHIN THE DIFFERENTIAL HAD FAILED. THE DEALER ALSO STATED THAT THE MANUFACTURER WOULD NOT REPLACE PARTS ON THE DIFFERENTIAL AND THE CONTACT WOULD HAVE TO PURCHASE AN ENTIRE REAR END FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 128,000.
NHTSA ODI #10493186
90,284 miles · Jul 14, 2012
Power TrainSuspension
WAS LEAVING A PARKING LOT AND WHEN TURNING TO THE LEFT FELT A BUMP LIKE SOMETHING HAD BEEN RUN OVER.DROVE HOME AND FELT BUMP SEVERAL MORE TIMES WHEN TURNING LEFT ONLY. REMOVED FILL PLUG AND SAW PIECES ON METAL ON DRAIN PLUG MAGNET. HAD VEHICLE TOWED TO DEALER AND WAS TOLD AXLE HAD FAILED AND NEEDED TO BE REPLACED.VEHICLE GAVE NO…
Read full complaint
WAS LEAVING A PARKING LOT AND WHEN TURNING TO THE LEFT FELT A BUMP LIKE SOMETHING HAD BEEN RUN OVER.DROVE HOME AND FELT BUMP SEVERAL MORE TIMES WHEN TURNING LEFT ONLY. REMOVED FILL PLUG AND SAW PIECES ON METAL ON DRAIN PLUG MAGNET. HAD VEHICLE TOWED TO DEALER AND WAS TOLD AXLE HAD FAILED AND NEEDED TO BE REPLACED.VEHICLE GAVE NO WARNING SIGNS AND HAD ALL SCHEDULED SERVICE DONE. *TR
NHTSA ODI #10465626
50,000 miles · May 25, 2012
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE DRIVER OF THE VEHICLE HEARD A CLICKING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT WAS UNAWARE OF THE REPAIRS NEEDED BUT STATED THAT THE NOISE WAS RELATED TO THE SUSPENSION. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE DRIVER OF THE VEHICLE HEARD A CLICKING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT WAS UNAWARE OF THE REPAIRS NEEDED BUT STATED THAT THE NOISE WAS RELATED TO THE SUSPENSION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
NHTSA ODI #10459615
40,000 miles · May 21, 2012
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE WAS LEAKING AND BOTH SEALS WERE BROKEN. THE CONTACT STATED THAT THE FAILURE HAD BEEN REPAIRED BEFORE UNDER A MANUFACTURER'S VOLUNTARY RECALL. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE REAR AXLE NEEDED TO BE REPLACED. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE WAS LEAKING AND BOTH SEALS WERE BROKEN. THE CONTACT STATED THAT THE FAILURE HAD BEEN REPAIRED BEFORE UNDER A MANUFACTURER'S VOLUNTARY RECALL. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE REAR AXLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 69,000.
NHTSA ODI #10459128
73,000 miles · Apr 28, 2012
Suspension
MY REAR LEAF SPRING SHACKLE SNAPPED PUNCHING A HOLE THOUGH THE TRUCK BED OPENING IT UP LIKE A TUNA CAN WHILE I WAS ON THE HIGHWAY AND NEARLY LOST CONTROL IN A CONSTRUCTION ZONE WHERE THERE WERE QUITE A FEW PEOPLE WORKING ON THE SIDE OF THE ROAD. DID SOME INVESTIGATING AND IT SEEMS LIKE A PRETTY COMMON PROBLEM FOR THE 04-07 TITA…
Read full complaint
MY REAR LEAF SPRING SHACKLE SNAPPED PUNCHING A HOLE THOUGH THE TRUCK BED OPENING IT UP LIKE A TUNA CAN WHILE I WAS ON THE HIGHWAY AND NEARLY LOST CONTROL IN A CONSTRUCTION ZONE WHERE THERE WERE QUITE A FEW PEOPLE WORKING ON THE SIDE OF THE ROAD. DID SOME INVESTIGATING AND IT SEEMS LIKE A PRETTY COMMON PROBLEM FOR THE 04-07 TITANS AND AM WONDERING WHY I (OR THE THOUSANDS OF OTHERS WHO'VE HAD THE SAME PROBLEM) WERE NOT INFORMED ABOUT THIS FROM THE FINE FOLKS AT NISSAN BEFORE PEOPLE GET KILLED. I WOULD HAVE PAID TO REPLACE THEM MYSELF HAD I JUST BEEN TOLD.....ITS NOT ABOUT THE MONEY...SAFETY IS NUMBER ONE IN MY BOOK ESPECIALLY WHEN I'M HAULING AROUND MY 18 MONTH OLD IN SOMETHING THAT THE FACTORY KNOWS HAS A LIFE THREATENING DEFECT AND DOESN'T TELL ANYONE!!!!!!!! SINCERELY PISSED!! *TR
NHTSA ODI #10456784
107,455 miles · Apr 25, 2012
Electrical SystemFuel System, GasolineSuspension
THIS VEHICLE HAS MORE COMMON FAILURES THAN ANY I HAVE SEEN. BOTH OF THE REAR LEAF SPRING SHACKLES ROTTED OUT. THE REAR AXLE SEALS ARE NOW LEAKING. IN 6 MONTHS I HAVE REPLACED 2 OXYGEN SENSORS AND NOW FOR THE 2ND TIME I AM REPLACING THE EVAP CANISTER CONTROL VALVE. NISSAN SEEMS TO IGNORE ALL OF THESE ISSUES AND HAS REDESIGNED MAN…
Read full complaint
THIS VEHICLE HAS MORE COMMON FAILURES THAN ANY I HAVE SEEN. BOTH OF THE REAR LEAF SPRING SHACKLES ROTTED OUT. THE REAR AXLE SEALS ARE NOW LEAKING. IN 6 MONTHS I HAVE REPLACED 2 OXYGEN SENSORS AND NOW FOR THE 2ND TIME I AM REPLACING THE EVAP CANISTER CONTROL VALVE. NISSAN SEEMS TO IGNORE ALL OF THESE ISSUES AND HAS REDESIGNED MANY OF THESE PROBLEM AREAS IN NEWER MODELS HOWEVER DOES NOT OWN UP TO FIXING THE ISSUES ON VEHICLES THAT ARE ON THE ROAD. *TR
NHTSA ODI #10456492
3,400 miles · Feb 7, 2012
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A LOUD CLUNKING NOISE EMITTED FROM THE REAR OF THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD AND THEN THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE REAR ASSEMBLY. TWO YEARS AFTE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A LOUD CLUNKING NOISE EMITTED FROM THE REAR OF THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD AND THEN THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE REAR ASSEMBLY. TWO YEARS AFTER THE REPAIR WAS PERFORMED, THE IDENTICAL FAILURE RECURRED. THE VEHICLE WAS AGAIN TOWED TO AN INDEPENDENT MECHANIC AND THE REAR DIFFERENTIAL WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,400.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration