NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
62 reportsClear category filter100,000 miles · Aug 8, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WAS A CRACK IN THE EXHAUST MANIFOLD AND THE VEHICLE WOULD MAKE A POPPING SOUND WHEN THE ENGINE WAS ON. THE EXHAUST WAS ALSO LEAKING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE MANIFOLD WAS REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT DID NOT ASSIS…
Read full complaint
TL* THE CONTACT OWNS 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WAS A CRACK IN THE EXHAUST MANIFOLD AND THE VEHICLE WOULD MAKE A POPPING SOUND WHEN THE ENGINE WAS ON. THE EXHAUST WAS ALSO LEAKING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE MANIFOLD WAS REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT DID NOT ASSIST WITH THE REPAIRS. THE FAILURE MILEAGE WAS 100,000 AND 200,000.
NHTSA ODI #10417982
85,000 miles · Jun 24, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT SHE COULD HEAR A LOUD NOISE COMING FROM THE ENGINE WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THERE WAS A LEAK IN THE EXHAUST SYSTEM. AS A RESULT, THE EXHAUST SYSTEM NEEDED TO BE REPLACE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT SHE COULD HEAR A LOUD NOISE COMING FROM THE ENGINE WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THERE WAS A LEAK IN THE EXHAUST SYSTEM. AS A RESULT, THE EXHAUST SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10408822
50,000 miles · Mar 24, 2011
Engine And Engine Cooling
ABOUT TWO YEARS AGO I STARTED HEARING A TICKING NOISE ON MY 2005 NISSAN TITAN PU AT START UP. COULDN'T FOR THE LIFE OF ME FIGURE OUT WHAT IT WAS UNTIL NISSAN SENT ME AN OWNER NOTIFICATION CARD ABOUT CRACKS IN THE EXHAUST MANIFOLDS. THEN IT DAWNED ON ME WHAT THAT TICKING NOISE WAS WHEN COLD START UP TOOK PLACE. I HAD THE VEHICLE …
Read full complaint
ABOUT TWO YEARS AGO I STARTED HEARING A TICKING NOISE ON MY 2005 NISSAN TITAN PU AT START UP. COULDN'T FOR THE LIFE OF ME FIGURE OUT WHAT IT WAS UNTIL NISSAN SENT ME AN OWNER NOTIFICATION CARD ABOUT CRACKS IN THE EXHAUST MANIFOLDS. THEN IT DAWNED ON ME WHAT THAT TICKING NOISE WAS WHEN COLD START UP TOOK PLACE. I HAD THE VEHICLE RECENTLY IN THE SHOP FOR 2 OTHER RECALLS AND MENTIONED THIS ALONG WITH THE NOTICE I RECEIVED ABOUT THIS PROBLEM FROM NISSAN. THE SERVICE MANAGER SAID THEY WOULD LOOK INTO IT BUT WAS CONCERNED BECAUSE I HAD 83,400 MILES ON THE TRUCK AND WARRANTY ISSUES ONLY WOULD FIX THIS UP TO 80,000 MILES. I HAVEN'T EVER HAD A EXHAUST CRACK ON ANY VEHICLE THAT I HAVE OWNED SINCE 1972 AND HAD SOME OF THESE VEHICLE TO UPWARD OF 250,000 MILES. WHY WON'T NISSAN DO SOMETHING ABOUT THIS TO FIX THIS ISSUE BECAUSE IT LOOKS LIKE IT IS ALL OF THEM THAT CRACK. SEEMS TO ME FOR SAFETY ISSUES AND EXHAUST FUMES THAT SHOULD BE ROUTED TO THE REAR OF THE VEHICLE ARE NOW BEING PUSHED INTO THE ENGINE COMPARTMENT AND NOT EVEN GETTING TO THE CATALYTIC CONVERTER. I'M VERY DISAPPOINTED IN NISSAN FOR THE ABSENCE OF HELP IN THIS ISSUE AND A SERIOUS ONE AT THAT. THIS SHOULD BE A RECALL AND OF ALL THE WATCHDOG AREAS OF OUR LIFE WHERE IS THE EPA ON THIS ONE. *TR
NHTSA ODI #10392786
74,000 miles · Mar 10, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT BOTH EXHAUST MANIFOLDS CRACKED AND THE CONTACT NOTICED THAT THE VEHICLE HAD BECOME VERY LOUD. THERE WAS ALSO A FUEL ODOR INSIDE WHICH ALERTED HER TO A POTENTIAL FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE MANIFOLDS WERE CRACKED AND WOULD…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT BOTH EXHAUST MANIFOLDS CRACKED AND THE CONTACT NOTICED THAT THE VEHICLE HAD BECOME VERY LOUD. THERE WAS ALSO A FUEL ODOR INSIDE WHICH ALERTED HER TO A POTENTIAL FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE MANIFOLDS WERE CRACKED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT A LATER DATE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 100,000. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000.
NHTSA ODI #10389726
Mileage unknown · Mar 7, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 20O5 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 25 MPH AND ACCELERATING FROM A COMPLETE STOP, THE ENGINE STALLED WITHOUT WARNING. AFTER WAITING A FEW MOMENTS THE ENGINE WAS RESTARTED. THE FAILURE RECURRED ON A DIFFERENT OCCASION AND THE ENGINE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER…
Read full complaint
TL* THE CONTACT OWNS A 20O5 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 25 MPH AND ACCELERATING FROM A COMPLETE STOP, THE ENGINE STALLED WITHOUT WARNING. AFTER WAITING A FEW MOMENTS THE ENGINE WAS RESTARTED. THE FAILURE RECURRED ON A DIFFERENT OCCASION AND THE ENGINE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY REPLACED THE RELAY SWITCH AT THE OWNER'S EXPENSE. A RECALL NOTIFICATION WAS RECEIVED TWO YEARS LATER AFTER THE REPAIR. THE RECALL WAS ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER TO VERIFY WHETHER THE VEHICLE WAS INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10386683
76,000 miles · Dec 30, 2010
Electrical SystemEngine And Engine Cooling
2/3/10: 2005 NISSAN TITAN BREAKS DOWN ON HWY 71 AT THE LIGHT RIGHT BEFORE THE ENTRANCE TO THE AIRPORT. MY 120 LBS FIANC HAS TO WORK TO PUSH THE TRUCK OUT OF THE LANE WITH CARS RACING BY AT 60 MPH WITH OUR 8 MONTH OLD DAUGHTER. 2/4/10: ENGAGED TERRY WISDOM WITH MAXWELL NISSAN IN ROUND ROCK AND HE WORKED TO HAVE MY ECM RELAY SWI…
Read full complaint
2/3/10: 2005 NISSAN TITAN BREAKS DOWN ON HWY 71 AT THE LIGHT RIGHT BEFORE THE ENTRANCE TO THE AIRPORT. MY 120 LBS FIANC HAS TO WORK TO PUSH THE TRUCK OUT OF THE LANE WITH CARS RACING BY AT 60 MPH WITH OUR 8 MONTH OLD DAUGHTER. 2/4/10: ENGAGED TERRY WISDOM WITH MAXWELL NISSAN IN ROUND ROCK AND HE WORKED TO HAVE MY ECM RELAY SWITCHED OUT AND CHARGES $340.06 FOR THE REPAIR.12/29/10: RECEIVED RECALL NOTICE ADVISES TO CONTACT NISSAN DEALER. 12/30/10: - ENGAGED SERVICE ADVISOR AT MAXWELL NISSAN IN RR ABOUT THE RECALL AND THEIR RECENT WORK IN FEBRUARY. SHE ADVISED I HAVE TO CALL INTO NISSANS 800 NUMBERS IN ORDER TO MOVE FORWARD WITH THE RECALL. SHE OFFERS MINIMAL ASSISTANCE WITH BRIDGING THAT GAP. I ASKED HER TO HAVE HER SUPERVISOR ENGAGE. SUPERVISORS CALLS BACK AND ADVISES THAT I HAVE CALL INTO NISSANS 800. PROVIDES DOCUMENTS, I ASK FOR ASSISTANCE? AND STATES HIS DEALERSHIPS CAN NOT GET INVOLVED. I SHOULD HAVE "CONSIDER TOYOTA OR FORD WITH MY PURCHASE" BUT MY ISSUES ARE WITH A NISSAN. CONTACT NISSAN NORTH AMERICA KALA ADVISES TO GO BACK TO THE DEALERSHIP TO HAVE THE PART RE-REPLACED DUE TO THE SERVICE TOOK PLACE IN FEB AND THIS RECALL STATES ANYTHING BEFORE NOVEMBER HAS TO ALSO BE REPLACED. FILE # 7042010 ENGAGE GM FOR MAXWELL NISSAN AND I INFORM HIM OF THE HISTORY WITH THIS ISSUE AND CUSTOMER SERVICE EXPERIENCE IVE RECEIVED WITH HIS SERVICE DEPARTMENT. HAVE I CONSIDERED GOING TO BACK TO THE DEALERSHIP WHERE I PURCHASED THE TRUCK FROM COMPARES MY EXPERIENCE TO HIS DELL HARD DRIVE CRASHING. I ADVISED THAT MY CHECK FOR SERVICE IF FEBRUARY WAS CUT TO HIS DEALERSHIP AND FOR ASSISTANCE WITH THE ENGAGEMENT, HE WOULD NOT. I ADVISED THAT I WAS GOING TO POST MY EXPERIENCE ON YOUTUBE OR FACEBOOK, IF YOU DO, DO NOT COME BACK TO THIS DEALERSHIP! SERVICE ADVISOR MANAGER IT IS SAD TO SEE OUR SOCIETY COME TO THE POINT OF HAVING TO USE SOCIAL MEDIA
NHTSA ODI #10374212
95,540 miles · Dec 21, 2010
Engine And Engine Cooling
MY EXHAUST MANIFOLD/ CAT HAS FAILED. THERE IS A CRACK IN MY EXHAUST MANIFOLD AND OVER WARRANTY 15K. I HAVE NOTICE MPG LOSS AND GASES ENTERING MY CABIN WHEN I'M AT A STOP LIGHT AND MY WINDOW IS DOWN. I'M A FATHER OF 3 AND WORRIED FOR MY CHILDREN SAFETY. PASSENGER IS CRACKED AND WORRIED THAT THE DRIVERS IS GOING TO GO SOON. THE DE…
Read full complaint
MY EXHAUST MANIFOLD/ CAT HAS FAILED. THERE IS A CRACK IN MY EXHAUST MANIFOLD AND OVER WARRANTY 15K. I HAVE NOTICE MPG LOSS AND GASES ENTERING MY CABIN WHEN I'M AT A STOP LIGHT AND MY WINDOW IS DOWN. I'M A FATHER OF 3 AND WORRIED FOR MY CHILDREN SAFETY. PASSENGER IS CRACKED AND WORRIED THAT THE DRIVERS IS GOING TO GO SOON. THE DEALERSHIP WILL NOT COVER UNDER WARRANTY. THIS WILL COST ME 600 PER SIDE + 600 FOR LABOR WHICH BRINGS THE TOTAL TO 1800+TAX. I'M APART OF A NISSAN CLUB/FORUM AND THIS IS A PROBLEM NUMEROUS PEOPLE ARE HAVING, 50+ IN CALIFORNIA. SOME PEOPLE HAVE TO GO AFTERMARKET OR EVEN PASS IT ILLEGALLY THROUGH BLACK MARKET CHANNELS. NISSAN IS WELL AWARE OF THIS PROBLEM AND RELEASED A REVISED VERSION WHICH STILL HAVE THE SAME PROBLEM. NISSAN IS ROBBING THEIR CUSTOMERS AND NEED TO BE BROUGHT TO JUSTICE. THEY SHOULD BE RESPONSIBLE UNDER THE EMISSIONS LAW AND FOR PUTTING OUT A KNOWN FAULTY PART. I DON'T KNOW WHAT TO DO I HAVE MANY FRIENDS IN OTHER STATES THAT ARE ON THEIR 2ND SET OR GOING ON THEIR 3RD SET. THIS SHOULD BE ADDRESSED FOR THE SAFETY OF PEOPLE AND THE EARTH [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10371882
100,000 miles · Dec 2, 2010
Engine And Engine CoolingEquipment
EXHAUST MANIFOLD LEAKING FOR THE SECOND TIME. BANK 1 SIDE WAS BAD BEFORE THE 80 EMISSIONS WARRANTY WAS UP, HOWEVER DEALERSHIP WOULDN'T DO IT, SO WE PURCHASED ANOTHER OEM MANIFOLD/CAT AND HAD ANOTHER SHOP REPLACE IT. NOW 2 YEARS LATER THAT SIDE HAS FAILED AND IS LEAKING AGAIN. THE CATALYTIC CONVERTER HAS FAILED ON THAT SIDE ALSO…
Read full complaint
EXHAUST MANIFOLD LEAKING FOR THE SECOND TIME. BANK 1 SIDE WAS BAD BEFORE THE 80 EMISSIONS WARRANTY WAS UP, HOWEVER DEALERSHIP WOULDN'T DO IT, SO WE PURCHASED ANOTHER OEM MANIFOLD/CAT AND HAD ANOTHER SHOP REPLACE IT. NOW 2 YEARS LATER THAT SIDE HAS FAILED AND IS LEAKING AGAIN. THE CATALYTIC CONVERTER HAS FAILED ON THAT SIDE ALSO. NISSAN HAS NOT OFFERED A RECALL. EXHAUST MANIFOLD LEAKING ALLOWS EXHAUST FUMES TO NOT BE VENTED CORRECTLY AND THE FUMES CAN COME INTO THE CABIN OF THE VEHICLE. I HAVE SPOKEN WITH THE DEALERSHIP AND IT SHOULD BE NOTED I'M OUT OF THE 80 K EMISSIONS WARRANTY. THE OEM EQUIPMENT IS NOT UP TO PAR. *TR
NHTSA ODI #10369015
57,215 miles · Dec 1, 2010
Engine And Engine Cooling
EMISSIONS PROBLEM LEADING TO CATALYTIC CONVERTER FAILURE DUE TO CRACKING EXHAUST MANIFOLD OF MY 2005 NISSAN TITAN. *TR
NHTSA ODI #10368478
114,800 miles · Nov 30, 2010
Engine And Engine Cooling
CRACK EXHAUST MANIFOLD/CATALYTIC CONVERTER IS ONE PIECE. *TR
NHTSA ODI #10368448
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration