I RECEIVED A RECALL NOTICE (RECALL 06V-459) FROM NISSAN APPROXIMATELY 4 YEARS AGO REGARDING THE WIRING HARNESS BEING DEFECTIVE. THE ORIGINAL NOTICE DID NOT MENTION THAT IT WOULD REQUIRE SERVICE ONLY IF THE AIRBAG LIGHT WAS ON OR FLASHING (WHICH IT WAS NOT). I BROUGHT MY VEHICLE IN FOR THE RECALL (AT KELLY NISSAN OF LYNNFIELD M…
Read full complaint
I RECEIVED A RECALL NOTICE (RECALL 06V-459) FROM NISSAN APPROXIMATELY 4 YEARS AGO REGARDING THE WIRING HARNESS BEING DEFECTIVE. THE ORIGINAL NOTICE DID NOT MENTION THAT IT WOULD REQUIRE SERVICE ONLY IF THE AIRBAG LIGHT WAS ON OR FLASHING (WHICH IT WAS NOT). I BROUGHT MY VEHICLE IN FOR THE RECALL (AT KELLY NISSAN OF LYNNFIELD MA), NOT KNOWING THIS AND THEY SIMPLY TAPED THE WIRING HARNESSES AFTER INSPECTION AND RECORDED THE RECALL SERVICED ON THE NISSAN TITAN AND MOST LIKELY CHARGED NISSAN OF NORTH AMERICA FOR PARTS AND LABOR FOR A HARNESS REPLACEMENT. AT 65,000 MILES I STARTED TO GET THE AIRBAG SENSOR LIGHT ON MY DASHBOARD FLASHING CONSTANTLY. I RESEARCHED THE FLASHING CODE FROM THE SENSOR AND IT TURNS OUT TO BE RELATED TO THE PASSENGER SIDE WIRING HARNESS. AS RECENTLY AS 2 WEEKS AGO I RECEIVED WHAT I THOUGHT WAS ANOTHER RECALL NOTICE FROM NISSAN OF NORTH AMERICA WHICH CLEARLY STATED THIS TIME " IF THE RED AIRBAG WARNING LAMP IS ILLUMINATED - PLEASE CONTACT YOUR DEALERSHIP IMMEDIATELY FOR REPAIRS" , AFTER SCHEDULING ANOTHER APPOINTMENT WITH THE SAME DEALERSHIP THAT DID THE ORIGINAL RECALL AND BRINGING THE VEHICLE IN THEY TOLD ME THAT THE RECALL HAD ALREADY BEEN DONE AND THE WAS NO OTHER ACTION THAT COULD BE PERFORMED WITHOUT A CHARGE TO ME. THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT AS I AM THE ORIGINAL OWNER. I FIND IT DIFFICULT TO BELIEVE THAT IF A VEHICLE HAS A RECALL AND PARTS ARE REPLACED THAT THE SAME FAILURE WILL OCCUR WITH THE REPLACED PARTS, HENCE MY CONCLUSION THAT THE ACTUAL WORK WAS NEVER PERFORMED ONLY RECORDED AS SUCH AGAINST THE VEHICLES (VIN). ANY HELP YOU COULD PROVIDE WOULD BE APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10509847
120,000 miles · Feb 22, 2012
Air BagsElectrical System
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE IN PARK, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC CONFIRMED THAT THE AIR BAG WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT, HIS VIN DID NOT QUA…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE IN PARK, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC CONFIRMED THAT THE AIR BAG WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT, HIS VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 06V459000 (ELECTRICAL SYSTEM).THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 120,300. STATUS UPDATE 04/25/12
NHTSA ODI #10448902
97,800 miles · Feb 18, 2012
Air BagsElectrical System
ABS COMPUTER MALFUNCTIONED CAUSING THE 4 WHEEL DRIVE HARNESS TO OVER HEAT, 4 WHEEL DRIVE HARNESS HAS MELTED AND WON`T ENGAGE 4 WHEEL DRIVE, IT ALSO EFFECTED THE AIR BAGS LIGHT ON DASH TO FLASH AND PASSENGER AIR BAGS TO SHUT OFF. *TR
NHTSA ODI #10448410
1,200 miles · Sep 20, 2009
Air BagsElectrical SystemEngine And Engine Cooling
I OWN A 2005 NISSAN TITAN KING CAB, WHICH I PURCHASED IT IN NOVEMBER OF 2005. AFTER, APPROXIMATELY 30DAYS OF OWNERSHIP AND 500 MILES OF TRAVEL; THE FRONT BRAKES BEGAN TO EXPERIENCE COMPLICATIONS (THEY WOULD SHUDDER WHILE BRAKING AND CREATE AN UNREASONABLE AMOUNT OF BRAKE DUST.) I QUICKLY RETURN TO MY LOCAL DEALERSHIP WHERE I P…
Read full complaint
I OWN A 2005 NISSAN TITAN KING CAB, WHICH I PURCHASED IT IN NOVEMBER OF 2005. AFTER, APPROXIMATELY 30DAYS OF OWNERSHIP AND 500 MILES OF TRAVEL; THE FRONT BRAKES BEGAN TO EXPERIENCE COMPLICATIONS (THEY WOULD SHUDDER WHILE BRAKING AND CREATE AN UNREASONABLE AMOUNT OF BRAKE DUST.) I QUICKLY RETURN TO MY LOCAL DEALERSHIP WHERE I PURCHASED IT, FOR SERVICING. THE NISSAN DEALERSHIP REPAIRED THE ROTORS. DURING THE SUMMER OF 2006, I BEGAN TO NOTICE A MUSTY ODOR EMITTING FROM THE FLOOR AND CARPETING OF THE PASSENGER SIDE. DURING A ROUTINE OIL CHANGE AND REQUESTED THE MECHANIC TO INSPECT THE TRUCK FOR THE CAUSE OF THE ODOR. THEY COULDN'T LOCATE THE SOURCE OF THE ODOR. I RETURNED THE TRUCK TO THE DEALERSHIP FOR THE SAME PROBLEM ON SEVERAL OTHER OCCASIONS, DURING THE SUMMER OF 2007 ODOR REAPPEARED; THEY REPLACED THE RUBBER GASKET AROUND DOOR WINDOWS IN HOPES OF RESOLVING THE ISSUE. MEANWHILE THE FRONT BRAKES ROTORS WERE REPLACED AGAIN AND THE GAUGES (FUEL, OIL, TACH ,VOLTMETER) ACTING ERRATICALLY. THE DEALERSHIP REPAIRED THE BRAKES UNDER MY EXTENDED WARRANTY & PRORATED MY PURCHASE OF A NEW NISSAN AUTO BATTERY; ACCORDING TO SERVICE DEPT. THIS WAS THE CAUSE OF THE GAUGES MALFUNCTION. THEN AGAIN IN2008, I WAS TOLD THE BRAKES WERE NO LONGER UNDER WARRANTY AND THAT THE MUSTY ODOR WAS CAUSED BY WATER COMING INTO THE CABIN VIA A SMALL VOID IN THE WINDOW SEALANT AROUND THE "FACTORY INSTALLED WINDSHIELD' UPON HEARING THIS, I CHOSE TO TAKE MY TRUCK TO ANOTHER MECHANIC DUE TO NISSAN MECHANIC INABILITY TO RESOLVE THE BRAKE ISSUE & LOCATE THE SOURCE OF THE WATER. THIS YEAR 2009, THE REAR END WAS REPAIRED DUE THE SEALS LEAKING ON THE DRIVER'S SIDE AND PREVENTIVE REPLACEMENT ON THE PASSENGER SEALS. HOWEVER, A FEW OLD ISSUES ALONG WITH NEW ONES THAT STILL EXIST. MY NEW MECHANIC TOLD ME THE SOURCE OF THE WATER & ODOR ISSUE IS THE A/C CONDENSER LEAKING INTO THE CABIN, THE BLINKING AIR BAG INDICATOR LIGHT WAS DUE TO A HARNESS NEEDING REPLACING IN THE REAR DOORS. *TR
NHTSA ODI #10284683
60,000 miles · Aug 26, 2009
Air BagsCrashInjury
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT SPEEDS RANGING 50 TO 55 MPH, A CRASH OCCURRED WITH A VEHICLE THAT PROCEEDED THROUGH A RED TRAFFIC LIGHT. THE AIRBAGS DID NOT DEPLOY. THE DRIVER SUFFERED MINOR INJURIES AS A RESULT OF THE CRASH. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 60,000. THE VIN WAS NOT RE…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT SPEEDS RANGING 50 TO 55 MPH, A CRASH OCCURRED WITH A VEHICLE THAT PROCEEDED THROUGH A RED TRAFFIC LIGHT. THE AIRBAGS DID NOT DEPLOY. THE DRIVER SUFFERED MINOR INJURIES AS A RESULT OF THE CRASH. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 60,000. THE VIN WAS NOT RECOGNIZED BY THE SYSTEM.
NHTSA ODI #10281857
74,000 miles · Feb 2, 2009
Air BagsCrashInjury
MY HUSBAND WAS IN AN ACCIDENT AND THE AIRBAGS ON OUR 2005 NISSAN TITAN () DID NOT DEPLOY IN SPITE ON THE WHOLE FRONT OF THE TRUCK BEING SMASHED IN. I HAVE CONTACTED NISSAN SEVERAL TIMES AND THEY WILL NOT CALL ME BACK. *TR
NHTSA ODI #10257243
Mileage unknown · Apr 10, 2007
Air Bags
MY WIFE WEIGHED 115 AND THE AIR BAG LIGHT SHOWED THE AIR BAG SYSTEM WAS OFF. DEALERSHIP SAYS THAT THERE WAS NOTHING THEY COULD DO, IT WAS THE SENSOR, AND IT WAS WORKING CORRECTLY. THIS NEEDED TO BE ADDRESSED, SHE WAS NOT SAFE WHILE DRIVING IN THE TRUCK. *AK
NHTSA ODI #10187415
8,000 miles · Oct 20, 2005
Air Bags
MY 125 LB WIFE DOES NOT ACTIVATE THE SEAT SENSOR FOR THE AIRBAG IN MY 05 NISSAN TITAN. WHILE IT DOESN'T HAPPEN 100% OF THE TIME, IT HAS OCCURRED REPEATEDLY. THE DEALER CHECKED & CONFIRMED THAT THE SYSTEM IS OPERATING NORMALLY AND STATED THAT THEY COULD DO NOTHING MORE. AT THIS POINT MY WIFE IS RIDING IN OUR TRUCK WITHOUT AN AIRB…
Read full complaint
MY 125 LB WIFE DOES NOT ACTIVATE THE SEAT SENSOR FOR THE AIRBAG IN MY 05 NISSAN TITAN. WHILE IT DOESN'T HAPPEN 100% OF THE TIME, IT HAS OCCURRED REPEATEDLY. THE DEALER CHECKED & CONFIRMED THAT THE SYSTEM IS OPERATING NORMALLY AND STATED THAT THEY COULD DO NOTHING MORE. AT THIS POINT MY WIFE IS RIDING IN OUR TRUCK WITHOUT AN AIRBAG. WHILE SHE DOES WEAR A SEAT BELT, I WOULD LIKE TO HAVE THE COMFORT OF KNOWING THE FULL SAFETY SYSTEM IS OPERATIONAL IN THE EVENT OF AN ACCIDENT. RESEARCH AND OTHER COMPLAINTS POSTED HERE SHOW THAT THIS IS NOT AN ISOLATED PROBLEM. *NM
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration