NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
304 reports183,400 miles · Oct 2, 2016
Air BagsElectronic Stability Control (esc)Vehicle Speed Control
TAKATA RECALL; AFTER PURCHASING VEHICLE AND DRIVING FOR ABOUT 10 MINUTES; CHECK ENGINE LIGHT SUDDENLY COMES ON PRIOR TO PICKING UP SPEED TO ENTER HIGHWAY; VEHICLE ABRUPTLY LOSES POWER AT A SPEED OF 65 MILES PER HOUR AND STALLS IN TRAFFIC CAUSING A NEAR FATAL TRAFFIC ACCIDENT; AFTER RUNNING THE VIN NUMBER IN NHTSA DATABASE VEHICL…
Read full complaint
TAKATA RECALL; AFTER PURCHASING VEHICLE AND DRIVING FOR ABOUT 10 MINUTES; CHECK ENGINE LIGHT SUDDENLY COMES ON PRIOR TO PICKING UP SPEED TO ENTER HIGHWAY; VEHICLE ABRUPTLY LOSES POWER AT A SPEED OF 65 MILES PER HOUR AND STALLS IN TRAFFIC CAUSING A NEAR FATAL TRAFFIC ACCIDENT; AFTER RUNNING THE VIN NUMBER IN NHTSA DATABASE VEHICLE WAS NEVER RECALLED FOR GROSSLY NEGLIGENT ISSUE WITH CRANKSHAFT AND CAMSHAFT POSITION SENSORS. THIS LEADS ME TO THE FACT THAT VEHICLE MANUFACTURER NEVER CONTACTED ORIGINAL OWNER CONCERNING THIS TERRIBLE SAFETY ISSUE. AFTER FINDING OUT ABOUT TWO OUTSTANDING RECALLS THAT WERE NEVER ADDRESSED IN WHICH THE VEHICLE HAS EXHIBITED POTENTIAL CATASTROPHIC CONSEQUENCES BASED UPON THE MANUFACTURERS PRODUCT DEFECT IT WAS UNCOVERED THAT THE VEHICLE HAS A POTENTIAL FATAL ISSUE WITH THE PASSENGER SIDE AIRBAG. I AM EXTREMELY TERRIFIED TO OPERATE THIS VEHICLE AND MY EXPERIENCE ON OCTOBER 1, 2016 OF OPERATING THIS VEHICLE AND IT LOSING POWER ABRUPTLY RISKING MY LIFE AND LIMB HAS CAUSED ME EXTREME DEPRESSION, STRESS, AND MENTAL ANGUISH. IF THESE ISSUES ARE NOT CORRECTED IMMEDIATELY AS A REMEDY AT LAW WITH THE NEAREST NISSAN DEALER INCLUDING TOWING AT MANUFACTURER'S EXPENSE, I AND THE TEXAS OFFICE OF THE ATTORNEY GENERAL WILL PURSUE A GROSS PRODUCT LIABILITY NEGLIGENCE LEGAL ACTION AGAINST NISSAN BASED UPON MY LEGAL ADVICE AND TEXAS LAW; WHICH CLEARLY STATES THAT IN A PRODUCT LIABILITY DISPUTE THE STATUTE OF LIMITATIONS IS 15 YEARS FROM SALE UNLESS MANUFACTURER SAYS USEFUL LIFE IS LONGER. TEXAS CIVIL PRACTICE & REMEDIES CODE ANN. 16.012. THANK YOU FOR YOUR TIME AND ATTENTION TO THIS SERIOUS SAFETY MATTER. *TR
NHTSA ODI #10911021
Mileage unknown · Aug 18, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V287000 (AIR BAGS). THE MANUFACTURER WAS UNABLE TO PROVIDE A REASONABLE TIME FRAME TO SUPPLY THE PART TO THE DEALER. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10896944
Mileage unknown · May 25, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V287000 (AIR BAGS), BUT THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10870794
156,000 miles · Apr 26, 2016
Engine
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING 45 MPH, THE CHECK ENGINE CODE: P0335 (CRANK SENSOR) ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CRANK SENSOR WAS REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V455000 (ENGINE A…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING 45 MPH, THE CHECK ENGINE CODE: P0335 (CRANK SENSOR) ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CRANK SENSOR WAS REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V455000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.
NHTSA ODI #10861601
185,000 miles · Feb 6, 2016
EngineVehicle Speed Control
MY NISSAN SENTRA DECIDED TO STALL OUT IN THE MIDDLE OF A VERY BUSY INTERSECTION. WAS ABLE TO RESTART THE NISSAN AFTER ABOUT 15 SECONDS. LATER THAT DAY I WAS UNABLE TO START MY CAR. BATTERY WAS JUMPED AND THE CAR WAS RUNNING UNTIL I TURNED MY HEADLIGHTS ON. I HAD TO BE TOWED HOME. I BELIEVE MY CAN SENSOR AND CRANK SENSOR NEE…
Read full complaint
MY NISSAN SENTRA DECIDED TO STALL OUT IN THE MIDDLE OF A VERY BUSY INTERSECTION. WAS ABLE TO RESTART THE NISSAN AFTER ABOUT 15 SECONDS. LATER THAT DAY I WAS UNABLE TO START MY CAR. BATTERY WAS JUMPED AND THE CAR WAS RUNNING UNTIL I TURNED MY HEADLIGHTS ON. I HAD TO BE TOWED HOME. I BELIEVE MY CAN SENSOR AND CRANK SENSOR NEED TO BE REPLACED AND THERE WAS A RECALL FOR THIS COMPLAINT BEFORE.
NHTSA ODI #10824649
79,000 miles · Dec 29, 2015
Air Bags
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE PASSENGER FRONTAL AIR BAG DEPLOYED, WHILE THE DRIVER WAS AT A COMPLETE STOP. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN NUMBER: 15V287000 (AIR BAGS) WAS PERFORMED IN JULY 28, 2014 HOWEVER, THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS NOTIFIED…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE PASSENGER FRONTAL AIR BAG DEPLOYED, WHILE THE DRIVER WAS AT A COMPLETE STOP. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN NUMBER: 15V287000 (AIR BAGS) WAS PERFORMED IN JULY 28, 2014 HOWEVER, THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
NHTSA ODI #10816795
60,000 miles · Dec 7, 2015
Engine
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING VARIOUS LOW SPEEDS, THE ENGINE STALLED WITHOUT WARNING. AFTER RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS IDENTICAL TO NHTSA CAMPAIGN NUMBER: 07V527000 (ENGI…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING VARIOUS LOW SPEEDS, THE ENGINE STALLED WITHOUT WARNING. AFTER RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS IDENTICAL TO NHTSA CAMPAIGN NUMBER: 07V527000 (ENGINE AND ENGINE COOLING); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10808852
149,000 miles · Sep 30, 2015
Engine
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY LOOSE POWER AND WOULD NOT ACCELERATE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WOULD NOT START AND WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT POS…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY LOOSE POWER AND WOULD NOT ACCELERATE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WOULD NOT START AND WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT POSITION SENSOR FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V527000 (ENGINE). THE FAILURE MILEAGE WAS 149,000.
NHTSA ODI #10778645
186,000 miles · Aug 7, 2015
Air Bags
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 13V136000 (AIR BAGS) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED AFTER THE RECALL REPAIR. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 13V136000 (AIR BAGS) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 186,000.
NHTSA ODI #10746951
124,000 miles · Jul 24, 2015
EnginePower Train
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING HIGHWAY SPEEDS, THE VEHICLE LOST ACCELERATION AND STALLED. THE CONTACT MANEUVERED THE VEHICLE TO THE SHOULDER OF THE HIGHWAY AND CHECKED THE OIL LEVEL. THE OIL WAS APPROXIMATELY TWO QUARTS LOW. AFTER TWENTY MINUTES, THE VEHICLE STARTED AGAIN AND THE FAILURE RECURRED THE CO…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. WHILE DRIVING HIGHWAY SPEEDS, THE VEHICLE LOST ACCELERATION AND STALLED. THE CONTACT MANEUVERED THE VEHICLE TO THE SHOULDER OF THE HIGHWAY AND CHECKED THE OIL LEVEL. THE OIL WAS APPROXIMATELY TWO QUARTS LOW. AFTER TWENTY MINUTES, THE VEHICLE STARTED AGAIN AND THE FAILURE RECURRED THE CONTACT HAD TO CALL A TOW TRUCK TO BRING THE VEHICLE TO AN INDEPENDENT MECHANIC. THE DIAGNOSIS WAS THAT THE PRE-CATALYST WAS DAMAGED AND CLOGGED AND NEEDED REPLACEMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 03V084000 (ENGINE AND ENGINE COOLING) A FEW YEARS BACK. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA ODI #10743386
Official recalls
10Dec 1, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Air Bags
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Jan 9, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.
May 15, 2015
Nissan North America, Inc. (Nissan) is recalling certain model year 2001-2003 Nissan Maxima, 2002-2004 Pathfinder, 2002-2006 Sentra, 2002-2003 Infiniti QX4 and I35, 2003 FX35 and FX45, and 2001 I30 vehicles. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger air bag inflator, free of charge. The recall began on June 15, 2015. Owners may contact Nissan customer service at 1-800-647-7261. Note: On December 18, 2015 Nissan informed NHTSA of an amendment of this recall to remove 2004-2005 Infiniti FX35 and FX45 vehicles.
Nov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 10, 2003
ON CERTAIN ELECTRIC VEHICLES, THE FRONT SUSPENSION TRANSVERSE LINK'S BALL JOINT BRACKET MAY BREAK FROM STRESS CONCENTRATION AT A NOTCH CREATED BY SURFACE ROUGHNESS AND THE SHAPE OF THE MATERIAL CUT-LINE.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE THE BRACKET ON THESE VEHICLES. OWNER NOTIFICATION BEGAN DECEMBER 15, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Nov 14, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH THE QG18DE ENGINE OR QR25DE ENGINES, THE FOAM MATERIAL USED FOR THE INTERIOR LINING OF THE ELECTRONIC CONTROL MODULE (ECM) BOX EMITS SULFUR AS IT CURES.
Consequence & remedy
Consequence: IF ONE OF THE RESISTORS INSIDE THE ECM HAS A CRACK ON THE SURFACE COATING, THE GAS MAY CAUSE CORROSION OF THE RESISTOR. THIS COULD CAUSE THE MALFUNCTION INDICATOR LIGHT TO COME ON, POOR DRIVABILITY (IDLE INSTABILITY, POOR ACCELERATOR), OR THE ENGINE TO STOP RUNNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REMOVE THE INSIDE LINING MATERIAL FROM THE ECM BOX. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Mar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
Feb 15, 2002
ON SOME PASSENGER VEHICLES EQUIPPED WITH A NISSAN-APPROVED ACCESSORY FLOOR MAT THAT WAS INSTALLED EITHER AT THE ASSEMBLY PLANT OR BY THE DEALER, DUE TO THE LENGTH OF THE DRIVER SIDE FLOOR MAT, A SMALL AMOUNT OF MAT MOVEMENT COULD CAUSE THE MAT TO INTERFERE WITH THE ACCELERATOR PEDAL AND NOT ALLOW THE PEDAL TO RELEASE AFTER IT IS DEPRESSED.
Consequence & remedy
Consequence: IF THIS OCCURS UNEXPECTEDLY, IT COULD LEAD TO A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER SIDE FLOOR MAT AND IF IT IS A NISSAN FLOOR MAT SUBJECT TO THIS RECALL, THE DEALER WILL REPLACE BOTH THE DRIVER AND PASSENGER SIDE FLOOR MATS. OWNER NOTIFICATION BEGAN MARCH 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Dec 12, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE VEHICLES WERE MISSING TAMPERPROOF CAPS THAT PREVENT HORIZONTAL HEADLAMP ADJUSTMENT.
Consequence & remedy
Consequence: THESE CAPS ARE INSTALLED TO PREVENT MISADJUSTMENT OF THE HEADLAMPS.
Remedy: DEALERS WILL INSTALL A TAMPERPROOF CAP OVER THE HORIZONTAL ADJUSTMENT SCREW FOR BOTH HEADLAMPS. OWNER NOTIFICATION BEGAN JANUARY 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration