NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
127 reportsClear category filter85,191 miles · Apr 14, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 03V455000 (ENGINE AND ENGINE COOLING) BUT TO NO AVAIL AS THE VEHICLE CONTINUED TO STALL. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOC…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 03V455000 (ENGINE AND ENGINE COOLING) BUT TO NO AVAIL AS THE VEHICLE CONTINUED TO STALL. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE CRANK SHAFT POSITION SENSORS. THE LOCAL MECHANIC REPLACED THE CRANK SHAFT POSITION SENSORS AND THE MANUFACTURER DENIED ANY ASSISTANCE WITH THE REPAIR. THE FAILURE AND THE CURRENT MILEAGE WAS 85,191.
NHTSA ODI #10395893
80,000 miles · Jan 10, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT WAS DRIVING 15 MPH WHEN THE ENGINE STALLED. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR INTERMITTENTLY WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY FAIL TO START. THE VEHICLE WAS LEFT AT THE DEALERS FOR FIVE MONTHS FOR EXTENSIVE …
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT WAS DRIVING 15 MPH WHEN THE ENGINE STALLED. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR INTERMITTENTLY WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY FAIL TO START. THE VEHICLE WAS LEFT AT THE DEALERS FOR FIVE MONTHS FOR EXTENSIVE DIAGNOSIS BUT THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE MANUFACTURER WAS CONTACTED WHO INFORMED THE CONTACT THAT THERE WERE NO RELATED RECALLS AND DID NOT OFFER ANY ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000. UPDATED 2/28/11 *CN UPDATED 05/04/11
NHTSA ODI #10375447
120,000 miles · Oct 19, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP REGARDING RECALL 03V455000 (ENGINE AND ENGINE COOLING) AND THE DEALER REPLACED THE INSULATION IN THE ECM. THE CONTACT ASKED THE DEALER TO INSPECT THE ECM TO MAKE SURE IT WAS FUNCTIONIN…
Read full complaint
TL*THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP REGARDING RECALL 03V455000 (ENGINE AND ENGINE COOLING) AND THE DEALER REPLACED THE INSULATION IN THE ECM. THE CONTACT ASKED THE DEALER TO INSPECT THE ECM TO MAKE SURE IT WAS FUNCTIONING CORRECTLY AND WAS BILLED FOR THE INSPECTION; HOWEVER, THE DEALER ALSO STATED THAT THE ECM NEEDED TO BE REPLACED AT THE CONTACTS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD CALL HER BACK. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 120,000.
NHTSA ODI #10361261
Mileage unknown · Oct 14, 2010
Engine And Engine CoolingEquipment
I TOOK MY VEHICLE A NISSAN SENTRA GXE 2002 FOR OIL CHANGE AT NISSAN AGINCOURT IN SCARBOROUGH IN SPRING 2010. THIS TIME I TOOK MY VEHICLE TO A MECHANIC FOR A OIL CHANGE. THE MECHANIC FROM CARFAX TOLD ME THE THE DIP STICK WAS BROKEN WHEN HE OPEN THE HOOD AND TRIED TO DO THE OIL CHANGE. HE MENTIONED THAT THEIR IS A RECALL FOR THE D…
Read full complaint
I TOOK MY VEHICLE A NISSAN SENTRA GXE 2002 FOR OIL CHANGE AT NISSAN AGINCOURT IN SCARBOROUGH IN SPRING 2010. THIS TIME I TOOK MY VEHICLE TO A MECHANIC FOR A OIL CHANGE. THE MECHANIC FROM CARFAX TOLD ME THE THE DIP STICK WAS BROKEN WHEN HE OPEN THE HOOD AND TRIED TO DO THE OIL CHANGE. HE MENTIONED THAT THEIR IS A RECALL FOR THE DIP STICK IN THIS VEHICLE. I CALLED THE NISSAN AT AGINCOURT WHERE DID MY LAST OIL CHANGE THEY TOLD ME THAT THERE IS NO RECALL FOR THE DIP STICK. I WAS GIVEN TO UNDERSTAND THIS IS A COMMON OCCURANCE FOR THIE NISSAN SENTRA 2002 GXE. THANK YOU. *TR
NHTSA ODI #10360475
132,000 miles · Oct 8, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE ENGINE OIL DIPSTICK TUBE WOULD FRACTURE EVERY ONE TO TWO YEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TUBE WAS REPLACED WITH A NEWER ONE AT THE CONTACTS EXPENSE. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT ON HOW TO REMOVE THE BROKEN DIPST…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN SENTRA. THE CONTACT STATED THAT THE ENGINE OIL DIPSTICK TUBE WOULD FRACTURE EVERY ONE TO TWO YEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TUBE WAS REPLACED WITH A NEWER ONE AT THE CONTACTS EXPENSE. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT ON HOW TO REMOVE THE BROKEN DIPSTICK. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 132,000.
NHTSA ODI #10359617
160,000 miles · Sep 6, 2010
Engine And Engine Cooling
WHILE DRIVING MY 2002 NISSAN SENTRA IT SHUTS OFF NO MATTER THE SPEED NOW. STARTED ONLY WHEN I WAS AT A STOP LIGHT, SIGN,OR GOING AT A SLOW SPEED. THIS HAS BEEN HAPPENING FOR 3 YEARS, HAVE THE MASS AIR FLOW SENSOR CHANGED, FUEL FILTER, AND STILL STOPPING. ALSO THE OIL DIP STICK KEEP BREAKING OFF. MOST RECENT SEPT 5, 2010 NOW …
Read full complaint
WHILE DRIVING MY 2002 NISSAN SENTRA IT SHUTS OFF NO MATTER THE SPEED NOW. STARTED ONLY WHEN I WAS AT A STOP LIGHT, SIGN,OR GOING AT A SLOW SPEED. THIS HAS BEEN HAPPENING FOR 3 YEARS, HAVE THE MASS AIR FLOW SENSOR CHANGED, FUEL FILTER, AND STILL STOPPING. ALSO THE OIL DIP STICK KEEP BREAKING OFF. MOST RECENT SEPT 5, 2010 NOW CAR WON'T START. *TR
NHTSA ODI #10354066
100,000 miles · Aug 24, 2010
Engine And Engine Cooling
1. THE ENGINE STOPPED RUNNING WITHOUT WARNING WHILE THE VEHICLE WAS DRIVEN. IT COULD HAVE CAUSED A CRASH. I COULDN'T START THE ENGINE UNTIL THE ENGINE WAS COOLED OFF. 2. IT OCCURRED ONCE, BUT IT IS STRONGLY BELIEVED TO BE RELATED TO A PREVIOUS CAMPAIGN (NHTSA CAMPAIGN ID NUMBER: 07V527000 AND 06V223) THE CONDITION, EVENTS AND…
Read full complaint
1. THE ENGINE STOPPED RUNNING WITHOUT WARNING WHILE THE VEHICLE WAS DRIVEN. IT COULD HAVE CAUSED A CRASH. I COULDN'T START THE ENGINE UNTIL THE ENGINE WAS COOLED OFF. 2. IT OCCURRED ONCE, BUT IT IS STRONGLY BELIEVED TO BE RELATED TO A PREVIOUS CAMPAIGN (NHTSA CAMPAIGN ID NUMBER: 07V527000 AND 06V223) THE CONDITION, EVENTS AND THE CONSEQUENCES ARE THE SAME. 3. A MECHANIC FIXED THE CONDITION BY REPLACING THE CRANK POSITION SENSOR, BUT I AM NOT SURE THE VEHICLE IS IN FAIR CONDITION. AIR FLOW METER WAS ALSO REPLACED ALTHOUGH IT IS NOT STRONGLY CORRELATED WITH THE I HAVE CONTACTED THE NISSAN USA AND A DEALER (DARCARS NISSAN), BUT I WAS TOLD THAT THERE IS NO CAMPAIGN FOR MY VEHICLE. *TR
NHTSA ODI #10351522
75,000 miles · Aug 20, 2010
Engine And Engine Cooling
BOUGHT NISSAN BRAND NEW IN 2002. THIS CAR IS ONLY 8 YEARS OLD WITH 75,000 MILES. FIRST THE CAR STARTED JERKING WHEN IT SITS STILL AT STOP SIGNS AND TRAFFIC LIGHTS. TOOK THE CAR TO MAINTENANCE SHOP AND PAID TO HAVE THE CATALYTIC CONVERTER REMOVED AND REPLACED. HOWEVER, AFTER A FEW MONTHS, IN APRIL THE CAR STARTS JERKING AGAIN…
Read full complaint
BOUGHT NISSAN BRAND NEW IN 2002. THIS CAR IS ONLY 8 YEARS OLD WITH 75,000 MILES. FIRST THE CAR STARTED JERKING WHEN IT SITS STILL AT STOP SIGNS AND TRAFFIC LIGHTS. TOOK THE CAR TO MAINTENANCE SHOP AND PAID TO HAVE THE CATALYTIC CONVERTER REMOVED AND REPLACED. HOWEVER, AFTER A FEW MONTHS, IN APRIL THE CAR STARTS JERKING AGAIN. PAID TO HAVE THE IGNITION COILS REPLACED BY THE DEALERSHIP. CAR ENGINE LIGHT STILL ON AND CAR STILL JERKING. CONTACTED NISSAN CORPORATION AND WAS TOLD THAT THE CAR WAS NOT UNDER RECALL. NOW THE DEALERSHIP REPLACES THE EGR VALVE AND 02 SENSOR. CAR ENGINE LIGHT STILL ON AND CAR STILL JERKING AS IF POSSESSED AS OF AUGUST 20, 2010. MONEY, MONEY AND MORE MONEY. *TR
NHTSA ODI #10350729
72,000 miles · Aug 13, 2010
Engine And Engine Cooling
I BOUGHT A 2002 NISSAN SENTRA SE-R WITH APPROXIMATELY 70K MILES ON IT. AT THE TIME OF PURCHASE THE ENGINE WAS RUNNING FINE, HOWEVER, AT APPROXIMATELY 72K MILES IT STARTED BURNING OIL AND I HAD TO PUT OIL IN THE ENGINE ONCE A WEEK. I TOOK THE CAR TO THE LOCAL DEALERSHIP WERE THEY REPLACED THE CATALYTIC CONVERTED DUE TO A RECALL…
Read full complaint
I BOUGHT A 2002 NISSAN SENTRA SE-R WITH APPROXIMATELY 70K MILES ON IT. AT THE TIME OF PURCHASE THE ENGINE WAS RUNNING FINE, HOWEVER, AT APPROXIMATELY 72K MILES IT STARTED BURNING OIL AND I HAD TO PUT OIL IN THE ENGINE ONCE A WEEK. I TOOK THE CAR TO THE LOCAL DEALERSHIP WERE THEY REPLACED THE CATALYTIC CONVERTED DUE TO A RECALL, BUT DID NOT STATE THAT THE ENGINE WAS DAMAGED TO THAT DEFECTIVE PART. I ASKED ABOUT AN ENGINE RECALL BUT NEVER RECEIVED AN ANSWER FROM THEM AS THEY SAID THE CAR WAS NOT UNDER WARRANTY AND HAD NO WARRANTS UNDER RECALL. *TR
NHTSA ODI #10349157
117,234 miles · Jul 22, 2010
Engine And Engine Cooling
THE CAR JUST STARTED CUTTING OFF. FIRST MECHANIC SAID BAD GAS, DID COMPUTER CHECK NOTHING. WOULD CUT OFF TURNING, FULL IDLE TO SILENT CUT OFF. NOW DOES IT ON START UP. *TR
NHTSA ODI #10344755
Official recalls
10Dec 1, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Air Bags
Nissan North America, Inc. (Nissan) is recalling certain 2002-2006 Sentra vehicles whose passenger air bags were previously inspected and may have been released without replacing the Takata air bag inflator. In the event of a crash, Takata frontal passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been completed. Nissan will notify owners, and dealers will re-inspect the vehicle and, if necessary, replace the air bag inflator, free of charge. The recall began January 22, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PM964.
Jan 9, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.
May 15, 2015
Nissan North America, Inc. (Nissan) is recalling certain model year 2001-2003 Nissan Maxima, 2002-2004 Pathfinder, 2002-2006 Sentra, 2002-2003 Infiniti QX4 and I35, 2003 FX35 and FX45, and 2001 I30 vehicles. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger air bag inflator, free of charge. The recall began on June 15, 2015. Owners may contact Nissan customer service at 1-800-647-7261. Note: On December 18, 2015 Nissan informed NHTSA of an amendment of this recall to remove 2004-2005 Infiniti FX35 and FX45 vehicles.
Nov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 10, 2003
ON CERTAIN ELECTRIC VEHICLES, THE FRONT SUSPENSION TRANSVERSE LINK'S BALL JOINT BRACKET MAY BREAK FROM STRESS CONCENTRATION AT A NOTCH CREATED BY SURFACE ROUGHNESS AND THE SHAPE OF THE MATERIAL CUT-LINE.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE THE BRACKET ON THESE VEHICLES. OWNER NOTIFICATION BEGAN DECEMBER 15, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Nov 14, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH THE QG18DE ENGINE OR QR25DE ENGINES, THE FOAM MATERIAL USED FOR THE INTERIOR LINING OF THE ELECTRONIC CONTROL MODULE (ECM) BOX EMITS SULFUR AS IT CURES.
Consequence & remedy
Consequence: IF ONE OF THE RESISTORS INSIDE THE ECM HAS A CRACK ON THE SURFACE COATING, THE GAS MAY CAUSE CORROSION OF THE RESISTOR. THIS COULD CAUSE THE MALFUNCTION INDICATOR LIGHT TO COME ON, POOR DRIVABILITY (IDLE INSTABILITY, POOR ACCELERATOR), OR THE ENGINE TO STOP RUNNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REMOVE THE INSIDE LINING MATERIAL FROM THE ECM BOX. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Mar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
Feb 15, 2002
ON SOME PASSENGER VEHICLES EQUIPPED WITH A NISSAN-APPROVED ACCESSORY FLOOR MAT THAT WAS INSTALLED EITHER AT THE ASSEMBLY PLANT OR BY THE DEALER, DUE TO THE LENGTH OF THE DRIVER SIDE FLOOR MAT, A SMALL AMOUNT OF MAT MOVEMENT COULD CAUSE THE MAT TO INTERFERE WITH THE ACCELERATOR PEDAL AND NOT ALLOW THE PEDAL TO RELEASE AFTER IT IS DEPRESSED.
Consequence & remedy
Consequence: IF THIS OCCURS UNEXPECTEDLY, IT COULD LEAD TO A CRASH.
Remedy: DEALERS WILL INSPECT THE DRIVER SIDE FLOOR MAT AND IF IT IS A NISSAN FLOOR MAT SUBJECT TO THIS RECALL, THE DEALER WILL REPLACE BOTH THE DRIVER AND PASSENGER SIDE FLOOR MATS. OWNER NOTIFICATION BEGAN MARCH 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Dec 12, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE VEHICLES WERE MISSING TAMPERPROOF CAPS THAT PREVENT HORIZONTAL HEADLAMP ADJUSTMENT.
Consequence & remedy
Consequence: THESE CAPS ARE INSTALLED TO PREVENT MISADJUSTMENT OF THE HEADLAMPS.
Remedy: DEALERS WILL INSTALL A TAMPERPROOF CAP OVER THE HORIZONTAL ADJUSTMENT SCREW FOR BOTH HEADLAMPS. OWNER NOTIFICATION BEGAN JANUARY 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration