NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
122 reportsClear category filter60,200 miles · Feb 9, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. While driving approximately 60 MPH, the vehicle decelerated to 30 MPH. The vehicle went into LIMP Mode; however, the vehicle was able to be driven to a certified mechanic. The mechanic diagnosed the vehicle and determined that the catalytic converter could have contributed to the failure. T…
Read full complaint
The contact owns a 2023 Nissan Rogue. While driving approximately 60 MPH, the vehicle decelerated to 30 MPH. The vehicle went into LIMP Mode; however, the vehicle was able to be driven to a certified mechanic. The mechanic diagnosed the vehicle and determined that the catalytic converter could have contributed to the failure. The mechanic retrieved DTC: U06652 and U2105 and associated the failure with NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The mechanic cleared the fault codes, and the vehicle was driven to the dealer. The dealer was unable to retrieve any fault codes. The fault codes returned after leaving the dealer, and the failure reoccurred. The vehicle was returned to the dealer the following day, and the dealer reprogrammed the engine control module(ECM) software. The failure persisted and the dealer then diagnosed the vehicle with an emissions failure. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,200.
NHTSA ODI #11716667
90,000 miles · Feb 6, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that the check engine warning light was illuminated, and the vehicle accelerated slowly with the RPM at 3,500. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling) days later. The vehicle was taken to the dealer, and it was conf…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that the check engine warning light was illuminated, and the vehicle accelerated slowly with the RPM at 3,500. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling) days later. The vehicle was taken to the dealer, and it was confirmed that the VIN was included in the recall. After running the test, the dealer concluded there were no issues with the vehicle and that only the battery needed to be replaced. The dealer reprogrammed the engine control module (ECM) software for the NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The contact was informed that the vehicle was included in another recall regarding the turbo charger under DTC: P4847; and replaced the turbo charger hose. The contact replaced the battery. Two days after replacing the battery, the vehicle failed to exceed 35 MPH, with the check engine warning light became illuminated. The vehicle was not returned to the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA ODI #11716112
Mileage unknown · Feb 2, 2026
Engine And Engine Cooling
See attached document for complaint. PLEASE ADVISE! In August of 2025 we received an important Safety Recall on our 2023 Nissan Rogue Vehicle ------copy enclosed. As of yet our car hasn’t been fixed and having a car with an engine that contains a manufacturing set of defects is alarming. Note------- the letter implied that if…
Read full complaint
See attached document for complaint. PLEASE ADVISE! In August of 2025 we received an important Safety Recall on our 2023 Nissan Rogue Vehicle ------copy enclosed. As of yet our car hasn’t been fixed and having a car with an engine that contains a manufacturing set of defects is alarming. Note------- the letter implied that if the engine fails while driving it--- the result would be loss of power. Can’t tell you our concern of having a crash and engine fire. We contacted our Nissan dealer twice now and was told Nissan Company has not gotten the part needed and how to administer it . This is our third Nissan Vehicle which is paid off. Please don’t make us “get rid” of our vehicle with this problem of worry! It is now as you know November 3, 2025 with no remedy in site. We don’t like traveling on the road knowing what could happen to us and our family at any time. We don’t want to make this a public issue for Nissan but we don’t see any effort from your company. We bought over the years Nissan vehicles as we valued their safety and service. Nissan’s performance is showing failure meeting its standards unacceptable!
NHTSA ODI #11715032
Mileage unknown · Jan 30, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The contact stated that while the vehicle was idling, it vibrated abnormally. No warning lights were illuminated. The vehicle was taken to the dealer; however, the contact was informed that the…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The contact stated that while the vehicle was idling, it vibrated abnormally. No warning lights were illuminated. The vehicle was taken to the dealer; however, the contact was informed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.
NHTSA ODI #11714564
Mileage unknown · Jan 29, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The local dealer was contacted, and the contact was informed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amou…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The local dealer was contacted, and the contact was informed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA ODI #11714241
76,071 miles · Jan 8, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle lost drive power with several unknown warning lights illuminated. There was white smoke coming from the rear of the vehicle. The vehicle was coasted to the side of the road. The vehicle was first towed to an independe…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle lost drive power with several unknown warning lights illuminated. There was white smoke coming from the rear of the vehicle. The vehicle was coasted to the side of the road. The vehicle was first towed to an independent mechanic, but it was not diagnosed. The vehicle was then towed to the dealer, who determined that the engine had failed due to coolant intrusion into the engine from faulty bearings. The dealer informed the contact that the engine needed to be replaced. The contact later received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the failure was not covered by the recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 76,071.
NHTSA ODI #11709598
90,000 miles · Jan 7, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The contact stated that while driving approximately 70 MPH, the vehicle lost power. The contact pulled over to the side of the road, and there was smoke coming from the engine compartment. The …
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The contact stated that while driving approximately 70 MPH, the vehicle lost power. The contact pulled over to the side of the road, and there was smoke coming from the engine compartment. The vehicle was towed to a dealer, where it was diagnosed, and determined that the engine needed to be replaced due to the main bearing failure. The vehicle was not repaired. The manufacturer was notified of the failure, but refused to repair the vehicle because sludge was found in the oil pan. The failure mileage was approximately 90,000.
NHTSA ODI #11709401
76,000 miles · Jan 5, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that upon starting the vehicle, there was an abnormal clanking sound coming from the engine. There was no warning light illuminated. The contact proceeded to drive the vehicle; however, the vehicle failed to properly accelerate while driving 60 MPH and attempting to accele…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that upon starting the vehicle, there was an abnormal clanking sound coming from the engine. There was no warning light illuminated. The contact proceeded to drive the vehicle; however, the vehicle failed to properly accelerate while driving 60 MPH and attempting to accelerate. The contact stated that the vehicle started to decelerate, and the contact pulled off to the shoulder of the highway. Due to the failure, the vehicle was towed to a dealer. A diagnostic test was performed on the vehicle, and metal shavings were found inside the oil pan. The vehicle was diagnosed with engine failure. The contact was informed that the engine long block and turbo needed to be replaced. Upon investigation, the contact discovered NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The contact reached out to the manufacturer, and it was confirmed that the VIN was not included in the recall. The vehicle remained with the dealer unrepaired. The failure mileage was 76,000.
NHTSA ODI #11708760
29,000 miles · Jan 2, 2026
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, parts to do the recall repair were not yet available. The vehicle was taken t…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); however, parts to do the recall repair were not yet available. The vehicle was taken to a dealer, but was not diagnosed or repaired. The dealer confirmed that parts were not available for the repair and informed the contact that a second notification letter would be issued once parts became available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle remained unrepaired. The approximate failure mileage was 29,000.
NHTSA ODI #11708314
83,000 miles · Dec 17, 2025
Engine And Engine Cooling
The contact owns a 2023 Nissan Rogue. The contact stated that while driving approximately 30 MPH, the vehicle suddenly started shaking and vibrating abnormally before the vehicle stalled. During the failure, the message "Engine Failure" was displayed. The vehicle was later towed to the local dealer, who discovered metal shavings…
Read full complaint
The contact owns a 2023 Nissan Rogue. The contact stated that while driving approximately 30 MPH, the vehicle suddenly started shaking and vibrating abnormally before the vehicle stalled. During the failure, the message "Engine Failure" was displayed. The vehicle was later towed to the local dealer, who discovered metal shavings inside the oil pan and advised the contact that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V437000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 83,000.
NHTSA ODI #11705519
Official recalls
6Feb 11, 2026
Nissan North America, Inc. (Nissan) is recalling certain 2023-2025 Rogue vehicles equipped with 3-cylinder 1.5L variable compression turbo (VC-Turbo) engines. Increased temperatures can break down the engine oil, which may cause the engine bearings to seize and become damaged, leading to engine failure.
Consequence & remedy
Consequence: Engine failure can cause a loss of drive power, increasing the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, inspect for diagnostic trouble codes, and test drive the vehicle, free of charge. The dealer may also inspect the oil pan for metal debris, and replace the engine if necessary. Repairs will be performed free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261. Nissan's numbers for this recall are R25E2 and R25E3. This recall expands previous NHTSA recall number 25V437. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 27, 2026.
Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Feb 28, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue vehicles. The driver and front passenger seat belt pretensioners may have been incorrectly manufactured, which can cause the seat belts to not properly restrain occupants. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection," 209, "Seat Belt Assemblies," and 210 "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: Improperly restrained occupants have an increased risk of injury during a crash.
Remedy: Dealers will replace the front seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed April 26, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PD105.
Feb 27, 2024
Nissan North America, Inc. (Nissan) is recalling certain 2024 Titan, Frontier, Infiniti QX60, Pathfinder, 2023-2024 Sentra, Versa, Kicks, Infiniti QX50, and 2023 Rogue vehicles. Due to a manufacturing issue, the driver's air bag inflator may absorb moisture, and cause the air bag to deploy improperly.
Consequence & remedy
Consequence: An air bag that deploys improperly may not protect the driver as intended during a crash, increasing the risk of injury.
Remedy: Dealers will replace the front driver's air bag assembly, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's numbers for this recall are PD103, PD104, and PMA34.
May 25, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Nissan Rogue vehicles. The fastener in the rear seat belt anchor attachment points may not have been tightened properly and can loosen over time.
Consequence & remedy
Consequence: A loose rear seat belt anchor fastener may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt anchor bolts. Additionally, dealers will apply warning labels to the seat belt attachment points to indicate the bolt size and torque value required for any future seat belt repair. Repairs will be performed free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC978, PC979.
Apr 13, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2023 Rogue, Pathfinder, and Infiniti QX60 vehicles. The driver's powered seat may not be fully secured to the seat frame, causing the seat frame welds to detach from the rear inboard seat bracket.
Consequence & remedy
Consequence: An unsecured seat with broken welds may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the driver's seat rail clearance, and if necessary, replace the driver's seat cushion frame, free of charge. Owner notification letters are expected to be mailed June 10, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC966, PC967.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration