NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
16 reportsClear category filterMileage unknown · Aug 21, 2026
EnginePower TrainVehicle Speed Control
My 2022 Nissan Rogue has entered reduced-power/limp mode approximately nine times. The specific component causing the malfunction has not been identified. The vehicle is available for inspection upon request. When the malfunction occurs, the vehicle displays a malfunction/reduced-power warning and substantially reduces availabl…
Read full complaint
My 2022 Nissan Rogue has entered reduced-power/limp mode approximately nine times. The specific component causing the malfunction has not been identified. The vehicle is available for inspection upon request. When the malfunction occurs, the vehicle displays a malfunction/reduced-power warning and substantially reduces available engine power. Several occurrences happened during a long-distance trip involving highway, mountain, and desert driving. The unexpected reduction in power creates a safety concern during highway travel, merging, passing, climbing grades, or travel in remote areas. The problem is intermittent and has not been successfully reproduced by an authorized Nissan dealership. I presented the vehicle to a Nissan dealer and reported the repeated events while the vehicle had approximately 56,500 miles and remained below Nissan's 60,000-mile powertrain warranty mileage limit. The dealership advised that it could not diagnose the problem unless the malfunction occurs again with an active diagnostic code. I have also reported the problem to Nissan Consumer Affairs. The underlying cause remains unidentified and the vehicle has not been repaired for this condition. Warning messages appear when the malfunction occurs. During the long-distance trip, diagnostic codes were cleared to restore vehicle operation. The vehicle would then operate normally for a period before unexpectedly entering reduced-power mode again. My primary concern is that after approximately nine occurrences, I still have no diagnosis or assurance that the condition will not recur during highway operation or another situation where maintaining vehicle power is necessary for safe operation.
NHTSA ODI #11758582
Mileage unknown · Jul 8, 2026
EngineVehicle Speed Control
I am reporting a serious safety concern involving my 2022 Nissan Rogue equipped with the 1.5L engine. While driving in normal traffic, my vehicle suddenly displayed an "Engine Malfunction" warning with no prior indication of an engine problem. Immediately after the warning appeared, the vehicle rapidly lost power and could no l…
Read full complaint
I am reporting a serious safety concern involving my 2022 Nissan Rogue equipped with the 1.5L engine. While driving in normal traffic, my vehicle suddenly displayed an "Engine Malfunction" warning with no prior indication of an engine problem. Immediately after the warning appeared, the vehicle rapidly lost power and could no longer maintain the speed of surrounding traffic. I had very limited ability to accelerate or safely maneuver, creating a significant risk of being struck from behind or becoming stranded in an active travel lane. There was no advance warning that a catastrophic engine failure was imminent. The vehicle ultimately became inoperable and was towed to an authorized Nissan dealership. The dealership diagnosed the engine with coolant leaking into the cylinders and determined that replacement of the engine assembly, turbocharger, and catalytic converter was required at an estimated cost exceeding $10,000. My vehicle had previously experienced engine-related concerns and was included in Recall Campaign R25D1. That recall was completed, but less than 30 days later the engine failed catastrophically. Based on this sequence of events, I am concerned that the existing recall may not identify or address all engine conditions that can result in sudden loss of motive power and catastrophic engine failure. I have since learned of numerous publicly reported complaints from other owners describing similar failures involving coolant intrusion, sudden loss of power, and complete engine replacement in 2022 Nissan Rogue vehicles equipped with this engine. I respectfully request that NHTSA investigate whether these engine failures represent a broader safety defect and whether additional corrective action is necessary to protect the driving public.
NHTSA ODI #11748992
Mileage unknown · Mar 5, 2026
Electrical SystemEngineVehicle Speed Control
I have been in and out of the shop since May of 2025 I have a paper trail of all dates and events including the times I did go in for a recall the times I was changed whe I should have never been charged , bout 3 or 4 times . I’m on the interstate and I’m going like 74/75/76 and my speed drops on me to like a 10-15 and I try to …
Read full complaint
I have been in and out of the shop since May of 2025 I have a paper trail of all dates and events including the times I did go in for a recall the times I was changed whe I should have never been charged , bout 3 or 4 times . I’m on the interstate and I’m going like 74/75/76 and my speed drops on me to like a 10-15 and I try to move as quickly as possible because everyyyyy time that has happened to me it’s either I’m finna cause an accident or an accident between me and another or two other HOW MANY TIMES DO I HAVE TO VOICE THIS , I’m afraid I will lose my life behind this vehicle because of these issue and what make it so bad I keep Being told it’s not due to the recall but in fact I know it is I will get a lawyer involved if I have to just this pass month in February I went through the same thing again and I keep being responsible for the repairs that have something to do with the engine but Miracle Nissan of Augusta on Washington rd keep telling me it’s not that when it is. I need some one to help me I tried to get in contact with Nissan community affairs they sent out someone to the dealership but the manager at the dealership told me a different time than the lady rep I was speaking with at Nissan community affairs told me so I was confused, when that day come about for the DTS /DTC APPOINTMENT the person came to Augusta, Ga Nissan location and spoken with the manager already before I could even meet with them about my own car . And I have been having these issues since May I NEED SOMEONE TO HELP ME give me a call [XXX] email [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11722308
Mileage unknown · Dec 19, 2025
Electrical SystemPower TrainVehicle Speed Control
I bring my car for a recall notice on the 11/28/25 , and on Saturday 11/29/25 my car lost power he couldn't go faster than 45 mph. and the engine light on and 3 other lights was on to, I bring my car back to the dealer and they told me it was the oil cooler thermostat and bled system they charged me 1203.20 for the fix. and they…
Read full complaint
I bring my car for a recall notice on the 11/28/25 , and on Saturday 11/29/25 my car lost power he couldn't go faster than 45 mph. and the engine light on and 3 other lights was on to, I bring my car back to the dealer and they told me it was the oil cooler thermostat and bled system they charged me 1203.20 for the fix. and they keep my car for 3 days. finally , they returned the car to me on 12/2/25 I drove it for short time and it happened again same problem same engine light on, lost the power and lot of smoke come out of the muffler, My family and I ran out of the car because I thought it was to catch on fire, people around also saw the smoke and ran. I bring my car back to the dealer on 12/4/25 they keep for 3 more day they told me it was code u0652 tested power and ground tested PIN FITMENT AT EMC AND EGR SENSOR on 12/6/25 returned my car back to me.
NHTSA ODI #11706058
Mileage unknown · Nov 15, 2025
EngineUnknown Or OtherVehicle Speed Control
I HAVE EXPERIENCED UNUSUAL ENGINE NOISES, ROUGH ENGINE PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT (MIL), AND WARNING MESSAGES DISPLAYED IN THE INSTRUMENT CLUSTER. THE ENGINE HAS FAILED WHILE THE VEHICLE WAS IN MOTION, RESULTING IN A LOSS OF MOTIVE POWER TWICE, ONCE ON THE HIGHWAY. I have been to the dealership…
Read full complaint
I HAVE EXPERIENCED UNUSUAL ENGINE NOISES, ROUGH ENGINE PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT (MIL), AND WARNING MESSAGES DISPLAYED IN THE INSTRUMENT CLUSTER. THE ENGINE HAS FAILED WHILE THE VEHICLE WAS IN MOTION, RESULTING IN A LOSS OF MOTIVE POWER TWICE, ONCE ON THE HIGHWAY. I have been to the dealership mechanic 3 times with this issue, the first occurred prior to the recall coming out. The Last time I was told to pay for a diagnostic or they would not be able to help me; I paid and was told they could not find anything relevant to my issue. I was just told that there was no further information occurring from this recall. I feel as if the car is almost undrivable. It is definitely unsafe and unreliable. And a car constantly revs at 6000 RPM's prior to switching gears if it switches gears. At this point I don't know what to do and regret buying a Nissan as they won't even help.
NHTSA ODI #11699573
Mileage unknown · Oct 13, 2025
Unknown Or OtherVehicle Speed ControlCrash
I took my Rogue to the dealership at City Limits Nissan on Monday 10/6/25 as it had power issues and the engine light came on stating 'Engine Malfunction Power reduce Service now' I then called NHTSA and filed a complaint about a recall for my Nissan Rogue that Nissan has yet to have a remedy. I got the car back on Tuesday afte…
Read full complaint
I took my Rogue to the dealership at City Limits Nissan on Monday 10/6/25 as it had power issues and the engine light came on stating 'Engine Malfunction Power reduce Service now' I then called NHTSA and filed a complaint about a recall for my Nissan Rogue that Nissan has yet to have a remedy. I got the car back on Tuesday afternoon 10/7/25 and they said it did not have to do with the recall. I drove the car straight home. I went to work the next morning and as I was pulling into a parking spot in parking garage, all of the sudden, I was crashed into the wall at a high rate of speed. I am extremely concerned that this may have been a malfunction with the Nissan Rogue as this occurred less then 24 hours after it was serviced. My car was totaled and the damage looks like it hit at 30 mph or more which is extremely alarming as I was slowing coming into the parking spot. I don't know exactly what happened however if there have been any issues with Nissans and sudden acceleration, I feel this needs to be investigated. My Rogue is a 2022 and had to have the engine replaced in early 2024. Nissan could not give any explanation as to why. My car has been taken to a salvage yard and I am concerned that if there was and issue, any evidence of an issued could be destroyed. Had there not been heavy duty cables, I could have gone further through the parking garage wall and fallen 3 stories.
NHTSA ODI #11693144
200 miles · Sep 9, 2025
Engine And Engine CoolingVehicle Speed Control
The contact owns a 2022 Nissan Rogue. The contact stated that the accelerator pedal became stuck while driving approximately 10-25 MPH in a parking lot on two occasions. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The vehicle was tak…
Read full complaint
The contact owns a 2022 Nissan Rogue. The contact stated that the accelerator pedal became stuck while driving approximately 10-25 MPH in a parking lot on two occasions. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling). The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The dealer confirmed that parts were not yet available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 200.
NHTSA ODI #11685864
Mileage unknown · Jul 19, 2025
Electrical SystemEngineVehicle Speed Control
I don’t know what malfunctioned excatly but I was driving on highway at 65 mph and vehicle just shut down so I pulled car off to side the dash said engine malfunction car shutting down to save engine. And hasn’t started since. But prior to that I have had issues since I got the car about 4000 miles into driving is when everythin…
Read full complaint
I don’t know what malfunctioned excatly but I was driving on highway at 65 mph and vehicle just shut down so I pulled car off to side the dash said engine malfunction car shutting down to save engine. And hasn’t started since. But prior to that I have had issues since I got the car about 4000 miles into driving is when everything started the dash said engine malfunction power reduced service now. I informed Nissan dealership right away brought it into there shop and they didn’t do anything just wanted to sell me another car I have nothing but problems and headaches with this car and yes me and my wife’s safety was at risk a few time cause when it malfunctions the power reduced and when it just shut down completely I was in far lane and almost go hit trying to merge off road.and due to it braking down I had to leave vehicle to go get a car dolly was gone about 2 hours and came back and vehicle windows were broken and everything was stolen out of my car of value. The other issue the intercooler went out and that cause a big problem I have the repair invoice somewhere but have to locate it
NHTSA ODI #11674736
Mileage unknown · Dec 13, 2024
EngineService BrakesVehicle Speed Control
3/25/2023 784 miles and 12 days after purchasing the vehicle The throttle got stuck, cruise was on but not activated, was going 100mgh, hit the brakes, slowed the speed, every time I took my foot off the brake, I was doing 90-100mph. I hit the brakes 5-7 times to try to cancel the cruise even though it was was set. It said "Acti…
Read full complaint
3/25/2023 784 miles and 12 days after purchasing the vehicle The throttle got stuck, cruise was on but not activated, was going 100mgh, hit the brakes, slowed the speed, every time I took my foot off the brake, I was doing 90-100mph. I hit the brakes 5-7 times to try to cancel the cruise even though it was was set. It said "Activate" so it was not on. Then after hitting the brakes repeatedly, I heard a loud kerplunk (metal on metal) sound in the engine behind the brake pedal, and it shut off and drove normally afterwards. 3/30/2023 I accelerated to get on I35 and RPM stuck at 3200 and would not shift in sport mode; I changed to Standard mode and the RPMs dropped to 2000-2100; the engine revved up loud in sport mode. Female Service Manager from Burleson Nissan was in the car at the time of the event. This has happened 3 more times since owning this vehicle. At the advice of my lemon law attorney, I am reporting them separately.
NHTSA ODI #11630588
Mileage unknown · Oct 21, 2024
EngineSteeringVehicle Speed Control
Car engine light came on and the vehicle automatically slowed itself down to 20 mph as I was in a 45 mph zone, with multiple traffic behind me. No warning!! A hazard sign lit and the MIL lit up, saying there is an emissions control system malfunction and to immediately take the car to a repair station. NissanConnect also sent me…
Read full complaint
Car engine light came on and the vehicle automatically slowed itself down to 20 mph as I was in a 45 mph zone, with multiple traffic behind me. No warning!! A hazard sign lit and the MIL lit up, saying there is an emissions control system malfunction and to immediately take the car to a repair station. NissanConnect also sent me a text at 5:12 Saturday night, all repair stations closed. This was very dangerous and the system should not have taken over complete control of the car at that very instant, leaving me completely unable to control the car. It was out of the blue, and I’m still shaking.
NHTSA ODI #11621065
Official recalls
6Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Oct 13, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Titan, Titan XD, Frontier, and 2021-2022 Rogue vehicles. The in-vehicle infotainment (IVI) system may continuously reboot when the vehicle is restarted, which can result in an inoperative rearview display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The IVI software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed November 18, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's numbers for this recall are R22B8, R22C1, and PC923/25.
Sep 1, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue vehicles. The rear seat belts for the left-hand and right-hand rear seats may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 209, "Seatbelt Assemblies."
Consequence & remedy
Consequence: Seat belts that do not retract properly may be difficult to operate, preventing their usage, which can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear seat belts, as necessary, free of charge. Owner notification letters are expected to be mailed October 27, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC915.
Aug 31, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. The fuel tank may have been punctured when vehicle modifications were performed.
Consequence & remedy
Consequence: A hole in the fuel tank could leak, increasing the risk of fire.
Remedy: Dealers will inspect and replace the fuel tank as necessary, free of charge. Owner notification letters are expected to be mailed September 23, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC912.
Jul 21, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Back Over Prevention: Sensing System: Camera
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Apr 14, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. Due to a manufacturing error, an area on the bottom wall of the fuel tank may be too thin.
Consequence & remedy
Consequence: Road debris may puncture the thin fuel tank wall, causing a gas leak and increasing the risk of a fire. In addition, the fuel tank may not perform as expected during a crash, increasing the risk of injury.
Remedy: Dealers will replace the fuel tank assembly and install a new lock ring, gasket, and o-ring seal, free of charge. Owner notification letters were mailed May 19, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration