NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
21 reportsClear category filterMileage unknown · Sep 3, 2026
Electrical SystemEnginePower Train
My 2022 Nissan Rogue 1.5L VC-Turbo is experiencing repeated limp-mode/reduced-power events, severe hesitation, poor acceleration, rough/shaking idle, and recurring DTC U0652 after Nissan marked recall 25V-437 complete. The vehicle is available for inspection. Reduced-power symptoms were documented as early as Dec. 2024 and sign…
Read full complaint
My 2022 Nissan Rogue 1.5L VC-Turbo is experiencing repeated limp-mode/reduced-power events, severe hesitation, poor acceleration, rough/shaking idle, and recurring DTC U0652 after Nissan marked recall 25V-437 complete. The vehicle is available for inspection. Reduced-power symptoms were documented as early as Dec. 2024 and significantly worsened by Oct. 3, 2025 at approximately 100,400 miles, including loss of power at highway speed. I previously reported this condition to NHTSA under Complaint #11696068. The first Nissan dealer (Willis) used a borescope, claimed “sludge,” recommended engine replacement, refused to provide supporting photos/evidence, and did not remove the oil pan. Willis later provided me an oil sample, which I submitted for independent analysis. That analysis showed multiple bearing-associated wear metals without an abnormal viscosity condition explaining the findings, and confirmed the oil pan was had not been checked. A second Nissan dealer was contacted to performed Nissan’s recall screening/software procedure. No engine light could be on upon arrival. Because the intermittent condition did not occur during the brief test, Nissan marked the recall complete. The warning light is now illuminated again and the vehicle is again entering limp mode/reduced power. I contacted Nissan for assistance and was told they would not provide towing or further recall assistance because the recall is listed as complete. I am currently stranded with the same safety condition after Nissan declared the vehicle remedied. My complaint is failed recall remedy/recall effectiveness. Nissan’s screening process classified this vehicle as remedied, but the safety condition continues and appears progressive. Nissan is now using its own “recall complete” status to refuse further action despite recurring loss of power and independent evidence of internal engine wear.
NHTSA ODI #11761960
Mileage unknown · Aug 26, 2026
Air BagsElectrical SystemUnknown Or Other
On June 12, 2026, while driving my 2022 Nissan Rogue on the Grand Central Expressway in New York, the engine suddenly shut down and the vehicle lost motive power in active highway traffic. The vehicle would not restart. I called 911, and police responded and protected the disabled vehicle until it could be towed to safety. I la…
Read full complaint
On June 12, 2026, while driving my 2022 Nissan Rogue on the Grand Central Expressway in New York, the engine suddenly shut down and the vehicle lost motive power in active highway traffic. The vehicle would not restart. I called 911, and police responded and protected the disabled vehicle until it could be towed to safety. I later learned the vehicle was subject to Nissan Safety Recall R25D1 / NHTSA 25V-437 involving engine bearing defects that may cause engine damage and loss of motive power. A Nissan dealer inspected the vehicle and documented that the engine would not turn over. The technician removed the oil pan, found metal debris, and determined the engine was seized. Nissan subsequently replaced the engine and turbocharger. After the replacement, I began experiencing additional problems. The vehicle hesitated during acceleration. On August 15, the Check Engine light illuminated with an “Engine Malfunction” warning. The dealer subsequently replaced an exhaust-related sensor. On August 23, the SRS/Air Bag warning light illuminated and remained on before later turning off. The same SRS warning occurred again on August 24, and the vehicle also failed to start on the first attempt. On August 26, another warning appeared stating “Malfunction – See Owner’s Manual.” Nissan Consumer Affairs advised me that these subsequent problems are unrelated to the engine recall. I am concerned about the continuing safety and reliability problems occurring shortly after the engine and turbo replacement and am requesting that NHTSA document and evaluate these incidents for a potential safety defect.
NHTSA ODI #11759667
Mileage unknown · Aug 11, 2026
Air BagsElectrical SystemEngineFire
I was driving when I was pulled over by a police officer for speeding I was going 5 over the speed limit (Speed limit was 65). As the officer approached my vehicle, he noticed flames coming from the engine compartment before I was aware there was any issue. He immediately instructed me to exit the vehicle for my safety. After I…
Read full complaint
I was driving when I was pulled over by a police officer for speeding I was going 5 over the speed limit (Speed limit was 65). As the officer approached my vehicle, he noticed flames coming from the engine compartment before I was aware there was any issue. He immediately instructed me to exit the vehicle for my safety. After I got out, the officer attempted to put out the fire with a fire extinguisher, but the flames continued to spread despite his efforts. The fire quickly intensified, causing extensive damage to the vehicle. Emergency responders were called to the scene to extinguish the fire, but by the time the fire was under control, the vehicle had sustained severe fire damage and was no longer operable.
NHTSA ODI #11756342
Mileage unknown · Jun 3, 2026
Electrical SystemEnginePower Train
I own a 2022 Nissan Rogue with approx 71,139 miles on. While driving on the freeway at 65mph, the vehicle suddenly lost power and became disabled. Prior to the failure, the vehicle did not dispaly an overheating warning, coolant warning, or other indication the engine was overheating or experiencing coolant loss. The vehicle was…
Read full complaint
I own a 2022 Nissan Rogue with approx 71,139 miles on. While driving on the freeway at 65mph, the vehicle suddenly lost power and became disabled. Prior to the failure, the vehicle did not dispaly an overheating warning, coolant warning, or other indication the engine was overheating or experiencing coolant loss. The vehicle was being driven normally and was on the way to routine maintenance and fuel stop when the failure occurred. An independent repair facility diagnosed coolant intrusion into the combustion chamber and determined the engine had overheated and required replacement. The vehicle's sudden loss of propulsion occurred without warning creating a safety hazard for myself and my daughter as I was forced to coast to a stop in the Gore Area of the freeway just as you entered the [XXX] from [XXX] due to the inability to maintain speed on the freeway. This was the safest area for us to park but it was terrifying as cars zoomed past us from both sides. I am concerned that the engine failed without adequate warning to the driver and that similar complaints have been noted by several others describing the same issue with the same year, make and model as my car. Multiple reports have said it occurred while on the freeway, making this a greater concern for safety. I took my car to Nissan who stated they see the coolant intrusion, but that it was not covered under recall. I asked what caused the internal leak, to which they replied that would require them to take apart the engine to examine further at my cost. I advised the issue with the car not indicating it was even out of coolant to cause it to overheat was concerning because even if I replace the engine, if the electrical failure isn't addressed I could run into the same issue and this time actually get into an accident that could cause death or serious injury. My car is still at Nissan Mission Hills Dealership and available for inspection upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11741844
Mileage unknown · Mar 9, 2026
Electrical SystemEnginePower Train
Car electrical dash lights up, powertrain, strange noises, electrical glitches, engine stalling, carbon monoxide or gasoline smell, makes me dizzy when turn on the ac
NHTSA ODI #11723088
Mileage unknown · Mar 5, 2026
Electrical SystemEngineVehicle Speed Control
I have been in and out of the shop since May of 2025 I have a paper trail of all dates and events including the times I did go in for a recall the times I was changed whe I should have never been charged , bout 3 or 4 times . I’m on the interstate and I’m going like 74/75/76 and my speed drops on me to like a 10-15 and I try to …
Read full complaint
I have been in and out of the shop since May of 2025 I have a paper trail of all dates and events including the times I did go in for a recall the times I was changed whe I should have never been charged , bout 3 or 4 times . I’m on the interstate and I’m going like 74/75/76 and my speed drops on me to like a 10-15 and I try to move as quickly as possible because everyyyyy time that has happened to me it’s either I’m finna cause an accident or an accident between me and another or two other HOW MANY TIMES DO I HAVE TO VOICE THIS , I’m afraid I will lose my life behind this vehicle because of these issue and what make it so bad I keep Being told it’s not due to the recall but in fact I know it is I will get a lawyer involved if I have to just this pass month in February I went through the same thing again and I keep being responsible for the repairs that have something to do with the engine but Miracle Nissan of Augusta on Washington rd keep telling me it’s not that when it is. I need some one to help me I tried to get in contact with Nissan community affairs they sent out someone to the dealership but the manager at the dealership told me a different time than the lady rep I was speaking with at Nissan community affairs told me so I was confused, when that day come about for the DTS /DTC APPOINTMENT the person came to Augusta, Ga Nissan location and spoken with the manager already before I could even meet with them about my own car . And I have been having these issues since May I NEED SOMEONE TO HELP ME give me a call [XXX] email [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11722308
Mileage unknown · Jan 30, 2026
Electrical System
Camera system failure and it has been a year with no response from Nissan. A recall was made for this issue but it was only for rental cars mine was never a rental and other nissan rogue owners are reporting the same issue with their cars. I park inside a parking garage so my car is covered.
NHTSA ODI #11714606
Mileage unknown · Jan 1, 2026
Electrical SystemEngineFuel/propulsion System
Blinking lights on dashboard, notified Nissan, they stated they knew of recall, but didn't know how to resolve yet, engineers were working on the issue, they stated when it breaks down just bring it in. Car engine light blinks, all warning lights blink, car stops immediately while pulling into to drive way. Lights appeared 1 da…
Read full complaint
Blinking lights on dashboard, notified Nissan, they stated they knew of recall, but didn't know how to resolve yet, engineers were working on the issue, they stated when it breaks down just bring it in. Car engine light blinks, all warning lights blink, car stops immediately while pulling into to drive way. Lights appeared 1 day ago, then drove ok. Started car this morning to go to work, 4 miles away pulled in and car started blinking all emergency lights, Quickly called Nissan they were closed to due to holiday. Emergency lites are check engine light, FEB light, MASTER warning light, AEB lights , Malfunction Indicator light (MIL). RAB light, the start button contents blink when all theses lights are blinking. The fact that Nissan told me to wait till it breaks down, or they would call me to fix recall when they know how is irresponsible .
NHTSA ODI #11708223
Mileage unknown · Dec 19, 2025
Electrical SystemPower TrainVehicle Speed Control
I bring my car for a recall notice on the 11/28/25 , and on Saturday 11/29/25 my car lost power he couldn't go faster than 45 mph. and the engine light on and 3 other lights was on to, I bring my car back to the dealer and they told me it was the oil cooler thermostat and bled system they charged me 1203.20 for the fix. and they…
Read full complaint
I bring my car for a recall notice on the 11/28/25 , and on Saturday 11/29/25 my car lost power he couldn't go faster than 45 mph. and the engine light on and 3 other lights was on to, I bring my car back to the dealer and they told me it was the oil cooler thermostat and bled system they charged me 1203.20 for the fix. and they keep my car for 3 days. finally , they returned the car to me on 12/2/25 I drove it for short time and it happened again same problem same engine light on, lost the power and lot of smoke come out of the muffler, My family and I ran out of the car because I thought it was to catch on fire, people around also saw the smoke and ran. I bring my car back to the dealer on 12/4/25 they keep for 3 more day they told me it was code u0652 tested power and ground tested PIN FITMENT AT EMC AND EGR SENSOR on 12/6/25 returned my car back to me.
NHTSA ODI #11706058
Mileage unknown · Dec 15, 2025
Electrical SystemEnginePower Train
The vehicle, a 2022 Nissan Rogue with the 1.5L VC-Turbo engine, suddenly entered severe limp mode: unable to exceed 35-40 mph on flat roads, barely 10 mph on hills, with high RPM and noise. The malfunction indicator light illuminated along with "engine malfunction service now" message and triangle warning light. These symptoms e…
Read full complaint
The vehicle, a 2022 Nissan Rogue with the 1.5L VC-Turbo engine, suddenly entered severe limp mode: unable to exceed 35-40 mph on flat roads, barely 10 mph on hills, with high RPM and noise. The malfunction indicator light illuminated along with "engine malfunction service now" message and triangle warning light. These symptoms exactly match the early warning signs in safety recall 25V-437 for defective engine bearings that can cause progressive degradation, engine damage, or failure.The vehicle was towed to an authorized Nissan dealer, who performed the recall inspection (oil pan drop) but reportedly found no metal debris. The dealer then diagnosed separate issues—oil temperature sensor, coolant temperature sensor replacement, full oil pan replacement for minor seepage, and other warning lights—and quoted approximately $1,900 in customer-paid repairs, claiming they are unrelated to the recall or warranty despite the symptoms aligning precisely with the recall's description of bearing-related limp mode.This created a safety risk due to sudden loss of motive power while driving, increasing the potential for a crash. As a full-time cancer researcher and PhD student who depends on this vehicle for daily lab commuting and time-sensitive experiments, the breakdown and repair dispute have caused major hardship: over a week without transportation, extensive time coordinating tows, appointments, and escalations with Nissan Consumer Affairs, and disruption to critical research.The dealer confirmed the limp mode and warnings, and inspected the vehicle under the recall procedure. Warning lamps/messages appeared suddenly prior to towing; no unusual noises noted earlier. The affected components (engine controls/sensors potentially stressed by the bearing defect) remain at the dealer for inspection.The recall should provide free ECM reprogramming, oil change, and gasket replacement even without debris, yet the dealer is charging for diagnostics and repairs from the same defect.
NHTSA ODI #11705183
Official recalls
6Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Oct 13, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Titan, Titan XD, Frontier, and 2021-2022 Rogue vehicles. The in-vehicle infotainment (IVI) system may continuously reboot when the vehicle is restarted, which can result in an inoperative rearview display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The IVI software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed November 18, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's numbers for this recall are R22B8, R22C1, and PC923/25.
Sep 1, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue vehicles. The rear seat belts for the left-hand and right-hand rear seats may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 209, "Seatbelt Assemblies."
Consequence & remedy
Consequence: Seat belts that do not retract properly may be difficult to operate, preventing their usage, which can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear seat belts, as necessary, free of charge. Owner notification letters are expected to be mailed October 27, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC915.
Aug 31, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. The fuel tank may have been punctured when vehicle modifications were performed.
Consequence & remedy
Consequence: A hole in the fuel tank could leak, increasing the risk of fire.
Remedy: Dealers will inspect and replace the fuel tank as necessary, free of charge. Owner notification letters are expected to be mailed September 23, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC912.
Jul 21, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Back Over Prevention: Sensing System: Camera
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Apr 14, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Rogue vehicles. Due to a manufacturing error, an area on the bottom wall of the fuel tank may be too thin.
Consequence & remedy
Consequence: Road debris may puncture the thin fuel tank wall, causing a gas leak and increasing the risk of a fire. In addition, the fuel tank may not perform as expected during a crash, increasing the risk of injury.
Remedy: Dealers will replace the fuel tank assembly and install a new lock ring, gasket, and o-ring seal, free of charge. Owner notification letters were mailed May 19, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration