NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
445 reportsMileage unknown · Dec 12, 2018
Structure
I AM WRITING DUE TO THE FACT I TOOK MY 2004 NISSAN QUEST INTO THE SHOP TODAY BECAUSE OF A LOOSE STEERING WHEEL AND A HORRIBLE CLUNKING NOISE COMING FROM THE FRONT RIGHT SIDE. MY VAN ONLY HAS 97,000 MILES ON IT AND HAS BEEN TAKEN CARE OF VERY WELL. THE MECHANIC TOLD ME THE THE SUBFRAME IS BASICALLY ROTTING AWAY AND IS THE WORST…
Read full complaint
I AM WRITING DUE TO THE FACT I TOOK MY 2004 NISSAN QUEST INTO THE SHOP TODAY BECAUSE OF A LOOSE STEERING WHEEL AND A HORRIBLE CLUNKING NOISE COMING FROM THE FRONT RIGHT SIDE. MY VAN ONLY HAS 97,000 MILES ON IT AND HAS BEEN TAKEN CARE OF VERY WELL. THE MECHANIC TOLD ME THE THE SUBFRAME IS BASICALLY ROTTING AWAY AND IS THE WORST HE HAS SEEN IN 50 YEARS OF WORK. I'VE READ NUMEROUS ACCOUNTS ONLINE OF OTHER WHO HAVE HAD THIS SAME ISSUE. I FEEL LIKE NISSAN SHOULD HELP COVER THE COST OF MY REPAIRS DUE TO POOR MANUFACTURING AND POOR QUALITY OF PARTS. I AM VERY UNHAPPY AND WILL BE SHARING MY STORY WITH WHOEVER I CAN SHARE IT WITH. I WILL INCLUDE A LINK WITH A SITE WITH MANY COMPLAINTS FROM OTHER OWNERS OF THIS SAME VEHICLE. PLEASE HELP ME OUT. THIS IS A BIG ISSUE BECAUSE MY WIFE AND THREE CHILDREN RIDE IN THIS VEHICLE DAILY. HTTPS://WWW.CARCOMPLAINTS.COM/NISSAN/QUEST/2004/BODY_PAINT/ROTTING_SUBFRAME.SHTML
NHTSA ODI #11160935
Mileage unknown · Oct 1, 2018
Structure
THERE WAS NOISE COMING OUT FROM THE FRONT PASSENGER SIDE OF THE VEHICLE AND UPON APPLYING BRAKES THE STEERING WHEEL WAS GETTING PULLED FORCEFULLY TO THE RIGHT. THINKING THAT THERE COULD BE SOME PROBLEM WITH THE STRUTS, I TOOK IT TO THE REPAIR SHOP. THE REPAIR SHOP NOTICED THAT THE PASSENGER SIDE OF THE SUB-FRAME (FRAME OR ENGINE…
Read full complaint
THERE WAS NOISE COMING OUT FROM THE FRONT PASSENGER SIDE OF THE VEHICLE AND UPON APPLYING BRAKES THE STEERING WHEEL WAS GETTING PULLED FORCEFULLY TO THE RIGHT. THINKING THAT THERE COULD BE SOME PROBLEM WITH THE STRUTS, I TOOK IT TO THE REPAIR SHOP. THE REPAIR SHOP NOTICED THAT THE PASSENGER SIDE OF THE SUB-FRAME (FRAME OR ENGINE CRADLE) UNDER THE ENGINE COMPARTMENT WAS COMPLETELY RUSTED AND ALMOST COMPLETELY GIVING AWAY. A HIGH-SPEED BUMP OR A SUDDEN BRAKING MAY HAVE CAUSED IT TO GIVE AWAY COMPLETELY AND COULD HAVE CAUSED THE VEHICLE TO GO COMPLETELY OUT OF CONTROL. THE CAR IS OLD BUT THAT OLD FOR THE FRAME TO GIVE AWAY. THIS IS A COSTLY REPAIR BUT MORE THAN THAT IT IS A SAFETY CRITICAL ISSUE THAT MAY LEAD TO A BAD ACCIDENT. THE ONLY REASON THIS MAY BE NOTICED BEFORE SOMETHING DREADFUL HAPPENED IS ONLY BY CHANCE. THE DRIVERS MIGHT BE NOTICING OTHER ISSUES THAT PROMPTS THEM TO TAKE IT TO THE SHOP WHILE THE OTHER SIDES OF THE FRAME ARE HOLDING UP THE VEHICLE FOR SOME TIME. SOME FURTHER RESEARCH SHOWED THAT THIS SAME ISSUE HAS BEEN REPORTED BY QUITE A FEW CONSUMERS (FRAME RUSTED/BREAKING ON THE PASSENGER SIDE), BUT NO ACTION HAS BEEN TAKEN THUS FAR. I HAVE NOTICED THAT THERE ARE NUMEROUS COMPLAINTS AND I-TEAM NEWS REPORTS ABOUT SIMILAR ISSUES, BUT NO ACTION HAS BEEN TAKEN. REMEMBER THAT THERE ARE OTHERS WHO QUIETLY GET THEIR CARS REPAIRED BUT NOT LODGE A COMPLAINT. GIVEN MY PREVIOUS EXPERIENCE WITH NISSAN ON A DIFFERENT ISSUE WITH THE SAME VEHICLE (CAM SENSOR FAILURE CAUSING THE VEHICLE TO TURN OFF COMPLETELY (WHILE DRIVING) THAT COMPLETELY JAMS THE STEERING WHEEL AND BRAKE FAILURE. THE VEHICLE COULD ONLY BE BROUGHT TO STOP BY APPLYING PARKING BRAKE). I DON'T TRUST NISSAN TO TAKE ANY ACTION UNLESS THEY ARE FORCED TO.
NHTSA ODI #11132678
Mileage unknown · Jul 13, 2018
Electrical SystemExterior LightingUnknown Or Other
TAKATA RECALL THE SPEEDOMETER GOES IN AND OUT ALL THE LIGHTS IN THE VAN IS NOT WORKING AND LIGHT BLINK ON AND OFF AND THE OVERDRIVE STAYS ON ALL THE TIME
NHTSA ODI #11111125
86,000 miles · Jun 28, 2018
EngineSeats
ENGINE WOULD SUDDENLY CUT OFF WHILE IN MOTION AT 25-35 MILES PER HOUR. TWO REPAIRS WERE NECESSARY AT A COST OF APPROXIMATELY $500 TO GET THE PROBLEM REPAIRED. THE PROBLEM WAS THAT BOTH THE FRONT AND REAR CRANK SHAFT SENSORS HAD TO BE REPLACED. AS FOR THE SEAT PROBLEM, ONE OF THE RELEASE LEVERS BROKE OFF COMPLETELY. I HAVE N…
Read full complaint
ENGINE WOULD SUDDENLY CUT OFF WHILE IN MOTION AT 25-35 MILES PER HOUR. TWO REPAIRS WERE NECESSARY AT A COST OF APPROXIMATELY $500 TO GET THE PROBLEM REPAIRED. THE PROBLEM WAS THAT BOTH THE FRONT AND REAR CRANK SHAFT SENSORS HAD TO BE REPLACED. AS FOR THE SEAT PROBLEM, ONE OF THE RELEASE LEVERS BROKE OFF COMPLETELY. I HAVE NOT YET HAD IT REPAIRED SO I DO NOT HAVE A COST FOR THIS REPAIR. I HAVE TO USE PLIERS TO RELEASE THE LEVER.
NHTSA ODI #11104526
181,000 miles · Apr 2, 2018
Power TrainSteeringVehicle Speed Control
WHILE DRIVING ON THE INTERSTATE WITH 2 INFANTS IN CARS SEATS AS WELL AS 3 OTHER ADULTS THE VEHICLE LOST POWER. IT WOULD NOT ACCELERATE. WITHIN MINUTES THE STEERING WAS STIFF AND WAS EXTREMELY DIFFICULT TO TURN. PULLED OFF THE INTERSTATE AND ONTO A SIDE ROAD. THE VEHICLE FINALLT DECELLERATED TO A FULL STOP. TURNED IT OFF AND…
Read full complaint
WHILE DRIVING ON THE INTERSTATE WITH 2 INFANTS IN CARS SEATS AS WELL AS 3 OTHER ADULTS THE VEHICLE LOST POWER. IT WOULD NOT ACCELERATE. WITHIN MINUTES THE STEERING WAS STIFF AND WAS EXTREMELY DIFFICULT TO TURN. PULLED OFF THE INTERSTATE AND ONTO A SIDE ROAD. THE VEHICLE FINALLT DECELLERATED TO A FULL STOP. TURNED IT OFF AND RESTARTED A FEW MOMENTS LATER. VEHICLE RAN AGAIN BUT NO STEERING. POPPED THE HOOD AND LOOKED AND NO POWER STEERING FLUID IN THE WELL. ADDED FLUID AND STEERED OK TILL 4 BLOCKS FROM MY HOUSE AT WHICH TIME THE STEERING ACTING UP AGAIN AND NOT ACCELERATING NO MATTER HOW FAR YOU PUSH THE PEDAL. TURNED IT OFF AND RESTARTED AGAIN. STEERING NOT WORKING BUT ACCELERATED ENOUGH TO PARK IT AT HOME. TOOK TO MY MECHANIC BUT SAYS HE CANNOT LOOK AT IT UNTIL WEDNESDAY. WAS SO SCARED CAUSE HAD THE GRANDBABIES IN THE VAN.
NHTSA ODI #11082566
90,000 miles · Mar 14, 2018
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
THE SPEDOMETER AND THE LIGHTS FOR IT DON'T WORK GOT PULLED OVER AND TOLD I HAD A FAKE INSPECTION BECAUSE OF THEM NOT WORKING CAN'T GET AN EXACT READING ON MY MILEAGE,FUEL OR IF THE VANS OVER HEATING I CAN'T TELL HOW FAST OR SLOW I'M GOING
NHTSA ODI #11079063
10,000 miles · Jan 23, 2018
Structure
TAMARA INFLATORS, SENT MY VAN TO MY LOCAL NISSAN DEALER FOR BRAKE REPAIRMEN. I WAS TOLD SINCE THE FRONT SUBFRAME AT PASSENGER SIDE HAD SEVERE RUST AREA, MY VAN IS NOT SAFE TO DRIVE. IT WILL COST ME MORE THAN $4,000 TO REPLACE. I CHECKED INTERNET. THERE ARE MANY SAME PROBLEMS OCCURRED ON 2004 QUEST. IT LOOKS LIKE THE DEFECT OF MA…
Read full complaint
TAMARA INFLATORS, SENT MY VAN TO MY LOCAL NISSAN DEALER FOR BRAKE REPAIRMEN. I WAS TOLD SINCE THE FRONT SUBFRAME AT PASSENGER SIDE HAD SEVERE RUST AREA, MY VAN IS NOT SAFE TO DRIVE. IT WILL COST ME MORE THAN $4,000 TO REPLACE. I CHECKED INTERNET. THERE ARE MANY SAME PROBLEMS OCCURRED ON 2004 QUEST. IT LOOKS LIKE THE DEFECT OF MATERIALS TO ME.
NHTSA ODI #11064470
100,500 miles · Jan 10, 2018
Air Bags
ALL SIDE AIR BAGS HAVE ACTIVATED WITHOUT ANY ACCIDENT OR COLLISION. THE REARWARD BAGS ACTIVATED AT 5 MPH THE FORWARD SIDE AIRBAGS ACTIVATED WHILE THE VEHICLE WAS NOT MOVING.
NHTSA ODI #11061990
Mileage unknown · Dec 11, 2017
Air BagsVehicle Speed Control
PASSENGER AIR BAG LS OFF, LIGHT FLASHING SPEEDOMETER STARTS AT 30MILES
NHTSA ODI #11053894
160,000 miles · Sep 28, 2017
Fuel/propulsion SystemUnknown Or Other
ON DIFFERENT OCCASIONS, WHEN ATTEMPTING TO DRIVE FROM 0MPH, THE VEHICLE WILL NOT ACCELERATE. I HAVE TO TURN IT OFF THEN TURN IT BACK ON THEN USUALLY IT WILL WORK. ALSO SOMETIMES IT WON'T START IT TURNS OVER STRONG BUT WILL NOT CRANK. I'LL WAIT SEVERAL MINUTES OR SO THEN ATTEMPTED AGAIN THEN IT WILL CRANK AND DRIVE NORMAL.
NHTSA ODI #11030410
Official recalls
4Oct 17, 2005
ON CERTAIN MINI VANS EQUIPPED WITH A FOLDING THIRD ROW REAR SEAT, WHEN THE THIRD ROW SEAT IS RAISED FROM ITS STOWED POSITION, IT ENGAGES STRIKER BRACKETS, ONE ON EACH SIDE OF THE SEAT CUSHION. THE FOLD-AWAY STRIKER LOOP IS WELDED TO A MOUNTING BRACKET. THE STRIKER MAY BECOME DETACHED FROM ITS MOUNTING BRACKET DUE TO A BROKEN WELD AT THE POINT OF ATTACHMENT TO THE BRACKET.
Consequence & remedy
Consequence: IF THE THIRD ROW SEAT STRIKER WELD FAILS, THE STRIKER COULD SEPARATE FROM THE MOUNTING BRACKET. STRIKER SEPARATION COULD AFFECT THE RISK OF INJURY IN CERTAIN TYPES OF CRASHES.
Remedy: DEALERS WILL REPLACE THE THIRD ROW SEAT STRIKER BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Oct 13, 2005
ON CERTAIN MINI VANS, THERE IS A SEAT ADJUSTMENT MECHANISM THAT CONTAINS EXPOSED MOVING COMPONENTS LOCATED AT THE REAR INSIDE EDGE OF THE SECOND ROW SEAT.
Consequence & remedy
Consequence: WHEN THE OPERATOR ATTEMPTS SEAT ADJUSTMENT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM WHICH COULD CAUSE AN INJURY.
Remedy: ON EARLIER MODEL VEHICLES BUILT THROUGH JUNE 28, 2004, DEALERS WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE, RIVET A PLASTIC REINFORCEMENT TO BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE TO THE INBOARD SIDE SHIELD. ON VEHICLES PRODUCED FROM JUNE 29, 2004 THROUGH SEPTEMBER 26, 2005, DEALERS WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE ON THE INBOARD SIDE SHIELD. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Apr 16, 2004
ON CERTAIN MINIVANS EQUIPPED WITH A POWER SLIDING DOOR(S), AT AN AMBIENT TEMPERATURE BELOW APPROXIMATELY 40 DEGREES FAHRENHEIT, THE ACTUATOR FOR THE POWER SLIDING DOOR(S) MAY EXPERIENCE BINDING DUE TO AN OUT-OF-SPECIFICATION CONDITION. IN ORDER TO OPEN, CLOSE OR REVERSE A POWER SLIDING DOOR, THE SHIFT SELECTOR LEVER MUST BE IN "PARK." IF THE ACTUATOR IS EXPERIENCING BINDING AND THE DRIVER SHIFTS THE VEHICLE OUT OF "PARK" WHILE A POWER SLIDING DOOR IS STILL CLOSING, THE DOOR LATCHES MAY NOT ENGAGE.
Consequence & remedy
Consequence: THIS CAN RESULT IN THE DOOR COMING OPEN UNEXPECTEDLY UPON RAPID ACCELERATION, AND AN OCCUPANT COULD FALL OUT OF THE DOOR AND BE INJURED.
Remedy: DEALERS WILL REPLACE THE ACTUATOR FOR THE POWER SLIDING DOOR(S). OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Mar 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE ADVANCED AIR BAG REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG FOR THE FRONT PASSENGER SEAT IS TO BE TURNED OFF (SO THAT IT DOES NOT INFLATE) WHEN CERTAIN OCCUPANTS, SUCH AS SMALL CHILDREN, ARE IN THE FRONT SEAT.
Consequence & remedy
Consequence: THIS REDUCES THE RISK OF SUCH OCCUPANTS BEING UNJURED BY AN INFLATING AIR BAG IN A COLLISION.
Remedy: DEALERS WILL INSPECT THE FRONT PASSENGER SEAT CUSHION/SENSOR ASSEMBLY. IF THE SEAT CUSHION/SENSOR IS FOUND TO BE OPERATING IMPROPERLY, THE SEAT WILL BE REMOVED AND RECALIBRATED. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
EA05012 · Finger Pinch Point
Opened Aug 19, 2005 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
THE SEAT ADJUSTMENT MECHANISM CONTAINS EXPOSED MOVING COMPONENTS, LOCATED AT THE REAR EDGE OF THE SECOND ROW SEAT.WHEN THE OPERATOR ATTEMPTS TO ADJUST THE SEAT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM.NISSAN WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF NISSAN QUEST VEHICLES.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005, NISSAN WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL THREE TIE-DOWNS AND INSTALL A FLANGE TO THE INBOARD SIDE SHIELD.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH JUNE 28, 2004, IN ADDITION TO THE ABOVE CORRECTIVE ACTIONS, NISSAN WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE WITH THE CURRENT PRODUCTION SEAT LEVER. NISSAN NORTH AMERICA, INC. WILL RECALL 109,437 MY 2004-2005 NISSAN QUEST VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005.ODI IS AWARE OF A TOTAL OF 11 COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS REPORTING 11 FINGER INJURIES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V474.
PE05019 · Finger Pinch Point
Opened Apr 21, 2005 · Closed Aug 19, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
ODI HAS RECEIVED FIVE REPORTS ALLEGING THAT THE CONSUMER WAS INJURED USING THE VEHICLE'S SECOND-ROW SEAT RELEASE LEVER TO FOLD THE SECOND ROW SEAT.NISSAN STATES, ...THE CUSTOMER OPERATION OF THE LEVER IN SOME CASES AND SUBSEQUENT ORIENTATION OF THEIR FINGERS IS DIFFERENT THAN EXPECTED.NISSAN ALSO REPORTED ADDITIONAL COMPLAINTS FOR A TOTAL OF 11 INJURIES.NISSAN MODIFIED THE LEVER FOR PRODUCTION TWICE.THE LATEST (SECOND MODIFICATION) DESIGN PROVIDES A LARGER SIZED HANDLE THAT CONTAINS A CUP INTO WHICH THE SEAT OCCUPANT CAN PLACE THEIR FINGERS TO OPERATE THE ADJUSTMENT LEVER.NISSAN REPORTS NO INJURIES ASSOCIATED WITH THE CUP DESIGN LEVER.BEGINNING JUNE 2004, NISSAN INITIATED A CUSTOMER SATISFACTION INITIATIVE THAT INCLUDED REPLACING THE ORIGINAL DESIGN HANDLE WITH THE FIRST MODIFICATION HANDLE (THIS IS NOT THE CUP DESIGN HANDLE MENTIONED ABOVE).THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-012) TO ALLOW FURTHER ANALYSIS OF THE ISSUE.
PE04027 · POWER-SLIDING Door Opening
Opened Mar 15, 2004 · Closed Jun 2, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Illustration