IllustrationQUEST WILL JERK EXTREMELY HARD AFTER SLOWING DOWN OR LETTING OF ON THE GAS AND THEN RETURNING TO NORMAL SPEED. *TR
2004 Nissan Quest
Owner reports · Recalls · Investigations
More warning signs than most Quest years
Owner complaints for the 2004 Nissan Quest are substantially higher than the model-year median of 66.
About this comparison →How this year compares
Owner complaints by model year
Compare all Quest years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1420–25K
3125–50K
4150–75K
3775–100K
55100–150K
15150K+
321 reports with mileage · 124 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports10 fire reports30 injury reports
Engine And Engine Cooling complaints
48 reports2004 NISSAN QUEST. CONSUMER WRITES IN REGARDS TO A FAULTY DESIGN/ INSTALLATION OF ENGINE CONTROL MODULE. *SMD THE CONSUMER STATED THE ECM WAS INSTALLED DIRECTLY UNDER THE WINDSHIELD PLASTIC COWL. THE OPEN MESH COWL WOULD DRAIN ALL THE WATER DIRECTLY ONTO THE ECM. IT WAS HOW WATER DRIPPED ON THE ECM'S ENCLOSURE, THAT CAUSED TH…
Read full complaint
2004 NISSAN QUEST. CONSUMER WRITES IN REGARDS TO A FAULTY DESIGN/ INSTALLATION OF ENGINE CONTROL MODULE. *SMD THE CONSUMER STATED THE ECM WAS INSTALLED DIRECTLY UNDER THE WINDSHIELD PLASTIC COWL. THE OPEN MESH COWL WOULD DRAIN ALL THE WATER DIRECTLY ONTO THE ECM. IT WAS HOW WATER DRIPPED ON THE ECM'S ENCLOSURE, THAT CAUSED THE CORROSION PREMATURELY. THE REPAIRMAN EVEN DECIDED NOT TO INSTALL THE REPLACEMENT IN ITS ORIGINAL BRACKET TO AVOID ACCUMULATING MOISTURE.
WE WERE GOING OVER LOVELAND PASS IN COLORADO. AS SOON AS WE STARTED GOING BACK DOWN THE ENGINE FAILED. I HAD TO DRIFT WITH NO POWER TO A SHOULDER TO PULL OFF ON. MY TWO KIDS WERE IN THE CAR AND WERE SCARED ABOUT ME HAVING NO POWER. HAD TO WAIT AN HOUR TO TOW IT. THE GARAGE SAID THE TIMING BELT BROKE, $1900 TO FIX....... *TR
TIMING CHAIN TENSIONER BROKE CAUSING TIMING CHAIN TO RATTLE LOUDLY. NISSAN SAID THE REPAIR WOULD BE ABOUT $2,400.00. APPARENTLY THIS IS A VERY COMMON PROBLEM WITH THE NISSAN 3.5 ENGINE AND SHOULD BE SUBJECT TO A RECALL. *JS
I OWN A 2004 NISSAN QUEST. I RECENTLY HAD TO REPLACE THE TIMING CHAIN AT A COST OF $1500.00. I AM QUITE ANGRY ABOUT THIS SINCE I HAVE RECENTLY FOUND OUT THAT MANY OTHER OWNERS ARE ALSO EXPERIENCING THE SAME PROBLEM WITH THE QUEST. THIS IS AN ISSUE NISSAN SHOULD HAVE RECALLED THE CAR FOR. I WAS TOLD HAT IF THIS CHAIN HAD BROKEN…
Read full complaint
I OWN A 2004 NISSAN QUEST. I RECENTLY HAD TO REPLACE THE TIMING CHAIN AT A COST OF $1500.00. I AM QUITE ANGRY ABOUT THIS SINCE I HAVE RECENTLY FOUND OUT THAT MANY OTHER OWNERS ARE ALSO EXPERIENCING THE SAME PROBLEM WITH THE QUEST. THIS IS AN ISSUE NISSAN SHOULD HAVE RECALLED THE CAR FOR. I WAS TOLD HAT IF THIS CHAIN HAD BROKEN WHILE I WAS DRIVNG, IT COULD CAUSE TEH THE ENGINE TRO SEIZE. WELL THAT IS JUST GREAT TO KNOW THAT I HAND MY DAUGHTER THE KEYS TO THIS CAR AND THEY COULD HAVE BEEN KILLED. IS THAT WHAT YOU ARE WAITING FOR..SOMEONE TO DIE BEFORE YOU REALIZE HOW BIG A PROBLEM THIS IS? I HAVE ALSO READ THAT OTHER MAKES OF NISSAN ARE ALSO EXPERIENCING THIS PROBLEM. NISSSAN SHOULD BE HELD RESPONSIBLE FOR THIS REPAIR. I HAVE ALWAYS PURCHASED NISSAN, BUT WITH THESE KIND OF COSTLY REPAIRS AND DANGEROUS ISSUE AT HAND, I WILL DEFINATELY CHOOSE ANOTHER MAKER IF NISSAN DOES NOT COME FORWARD WITH A RECALL AND REINBURSE THOSE OF US THAT HAVE ALREADY HAD PAY FOR THESE COSTLY REPAIRS. I AM VERY DISAPOINTED WITH NISSAN, SINCE I AM SURE THEY ARE AWARE OF THIS PROBLEM AND HAVE DONE NOTHING ABOUT IT. *TR
THERE IS A LOUD, ANNOYING AND DANGEROUS RATTLING SOUND COMING FROM THE MOTOR. BASED ON WHAT SEEMS LIKE HUNDREDS OF THOUSANDS OF COMPLAINTS AND MANY OPINIONS FROM VERY EXPERIENCED MECHANICS, IT IS THE TIMING CHAIN - THE WHOLE THING- FROM THE CHAIN, TENSIONERS AND EVERYTHING ASSOCIATED WITH THE ENTIRE TIMING CHAIN MECHANISM. THI…
Read full complaint
THERE IS A LOUD, ANNOYING AND DANGEROUS RATTLING SOUND COMING FROM THE MOTOR. BASED ON WHAT SEEMS LIKE HUNDREDS OF THOUSANDS OF COMPLAINTS AND MANY OPINIONS FROM VERY EXPERIENCED MECHANICS, IT IS THE TIMING CHAIN - THE WHOLE THING- FROM THE CHAIN, TENSIONERS AND EVERYTHING ASSOCIATED WITH THE ENTIRE TIMING CHAIN MECHANISM. THIS IS ABSURDLY ANNOYING, EXTREMELY DANGEROUS AND OUTRAGEOUSLY LABOR INTENSIVE AND EXPENSIVE TO FIX. I, LIKE SO MANY OTHERS OUT THERE, PUT MY FAMILY IN THIS VEHICLE ON A DAILY BASIS AND HAVE TO WONDER JUST HOW SAFE THIS THING IS. WHAT HAPPENS IF THE CHAIN BREAKS? WHAT HAPPENS IF IT BREAKS WHILE ON A MAJOR HIGHWAY? I JUST HAD MY FAMILY TO FLORIDA THIS SUMMER - CAN'T IMAGINE THAT SCENARIO. OBVIOUSLY, THIS PROBLEM EXISTS ABSOLUTELY EVERYWHERE WITH THIS VEHICLE. *TR
MY CAR ENGINE HAS BEEN MAKING A CLICKING NOISE FOR THE PAST 10,000 MILES AND SEEMS TO BE GETTING WORSE. ON TAKING IT INTO THE DEALER AT APPROX 95,000 MILES, THEY TOLD ME I NEEDED TO HAVE THE TIMING CHAIN REPLACED WITH OTHER INCIDENTALS FOR A COST OF APPROX $3200., $2300 ALONE FOR THE TIMING BELT ASPECT. I DID NOT FOLLOW THR…
Read full complaint
MY CAR ENGINE HAS BEEN MAKING A CLICKING NOISE FOR THE PAST 10,000 MILES AND SEEMS TO BE GETTING WORSE. ON TAKING IT INTO THE DEALER AT APPROX 95,000 MILES, THEY TOLD ME I NEEDED TO HAVE THE TIMING CHAIN REPLACED WITH OTHER INCIDENTALS FOR A COST OF APPROX $3200., $2300 ALONE FOR THE TIMING BELT ASPECT. I DID NOT FOLLOW THROUGH WITH THE TIMING CHAIN REPAIR BUT ONLY THE REPAIR OF THE HIGH SPEED STEERING HOSE. I HAVE BEEN REVIEWING THE TIMING CHAIN REPORTS AND IT DEFINITELY SEEM THAT NISSAN HAS A PROBLEM WITH FAILING TIMING CHAINS AND IT DOES SEEM LIKE A MANUFACTURING DEFECT AND AS SUCH SHOULD BE RECALLED. I STRONGLY RECOMMEND THAT NHTSA START AN INVESTIGATION INTO RECALLING ALL THE NISSAN TIMING CHAIN VEHICLES. *TT
LOUD RATTLING IN MY ENGINE WHEN I START MY VAN AND WHEN I DRIVE THROUGH TOWN. VERY EMBARRASSING! MECHANIC THINKS IT IS THE TIMING CHAIN TENSIONERS IN THE ENGINE THAT IS GOING TO COST OVER $3,500. I ONLY HAVE 94,000 MILES ON THE VAN SO IT SHOULD NOT BE DOING THIS! *TR
THERE IS AN AWFUL TICKING SOUND COMING FROM THE ENGINE. MY CAR HAS BEEN SERVICED MY NISSAN REPEATEDLY AND IT'S STILL MAKING THE NOISES. NOW I'VE BEEN TOLD IT'S THE TIMING CHAIN. AFTER READING UP ON THIS ISSUE IT'S APPARENT THAT THERE A WIDESPREAD PROBLEM WITH THIS PART IN THE NISSAN QUESTS. *TR
AT A REGULAR DEALER VISIT FOR AN OIL CHANGE, I WAS TOLD THAT I HAVE A BROKEN TIMING CHAIN GUIDE ON MY 04 NISSAN QUEST. THE COST OF THIS REPAIR IS APPROXIMATELY $1800. UPON DOING SOME RESEARCH, I DISCOVERED THAT THIS IS A FAIRLY COMMON ISSUE WITH 04 QUESTS AND IT APPEARS TO HAPPEN BETWEEN 60 -90,000 MILES (MINE IS JUST OVER 80,…
Read full complaint
AT A REGULAR DEALER VISIT FOR AN OIL CHANGE, I WAS TOLD THAT I HAVE A BROKEN TIMING CHAIN GUIDE ON MY 04 NISSAN QUEST. THE COST OF THIS REPAIR IS APPROXIMATELY $1800. UPON DOING SOME RESEARCH, I DISCOVERED THAT THIS IS A FAIRLY COMMON ISSUE WITH 04 QUESTS AND IT APPEARS TO HAPPEN BETWEEN 60 -90,000 MILES (MINE IS JUST OVER 80,000). LINK IS ATTACHED: HTTP://QUESTDRIVER.COM/NODE/835. *TR
Official recalls
405V480000 · Seats:mid/rear Assembly
Oct 17, 2005
ON CERTAIN MINI VANS EQUIPPED WITH A FOLDING THIRD ROW REAR SEAT, WHEN THE THIRD ROW SEAT IS RAISED FROM ITS STOWED POSITION, IT ENGAGES STRIKER BRACKETS, ONE ON EACH SIDE OF THE SEAT CUSHION. THE FOLD-AWAY STRIKER LOOP IS WELDED TO A MOUNTING BRACKET. THE STRIKER MAY BECOME DETACHED FROM ITS MOUNTING BRACKET DUE TO A BROKEN WELD AT THE POINT OF ATTACHMENT TO THE BRACKET.
Consequence & remedy
Consequence: IF THE THIRD ROW SEAT STRIKER WELD FAILS, THE STRIKER COULD SEPARATE FROM THE MOUNTING BRACKET. STRIKER SEPARATION COULD AFFECT THE RISK OF INJURY IN CERTAIN TYPES OF CRASHES.
Remedy: DEALERS WILL REPLACE THE THIRD ROW SEAT STRIKER BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
05V474000 · Seats:mid/rear Assembly
Oct 13, 2005
ON CERTAIN MINI VANS, THERE IS A SEAT ADJUSTMENT MECHANISM THAT CONTAINS EXPOSED MOVING COMPONENTS LOCATED AT THE REAR INSIDE EDGE OF THE SECOND ROW SEAT.
Consequence & remedy
Consequence: WHEN THE OPERATOR ATTEMPTS SEAT ADJUSTMENT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM WHICH COULD CAUSE AN INJURY.
Remedy: ON EARLIER MODEL VEHICLES BUILT THROUGH JUNE 28, 2004, DEALERS WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE, RIVET A PLASTIC REINFORCEMENT TO BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE TO THE INBOARD SIDE SHIELD. ON VEHICLES PRODUCED FROM JUNE 29, 2004 THROUGH SEPTEMBER 26, 2005, DEALERS WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE ON THE INBOARD SIDE SHIELD. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
04V186000 · Latches/locks/linkages:doors:latch
Apr 16, 2004
ON CERTAIN MINIVANS EQUIPPED WITH A POWER SLIDING DOOR(S), AT AN AMBIENT TEMPERATURE BELOW APPROXIMATELY 40 DEGREES FAHRENHEIT, THE ACTUATOR FOR THE POWER SLIDING DOOR(S) MAY EXPERIENCE BINDING DUE TO AN OUT-OF-SPECIFICATION CONDITION. IN ORDER TO OPEN, CLOSE OR REVERSE A POWER SLIDING DOOR, THE SHIFT SELECTOR LEVER MUST BE IN "PARK." IF THE ACTUATOR IS EXPERIENCING BINDING AND THE DRIVER SHIFTS THE VEHICLE OUT OF "PARK" WHILE A POWER SLIDING DOOR IS STILL CLOSING, THE DOOR LATCHES MAY NOT ENGAGE.
Consequence & remedy
Consequence: THIS CAN RESULT IN THE DOOR COMING OPEN UNEXPECTEDLY UPON RAPID ACCELERATION, AND AN OCCUPANT COULD FALL OUT OF THE DOOR AND BE INJURED.
Remedy: DEALERS WILL REPLACE THE ACTUATOR FOR THE POWER SLIDING DOOR(S). OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
04V103000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Mar 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE ADVANCED AIR BAG REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG FOR THE FRONT PASSENGER SEAT IS TO BE TURNED OFF (SO THAT IT DOES NOT INFLATE) WHEN CERTAIN OCCUPANTS, SUCH AS SMALL CHILDREN, ARE IN THE FRONT SEAT.
Consequence & remedy
Consequence: THIS REDUCES THE RISK OF SUCH OCCUPANTS BEING UNJURED BY AN INFLATING AIR BAG IN A COLLISION.
Remedy: DEALERS WILL INSPECT THE FRONT PASSENGER SEAT CUSHION/SENSOR ASSEMBLY. IF THE SEAT CUSHION/SENSOR IS FOUND TO BE OPERATING IMPROPERLY, THE SEAT WILL BE REMOVED AND RECALIBRATED. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
EA05012 · Finger Pinch Point
Opened Aug 19, 2005 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
THE SEAT ADJUSTMENT MECHANISM CONTAINS EXPOSED MOVING COMPONENTS, LOCATED AT THE REAR EDGE OF THE SECOND ROW SEAT.WHEN THE OPERATOR ATTEMPTS TO ADJUST THE SEAT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM.NISSAN WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF NISSAN QUEST VEHICLES.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005, NISSAN WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL THREE TIE-DOWNS AND INSTALL A FLANGE TO THE INBOARD SIDE SHIELD.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH JUNE 28, 2004, IN ADDITION TO THE ABOVE CORRECTIVE ACTIONS, NISSAN WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE WITH THE CURRENT PRODUCTION SEAT LEVER. NISSAN NORTH AMERICA, INC. WILL RECALL 109,437 MY 2004-2005 NISSAN QUEST VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005.ODI IS AWARE OF A TOTAL OF 11 COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS REPORTING 11 FINGER INJURIES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V474.
PE05019 · Finger Pinch Point
Opened Apr 21, 2005 · Closed Aug 19, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
ODI HAS RECEIVED FIVE REPORTS ALLEGING THAT THE CONSUMER WAS INJURED USING THE VEHICLE'S SECOND-ROW SEAT RELEASE LEVER TO FOLD THE SECOND ROW SEAT.NISSAN STATES, ...THE CUSTOMER OPERATION OF THE LEVER IN SOME CASES AND SUBSEQUENT ORIENTATION OF THEIR FINGERS IS DIFFERENT THAN EXPECTED.NISSAN ALSO REPORTED ADDITIONAL COMPLAINTS FOR A TOTAL OF 11 INJURIES.NISSAN MODIFIED THE LEVER FOR PRODUCTION TWICE.THE LATEST (SECOND MODIFICATION) DESIGN PROVIDES A LARGER SIZED HANDLE THAT CONTAINS A CUP INTO WHICH THE SEAT OCCUPANT CAN PLACE THEIR FINGERS TO OPERATE THE ADJUSTMENT LEVER.NISSAN REPORTS NO INJURIES ASSOCIATED WITH THE CUP DESIGN LEVER.BEGINNING JUNE 2004, NISSAN INITIATED A CUSTOMER SATISFACTION INITIATIVE THAT INCLUDED REPLACING THE ORIGINAL DESIGN HANDLE WITH THE FIRST MODIFICATION HANDLE (THIS IS NOT THE CUP DESIGN HANDLE MENTIONED ABOVE).THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-012) TO ALLOW FURTHER ANALYSIS OF THE ISSUE.
PE04027 · POWER-SLIDING Door Opening
Opened Mar 15, 2004 · Closed Jun 2, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.