TL* THE CONTACT OWNS A 1996 NISSAN QUEST. THE CONTACT NOTICED AN ABNORMAL FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE WHILE DRIVING. THE CONTACT WAS UNAWARE OF A FUEL LEAK UNDER THE VEHICLE OR INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE A…
Read full complaint
TL* THE CONTACT OWNS A 1996 NISSAN QUEST. THE CONTACT NOTICED AN ABNORMAL FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE WHILE DRIVING. THE CONTACT WAS UNAWARE OF A FUEL LEAK UNDER THE VEHICLE OR INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #11142545
Mileage unknown · Jun 9, 2015
Fuel/propulsion System
CAN NOT FILL UP THE VAN WHIT GASOLINE,STOP FILL IN ,LIKE IF IS FULL,AND GASOLINE GAUGE INDICATES WRONG READING
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH POWER WINDOWS THAT CAN BE CLOSED AFTER THE IGNITION KEY IS TURNED TO THE "OFF" POSITION AND THE RIGHT FRONT (PASSENGER) DOOR IS OPENED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 118, "POWER-OPERATED WINDOW SYSTEMS."
Consequence & remedy
Consequence: THERE IS THE POTENTIAL FOR UNSUPERVISED CHILDREN TO OPERATE THE POWER WINDOWS, INCREASING THE RISK OF PERSONAL INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH A LABEL REMINDING OWNERS NOT TO LEAVE CHILDREN UNATTENDED BECAUSE THE POWER WINDOWS CAN OPERATE FOR 15 MINUTES AFTER THE VEHICLE IGNITION HAS BEEN TURNED OFF UNLESS THE DRIVER'S DOOR IS OPENED. ALSO INCLUDED ARE INSTRUCTIONS DESCRIBING HOW AND WHERE THIS LABEL IS TO BE INSTALLED. IF AN OWNER PREFERS, THEIR DEALER CAN INSTALL THIS LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA00015 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Additional source detail variants (2)
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
SQ00008 · Unexpected Opening On Sliding Door
Opened May 12, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1996 Nissan Quest Problems, Complaints & Recalls | Skip That Year
Illustration