IllustrationThe timing chain has gone out. Other crankshaft sensor went out while driving the vehicle at about 30mph.
2005 Nissan Frontier
Owner reports · Recalls · Investigations
More warning signs than most Frontier years
Owner complaints for the 2005 Nissan Frontier are substantially higher than the model-year median of 64.
About this comparison →How this year compares
Owner complaints by model year
Compare all Frontier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
5225–50K
9250–75K
12975–100K
156100–150K
32150K+
479 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports8 fire reports9 injury reports
Engine complaints
80 reportsThe contact owns a 2005 Nissan Frontier. The contact stated that on several occasions while driving approximately 65 MPH, the vehicle inadvertently decelerated. The contact then stated that the check engine warning light illuminated, and the vehicle stalled. The contact was able to coast the vehicle off the roadway. The contact …
Read full complaint
The contact owns a 2005 Nissan Frontier. The contact stated that on several occasions while driving approximately 65 MPH, the vehicle inadvertently decelerated. The contact then stated that the check engine warning light illuminated, and the vehicle stalled. The contact was able to coast the vehicle off the roadway. The contact then stated that the check engine warning light intermittently flashed upon start-up then remained illuminated. The contact stated that he allowed the engine time to cool down then restarted the vehicle; however, after the vehicle was restarted, he depressed the accelerator pedal to regain speed but two to three minutes later the vehicle stalled again. The contact stated that occasionally, after the vehicle stalled, the vehicle was jumpstarted, but the negative side of the battery sparked from the cable. Additionally, the contact stated that the ABS warning light and the check engine warning illuminated then turned off then the vehicle stalled. The contact stated that he noticed that when the coolant temperature gauge was at an undisclosed temperature, the vehicle failed to restart. In addition, the contact added that upon research he related the failure to the NHTSA Campaign Number: 10V517000 (Engine and Engine Cooling). The vehicle was not diagnosed or repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 189,000.
TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE ECM NEEDED TO BE REPLACED AND PROGRAMED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE ECM NEEDED TO BE REPLACED AND PROGRAMED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE THEN WAS THEN TAKEN TO NISSAN AT THE AVENUES (10859 PHILIPS HWY, JACKSONVILLE, FL 32256) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 113,010.
FILED A COMPALINT #11288301.JJUST WANT TO BE PUT ON THE RECALL UPDATE LIST IN THE FUTURE. THANKS
WAS ON A VACATION TRIP DECEMBER 6, 2019(FRIDAY). TRAVELING ON FOLEY BEACH EXPRESS AND THE ENGINE STARTED SHACKING, FELT LIKE WAS FALLING APART, ENGINE DIED.TRIED TO RESTART ENGINE, CRANKED AND IMMEDIATELY STOPPED, TRIED SEVERAL TIMES AND AND THE SAME THING EVERY TIME. HAD TO PUSH OFF EXPRESS WAY, WITH HELP. FORTUNALLY WAS A MECH…
Read full complaint
WAS ON A VACATION TRIP DECEMBER 6, 2019(FRIDAY). TRAVELING ON FOLEY BEACH EXPRESS AND THE ENGINE STARTED SHACKING, FELT LIKE WAS FALLING APART, ENGINE DIED.TRIED TO RESTART ENGINE, CRANKED AND IMMEDIATELY STOPPED, TRIED SEVERAL TIMES AND AND THE SAME THING EVERY TIME. HAD TO PUSH OFF EXPRESS WAY, WITH HELP. FORTUNALLY WAS A MECHANIC. HE SAID SEAMED AS WAS NOT GETTING FUEL. FUTHER CHECKING MORE THE MECHANIC SAID IT WAS IN THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) OR THE (ECM) RELAY. I AM BROKE DOWN 190 MILES FROM HOME. HAD TO HAVE MY VEHICLE 90 MILES TO MOBILE,A>> AND AM STUCK. HAD TO RENT AN VEHICLE TO GET HOME COSTING ME $214.00 TO GET HOME TO GO TO WORK MONDAY. MY VEHICLE IS STUCK IN MOBILE, AL. THERE IS A NISSAN DEALERSHIP THERE. THIS VEHICLE 2005 NISSAN FRONTIER XE THE MECHANIC SAID REPORTEDLY HAD A RECALL ON THIS SIMULAR PROBLEM. WHAT IS THE PROCEDURE ON GETTING THIS DEFECT FIXED. THANKS. I HAVE NO PICTURES TO UPLOAD, AS WAS 10:30 AT NIGHT AND I AM NOW 100 MILES FROM THE VEHICLE.
I WAS DRIVING TO WORK IN THE MORNING , ABOUT 10 MILES TO WORK ON THE HIGHWAY NOT A TREE OR CAR INSIGHT , I HEARD WHAT SOUNDED LIKE A LOUD POP / I HAD NO IDEA WHAT IT WAS , NOT A TIRE OR ANYTHING I LOOK UP AND SEE MY SUNROOF SHATTERED
TRANSMISSION DAMAGE CAUSED BY TRANSMISSION COOLER.
THE DEALER TOLD ME THE TIMING CHAIN NEEDED TO BE REPLACED DUE TO A WHIRRING SOUND
TIMING CHAIN HAS TO BE REPAIRED AT LESS THAN 50,000 MILES. A CLASS ACTION SUIT AGAINST NISSAN WAS JUST COMPLETED ROLAND TELLIS BARON & BUDD ATTORNEYS FOR OWNERS OF NISSAN FRONTIERS IN THE STATES OF CALIFORNIA AND WASHINGTON WHERE OWNERS ARE TO BE REIMBURSED EXPENSE OF REPLACING FAULTY FRONTIER TIMING CHAIN THAT NISSAN MANUFACTU…
Read full complaint
TIMING CHAIN HAS TO BE REPAIRED AT LESS THAN 50,000 MILES. A CLASS ACTION SUIT AGAINST NISSAN WAS JUST COMPLETED ROLAND TELLIS BARON & BUDD ATTORNEYS FOR OWNERS OF NISSAN FRONTIERS IN THE STATES OF CALIFORNIA AND WASHINGTON WHERE OWNERS ARE TO BE REIMBURSED EXPENSE OF REPLACING FAULTY FRONTIER TIMING CHAIN THAT NISSAN MANUFACTURER ALLEGEDLY KNEW WERE IN THE TRUCKS THAT THEY HAD SOLD. IN THE SUIT IT STATES THAT IF YOU HAVE LESS THAN 120K MILES ON YOUR VEHICLE. I WAS TOLD BY THE DEALERSHIP SERVICE CENTER THAT REPLACING TIMING CHAIN AT 50K MILES IS NORMAL. I BELIEVE THEY MISPRESENTED THE TRUTH IN THIS INSTANCE AND THAT I SHOULDN'T HAVE TO PAY FOR A REPAIR THAT IS A RESULT OF MANUFACTURER ERROR. RECENTLY ENGINE STALLED IN THE INTERSECTION, I WAS LUCKY THE CHAIN HAD NOT SHATTERED AND DESTROYED MY ENGINE.
TL* THE CONTACT OWNED A 2005 NISSAN FRONTIER. WHILE THE CONTACT'S SON WAS DRIVING 35 MPH, THE VEHICLE STALLED AND CRASHED INTO A JERSEY WALL. THE DRIVER WAS TRAPPED INSIDE THE VEHICLE WHEN IT SUDDENLY BURST INTO FLAMES. AS A RESULT, THE CONTACT'S SON PASSED AWAY. A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FI…
Read full complaint
TL* THE CONTACT OWNED A 2005 NISSAN FRONTIER. WHILE THE CONTACT'S SON WAS DRIVING 35 MPH, THE VEHICLE STALLED AND CRASHED INTO A JERSEY WALL. THE DRIVER WAS TRAPPED INSIDE THE VEHICLE WHEN IT SUDDENLY BURST INTO FLAMES. AS A RESULT, THE CONTACT'S SON PASSED AWAY. A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DEEMED A TOTAL LOSS. THE DEALER WAS NOT CONTACTED TO DETERMINE THE CAUSE OF THE ENGINE POWER FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING) SEVERAL MONTHS AFTER THE COLLISION. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS UNKNOWN. *TT *CN
Official recalls
310V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V690000 · Air Bags:frontal
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.