IllustrationEVERY SO OFTEN THE BRAKE LIGHT COMES ON AND THE BRAKES SCREECH AND DON'T RESPOND WHEN STEP ON THE BRAKE PEDAL. WHAT I DO IS TURN OF THE CAR AND FOR SOME REASON THIS SEEMS TO DO A RESET AND THE CAR GOES BACK TO NORMAL. THIS IS VERY DANGEROUS BECAUSE IF IT HAPPENS WHEN YOU'RE DRIVING AND BRAKE YOU CAN CRASH.
2006 Nissan Armada
Owner reports · Recalls · Investigations
More warning signs than most Armada years
Owner complaints for the 2006 Nissan Armada are substantially higher than the model-year median of 23.
About this comparison →How this year compares
Owner complaints by model year
Compare all Armada years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
2825–50K
4450–75K
4875–100K
59100–150K
26150K+
230 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 138 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports13 fire reports9 injury reports
Service Brakes complaints
138 reportsBRAKE KEEP GOING OUT WHILE DRIVING DOESN'T HAPPEN ALL THE TIME... BUT WHEN IT HAPPEN THE BRAKE LIGHT ON AND WHEN YOU TRY TO STEP ON THE BRAKE IT SHAKE AND GRIND... I REPORT THIS A COUPE TIME ALREADY AND STILL NOTHING HAPPEN...AND WITH THE AIRBAG LIGHT KEEP COMING ON AND WHEN I RESET IT TWO DAY LATER IT COME RIGHT BACK ON. *TR
OWN A 2006 NISSAN ARMADA LE. STARTED MY TRUCK AND THE BRAKE, VDC, SLIP, AND 4WD LIGHTS LIT UP ON THE DASHBOARD. THOUGHT IT APPEARED BECAUSE IT WAS GETTING COLD. DROVE A COUPLE OF BLOCKS DOWN A CITY A STREET AND HEARD A LOUD GRINDING NOISE WHEN THE BRAKES WERE PRESSED AND THE TRUCK JOLTED A LITTLE BIT. AFTER ANOTHER BLOCK, LIG…
Read full complaint
OWN A 2006 NISSAN ARMADA LE. STARTED MY TRUCK AND THE BRAKE, VDC, SLIP, AND 4WD LIGHTS LIT UP ON THE DASHBOARD. THOUGHT IT APPEARED BECAUSE IT WAS GETTING COLD. DROVE A COUPLE OF BLOCKS DOWN A CITY A STREET AND HEARD A LOUD GRINDING NOISE WHEN THE BRAKES WERE PRESSED AND THE TRUCK JOLTED A LITTLE BIT. AFTER ANOTHER BLOCK, LIGHTS WENT AWAY AND DIDN'T HAVE MORE ANY ISSUES ON THE WAY HOME. WHEN I GOT HOME, TURN THE TRUCK OFF AND RESTARTED THE TRUCK, NO LIGHTS. DID A GOOGLE SEARCH AND READ MANY ISSUES RELATING TO THIS. A COUPLE A DAYS LATER CHECKED THE TRUCK, ON START-UP...NO LIGHTS, THEN WHEN I PUT IT IN DRIVE, THE SAME LIGHTS LIT UP. TOOK IT TO THE DEALERSHIP, LIGHTS WERE LIT, BRAKES ENGAGED, AND SPEEDOMETER WAS FLUCTUATING AND THEN DIDN'T MOVE. WHEN I ARRIVED AT THE DEALERSHIP, SPEEDOMETER ACTIVATED AGAIN WHEN THE TRUCK WAS PUT IN PARK. NISSAN DEALERSHIP DID A DIAGNOSTIC TEST AND THE ADVISOR INDICATED BOTH THE ECM AND ABS ACTUATOR ASSEMBLY WERE FRIED AND NEEDED TO BE REPLACED, $3,100 TO START OUT WITH. TRUCK IS STILL AT THE SHOP, NO WORK HAS STARTED. NOTIFIED NISSAN CUSTOMER RELATIONS SINCE THERE IS A KNOWN ISSUE, WAITING TO HEAR BACK. ALSO CALLED ANOTHER DEALERSHIP TO SEE WHAT THEY COULD TELL ME AND IT WAS MENTIONED THAT THERE IS A KNOWN ISSUE. CALLED THE SERVICE DEPT. BACK THE NEXT DAY AND TALKED TO ANOTHER ADVISOR, THE ADVISOR INDICATED SINCE THERE ARE SOME ARE HARD CODES (U1000, U1001) DISPLAYED WITH THE ECM AND ABS ASSEMBLY, THE SYSTEMS POTENTIALLY NEED TO BE REPLACED.
BRAKES FAILED TO OPERATE CORRECTLY CAUSING MY WIFE TO REAR END THE VEHICLE IN FRONT OF HER. DAMAGING BOTH VEHICLES I AM GLAD THAT HER OR MY TWO SONS WHO WERE IN THE VEHICLE AND THE OTHER PERSON WERE NOT HURT. NISSAN IS AWARE OF THE BRAKE ISSUES RELATED TO THE NISSAN ARMADA AND TITAN
BRAKE ISSUES GRINDING TURN CAR OFF STOPS BRAKE LIGHT COMES ON WHEN A PROBLEM BUT GOES OF WHEN RESTARTED. SEE ATTACHED LAWSUIT.
AS I WAS DRIVING MY ARMADA I HEARD A NOISE AND FELT THAT SOMETHING WAS WRONG WITH MY BREAKS. I TRIED TO BRAKE AND MY BREAKS WOULDN'T RESPOND, IT ALSO SOUNDED LIKE MY BREAKS WERE HITTING METAL WITH METAL, THE BREAK LIGHT ALSO CAME ON. AFTER PUSHING THE BREAK PEDAL SEVERAL TIMES IT STOPPED HAD TO TURN ON MY EMERGENCY LIGHTS AS I S…
Read full complaint
AS I WAS DRIVING MY ARMADA I HEARD A NOISE AND FELT THAT SOMETHING WAS WRONG WITH MY BREAKS. I TRIED TO BRAKE AND MY BREAKS WOULDN'T RESPOND, IT ALSO SOUNDED LIKE MY BREAKS WERE HITTING METAL WITH METAL, THE BREAK LIGHT ALSO CAME ON. AFTER PUSHING THE BREAK PEDAL SEVERAL TIMES IT STOPPED HAD TO TURN ON MY EMERGENCY LIGHTS AS I STOPPED AT A MAIN STREET. I TURNED OFF THE CAR AND BACK ON MY BRAKE LIGHT TURNED OFF AND DROVE HOME THROUGH THE SMALL STREETS SINCE WAS AFRAID THAT THE BREAKS WOULDN'T WORK AGAIN.
THE BRAKE LIGHT RANDOMLY TURNS ON. WHEN TRYING TO BRAKE THERE IS A VERY LOUD GRINDING NOISE. THE NOISE IS SCARY AND THE BRAKES WORK BUT NOT AS WELL. THIS HAS HAPPEN TO ME WHILE I'M DRIVING. I HAVE TO STOP TURN THE TRUCK OFF THEN THE BRAKE LIGHT DISAPPEARS AND STARTS WORKING AGAIN. IT'S HARD TO DIAGNOSE BECAUSE IT'S RANDOM. I…
Read full complaint
THE BRAKE LIGHT RANDOMLY TURNS ON. WHEN TRYING TO BRAKE THERE IS A VERY LOUD GRINDING NOISE. THE NOISE IS SCARY AND THE BRAKES WORK BUT NOT AS WELL. THIS HAS HAPPEN TO ME WHILE I'M DRIVING. I HAVE TO STOP TURN THE TRUCK OFF THEN THE BRAKE LIGHT DISAPPEARS AND STARTS WORKING AGAIN. IT'S HARD TO DIAGNOSE BECAUSE IT'S RANDOM. IT HAS HAPPENED MORE THAN ONCE, I WAS TOLD IT MIGHT BE A BRAKE BOOSTER BUT CAN'T TELL FOR SURE BECAUSE WHEN I TAKE IT TO THE SHOP IT'S NORMAL.
THE BRAKE LIGHT WOULD DISPLAY IN THE CAR. THERE IS A LOUD GRINDING NOISE WHICH HAPPEN WHEN BREAKING. AFTER CAR IS TURNED OFF AND TURNED BACK ON ITS LIKE NOTHING EVER HAPPEN. THIS SITUATION HAPPENS RANDOMLY.
BRAKING SYSTEM DOESNT WORK PROPERLY AT TIMES. BRAKE LIGHT ON DASH LIGHTS UP AND BRAKES PULSATE LIKE IT WOULD IF YOU ARE TRYING TO STOP ON ICE. AFTER RESTART VEHICLE IT WILL BE OK UNTIL IT HAPPENS AGAIN.
CHECK ENGINE LIGHT IS ON
Official recalls
310V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.