NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports10,000 miles · Nov 3, 2006
Service Brakes, Hydraulic
I OWN A 2005 NISSAN ARMADA (16,000 MILES) WITH BRAKE PROBLEMS. I PURCHASED THE VEHICLE ON AUGUST 22, 2006. IT WAS TAKEN TO A NISSAN DEALER TWO DAYS LATER WITH BRAKE PROBLEMS. THE DEALER REPLACED THE FRONT ROTORS AND PADS, THE REAR ROTORS WERE RESURFACED WITH NEW PADS. I PICKED THE VEHICLE UP ON FRIDAY, AND RETURNED WITH IT BACK …
Read full complaint
I OWN A 2005 NISSAN ARMADA (16,000 MILES) WITH BRAKE PROBLEMS. I PURCHASED THE VEHICLE ON AUGUST 22, 2006. IT WAS TAKEN TO A NISSAN DEALER TWO DAYS LATER WITH BRAKE PROBLEMS. THE DEALER REPLACED THE FRONT ROTORS AND PADS, THE REAR ROTORS WERE RESURFACED WITH NEW PADS. I PICKED THE VEHICLE UP ON FRIDAY, AND RETURNED WITH IT BACK TO THE DEALER ON MONDAY. MY ARMADA WAS NOT FIXED. THE STEERING WHEEL STILL WAS VIOLENTLY SHAKING,AND THE FRONT BRAKE PEDAL WAS SPONGY,AS WELL AS THE BRAKES OVER HEATING. THE DEALER HAD THE ARMADA FOR THREE DAYS TO FIX/REPLACE A FRONT CALIPER NEW PADS AGAIN, AND WHEEL BALANCE. I BELIEVE MORE WORK WAS DONE, HOWEVER THE WORK ORDER DOES NOT REFLECT ANY OTHER REPAIRS. WHAT REALLY DISTURBS ME IS THAT I FOUND OUT THAT IN OCTOBER OF 2005 THE ARMADA HAD THE BRAKES REPLACED BY THE ORIGINAL OWNER. THE VEHICLE WAS NOT EVEN A YEAR OLD AT THAT TIME. THIS MAKES 3 REPAIRS FOR THE SAME PROBLEM IN LESS THAN TWO YEARS. NISSAN STATES THE BRAKES ISSUES ARE CORRECTED, I THINK THAT EVERY 10K I WILL HAVE TO HAVE THE BRAKES REPLACED OVER AND OVER. NISSAN STATED THAT NO OTHER PADS OR ROTORS WILL BE COVERED UNDER A WARRANTY,SINCE THEY WERE FIXED TWICE ALREADY. I WILL SAY THE DEALER HAS BEEN VERY GOOD SO FAR,BUT WHAT HAPPENS WHEN I NEED BRAKES AGAIN. I AM AWARE OF OTHER ARMADA OWNERS WITH THIS SAME ISSUE. WHAT CAN BE DONE TO FINALLY CORRECT THIS SAFETY PROBLEM. *JB
NHTSA ODI #10172594
2,100 miles · Nov 2, 2006
EquipmentPower TrainService Brakes, Hydraulic
4WD LIGHT WOULD ENGAGE INTERMITTENTLY. STAYED ON FOR THE DURATION THAT THE VEHICLE WAS ON. THIS HAS HAPPENED 3 TIMES AT APPROX MILEAGE: 1530 MILES, 3650 MILES & YESTERDAY 10/31/06 AT 9:15 P.M. PST 6880 MILES. BRAKES & ROTORS FAILED AT 2200 MILES. REPLACED BY LOCAL DEALERSHIP. BRAKES SEVERELY SCREECHED AT 5500 MILES. LOCAL DEALE…
Read full complaint
4WD LIGHT WOULD ENGAGE INTERMITTENTLY. STAYED ON FOR THE DURATION THAT THE VEHICLE WAS ON. THIS HAS HAPPENED 3 TIMES AT APPROX MILEAGE: 1530 MILES, 3650 MILES & YESTERDAY 10/31/06 AT 9:15 P.M. PST 6880 MILES. BRAKES & ROTORS FAILED AT 2200 MILES. REPLACED BY LOCAL DEALERSHIP. BRAKES SEVERELY SCREECHED AT 5500 MILES. LOCAL DEALERSHIP SERVICE SAID "WE FORGOT TO TIGHTENED UP A FEW BOLTS ON YOUR BRAKES". AT 6750 MILES, SEVERE BRAKES PROBLEMS. BRAKES LIGHTS CAME ON, BRAKES LOCKED UP W/ CAR SEVERELY LURCHING FORWARD WHEN APPLYING PRESSURE LIGHT PRESSURE. DROVE TO THE DEALERSHIP AS IS WITHOUT TURNING OFF THE CAR. NOTICED THAT PROBLEM WAS SERIOUS & GAVE US A LOANER VEHICLE FOR 9 DAYS. LOCAL DEALERSHIP SAID THEY HAVE NEVER SEEN THIS FAILURE CODE BEFORE ON ANY NISSAN VEHICLE FOR A BRAKE ISSUE. "DELTA STROKEFORCE" LOCAL DEALERSHIP WAS UNABLE TO REPAIR THE PROBLEM; DROVE IT TO A NEIGHBORING DEALERSHIP 180 MILES R/T. THE NEIGHBORING DEALERSHIP RE-PROGRAMMED THE INTERNAL COMPUTER & ASSURED ME THE PROBLEM WAS FIXED. TONIGHT 11/01/2006, BRAKE LIGHT CAME ON & BRAKES FAILED AGAIN WITH MY WIFE & KIDS IN THE VEHICLE. COULD NOT MAKE A STOP OFF A FREEWAY EXIT & JUST ABOUT PUT HER FOOT THROUGH THE FLOORBOARD TRYING TO DO SO. BRAKES ENGAGED SUDDENLY SKIDDING THE TIRES THROUGH THE INTERSECTION. MILEAGE AT TIME OF INCIDENT 6927. IT IS NOW AT 6930; MY WIFE & I WILL BE DRIVING IT TO THE LOCAL DEALERSHIP IN THE MORNING. *NM
NHTSA ODI #10172426
680 miles · Aug 20, 2006
Service Brakes, Hydraulic
3/10/05 PURCHASED CAR NEW. 3/17/05 CAR IN SHOP FOR BRAKE AND STEERING VIBRATION. 4/11/05 ENTIRE FRONT CURTAIN AIRBAGS, HARNESS AND WIRING HAD TO BE REPLACED. CAR IN SHOP 8 DAYS. CAR HAS BEEN IN SHOP A TOTAL OF 12 TIME SINCE PURCHASE. MOSTLY FOR BRAKES, PULLING, VIBRATION, JUDDER, BROKEN PARTS. ALSO HAVING PROBLEMS WITH SEAT STAI…
Read full complaint
3/10/05 PURCHASED CAR NEW. 3/17/05 CAR IN SHOP FOR BRAKE AND STEERING VIBRATION. 4/11/05 ENTIRE FRONT CURTAIN AIRBAGS, HARNESS AND WIRING HAD TO BE REPLACED. CAR IN SHOP 8 DAYS. CAR HAS BEEN IN SHOP A TOTAL OF 12 TIME SINCE PURCHASE. MOSTLY FOR BRAKES, PULLING, VIBRATION, JUDDER, BROKEN PARTS. ALSO HAVING PROBLEMS WITH SEAT STAINS THAT WILL NOT STAY OUT OF OUR FABULOUS NASA FABRIC! WILL BE TRYING TO OBTAIN REPLACEMENT VEHICLE EITHER WITH DEALERSHIP OR ATTORNEY. YOU HAVE 12 COMPLAINTS AND MORE THAT ARE SIMILAR. WHY NO RECALL. THERE IS EVEN A NISSAN LEMON LAW WEBSITE. PLEASE HELP! *JB
NHTSA ODI #10166057
36,885 miles · Jul 16, 2006
Electrical System
I PURCHASED A USED 2005 NISSAN ARMADA ON MAY 22, 2006 WITH A MILEAGE OF 34,399 MILES. AS YOU CAN SEE I HAVEN'T HAD IT FOR A 2 FULL MONTHS YET, AND ALREADY IT HAS FAILED ME. ON MY WAY HOME FROM WORK AFTER WORKING 16 HOURS. I STOPPED IN A RECORD SHOP TO PURCHASE SOME MUSIC CD'S, IT HAD ONLY BEEN ABOUT 15 MINUTES THAT THE ENGINE …
Read full complaint
I PURCHASED A USED 2005 NISSAN ARMADA ON MAY 22, 2006 WITH A MILEAGE OF 34,399 MILES. AS YOU CAN SEE I HAVEN'T HAD IT FOR A 2 FULL MONTHS YET, AND ALREADY IT HAS FAILED ME. ON MY WAY HOME FROM WORK AFTER WORKING 16 HOURS. I STOPPED IN A RECORD SHOP TO PURCHASE SOME MUSIC CD'S, IT HAD ONLY BEEN ABOUT 15 MINUTES THAT THE ENGINE WAS SHUT OFF. WHEN I PROCEEDED BACK TO MY VEHICLE TO START IT BACK UP, IT WOULDN'T START. I THEREFORE CALLED AAA, THEY CAME IN A MATTER OF MINUTES, THEY TRIED FOR 45 MINUTES TO GIVE IT A BOOST BUT IT JUST WOULDN'T START, SO THEREFORE AAA HAD TO SEND A FLAT BED TOW TRUCK TO TOW IT BACK TO THE DEALER. I CONTACTED THE DEALER WHERE I PURCHASED THE VEHICLE FROM, THEY INFORMED ME THAT THE SERVICE DEPARTMENT WAS CLOSED, SO NOW I HAVE TO TAKE OFF A DAY OF WORK TO HAVE THIS VEHICLE TOWED ON MONDAY. THE CATCH 22 IS THEY CAN'T PROMISE ME A LOANER, AND THEY ARE NOT EVEN SURE IF THEY CAN REIMBURSE MY TOWING FEES. AS A CONSUMER WHO IS A SINGLE PARENT OF 4 WORKING 16 HOURS A DAY 5 DAYS A WEEK, I'M TAKING THIS ALL THE WAY TO THE TOP. THE END RESULTS THAT WOULD BE TO MY SATISFACTION IS TO GIVE ME A BRAND NEW 2006 ARMADA WITH 0 MILEAGE. THE DEALER DID NOT SERVICE THIS CAR PROPERLY. I CONDUCTED A CARFAX REPORT ON MY VEHICLE AND IT STATED THAT THIS VEHICLE WAS USED AS A RENTAL IN MARYLAND. I DON'T WANT THEM TO FIX IT, THEY ARE ASSUMING ITS THE ALTERNATOR OR THE STARTER, IN WHICH SHOULD NOT BE HAPPENING TO WHAT IS CONSIDERED TO BE A NEW TRUCK. I FEEL ONCE THEY FIX THAT PROBLEM, ANOTHER PROBLEM WILL OCCUR. I AM A VERY DISSATISFIED CUSTOMER, I FEEL I WAS TAKEN FOR MY MONEY BECAUSE I AM A WOMAN. I WILL BE CONTACTING CONSUMER AFFAIRS & NY1 NEWS STATION TO GET THE SATISFACTION I DESERVE. *JB
NHTSA ODI #10162505
Mileage unknown · Jul 6, 2006
Electrical System
WHILE DRIVING 65 MPH ON THE FREEWAY MY 2005 NISSAN ARMADA STALLED. THE ELECTRICAL WAS STILL FUNCTIONAL. WE HAD ENOUGH MOMENTUM TO PULL OVER TO THE SIDE OF THE ROAD. IT WAS DIFFICULT AS WE ALMOST HAD AN ACCIDENT. PRIOR TO THIS, THE AIRBAG WARNING LIGHT WAS FLASHING. WE HAD IT TOWED TO THE NEAREST NISSAN DEALER WHERE WE WERE TOLD …
Read full complaint
WHILE DRIVING 65 MPH ON THE FREEWAY MY 2005 NISSAN ARMADA STALLED. THE ELECTRICAL WAS STILL FUNCTIONAL. WE HAD ENOUGH MOMENTUM TO PULL OVER TO THE SIDE OF THE ROAD. IT WAS DIFFICULT AS WE ALMOST HAD AN ACCIDENT. PRIOR TO THIS, THE AIRBAG WARNING LIGHT WAS FLASHING. WE HAD IT TOWED TO THE NEAREST NISSAN DEALER WHERE WE WERE TOLD IT WAS PROBABLY DUE TO HAVING NO GAS IN OUR VEHICLE. BESIDES BEING INSULTED WE DID HAVE A 1/4 TANK OF GAS PRIOR TO TAKING IT TO THEM. WE STILL HAVE YET TO HEAR FROM THEM AGAIN AND THE VEHICLE HAS BEEN THERE FOR 2 DAYS. *NM
NHTSA ODI #10161686
14,000 miles · May 30, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED THAT WHILE DRIVING 70 MPH ON THE FREEWAY, THE VEHICLE STALLED. THE ENGINE WAS POWERLESS, BUT THE ELECTRICAL SYSTEM REMAINED OPERATIONAL. THERE WAS SUFFICIENT MOMENTUM TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A SERVICE DEALER. DUE TO THE HOLIDAY, THERE HAS BEEN NO COM…
Read full complaint
DT*: THE CONTACT STATED THAT WHILE DRIVING 70 MPH ON THE FREEWAY, THE VEHICLE STALLED. THE ENGINE WAS POWERLESS, BUT THE ELECTRICAL SYSTEM REMAINED OPERATIONAL. THERE WAS SUFFICIENT MOMENTUM TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A SERVICE DEALER. DUE TO THE HOLIDAY, THERE HAS BEEN NO COMMUNICATION WITH THE SERVICE DEALER.
NHTSA ODI #10158537
16,158 miles · May 27, 2006
Service Brakes, Hydraulic
BRAKE FAILURE INCIDENT WHEN SUV FAILED TO STOP AT A RED LIGHT. BRAKE PEDAL WAS COMPLETELY DEPRESSED, BUT SUV CONTINUED TO MOVE FORWARD. *NM
NHTSA ODI #10158437
4,500 miles · May 1, 2006
Service Brakes, Hydraulic
2005 NISSAN ARMADA BRAKES SHAKE WHEN APPLYING THE BREAKS. THE ROTORS ARE WARPED. SHAKING IS GETTING WORSE. *JB
NHTSA ODI #10156568
18,000 miles · Apr 7, 2006
Electrical SystemFireInjury
DT*: THE CONTACT STATED WHILE SITTING IN THE PARKED VEHICLE SMOKE WAS NOTICED COMING FROM UNDER THE STEERING COLUMN, IMMEDIATELY FOLLOWED BY THE AUTOMATIC DOOR LOCKS ENGAGING. THE PASSENGER DOOR WAS AJAR ALLOWING THE OCCUPANTS TO ESCAPE THE VEHICLE PRIOR TO IT ENGULFING IN FLAMES. WHILE EXITING THE VEHICLE BOTH OCCUPANTS SUST…
Read full complaint
DT*: THE CONTACT STATED WHILE SITTING IN THE PARKED VEHICLE SMOKE WAS NOTICED COMING FROM UNDER THE STEERING COLUMN, IMMEDIATELY FOLLOWED BY THE AUTOMATIC DOOR LOCKS ENGAGING. THE PASSENGER DOOR WAS AJAR ALLOWING THE OCCUPANTS TO ESCAPE THE VEHICLE PRIOR TO IT ENGULFING IN FLAMES. WHILE EXITING THE VEHICLE BOTH OCCUPANTS SUSTAINED MINOR INJURIES. THE FIRE AND POLICE DEPARTMENTS WERE ALERTED AND REPORTS FILED. THE VEHICLE IS CURRENTLY BEING INSPECTED BY THE INSURANCE COMPANY. THE MANUFACTURER HAS BEEN ALERTED. UPDATED 5/2/2006 - *NM
NHTSA ODI #10154833
7,000 miles · Mar 27, 2006
Service Brakes, Hydraulic
I OWN A 2005 NISSAN ARMADA WITH 7000 MILES AND THE BRAKE ROTORS SEEM TO BE WARPED ALREADY. I HAVE A COUSIN WHO HAS A 2004 TITAN AND HAS HAD PLENTY OF BRAKE PROBLEMS ALSO. WHEN BRAKING,ESPECIALLY AT HIGHER SPEEDS, THE STEERING WHEEL HAS A LOT OF VIBRATION. AFTER DOING RESEARCH ON THE INTERNET THERE SEEMS TO BE A LOT OF OTHER P…
Read full complaint
I OWN A 2005 NISSAN ARMADA WITH 7000 MILES AND THE BRAKE ROTORS SEEM TO BE WARPED ALREADY. I HAVE A COUSIN WHO HAS A 2004 TITAN AND HAS HAD PLENTY OF BRAKE PROBLEMS ALSO. WHEN BRAKING,ESPECIALLY AT HIGHER SPEEDS, THE STEERING WHEEL HAS A LOT OF VIBRATION. AFTER DOING RESEARCH ON THE INTERNET THERE SEEMS TO BE A LOT OF OTHER PEOPLE WITH THE SAME PROBLEM. BUT NISSAN HAS YET TO RECALL THESE VEHICLES WITH THESE PROBLEMS. THERE ARE SERVICE BULLETINS OUT TO REPLACE THE FRONT AND REAR ROTORS AND BRAKE PADS BUT AFTER READING MANY OF THE COMPLAINTS POSTED BY OTHER PEOPLE THEY ONLY WANT TO TURN THE ROTORS WHICH IS NOT THE SOLUTION. I WOULD LIKE TO KNOW WHAT MY RIGHTS ARE AND HOW TO GET NISSAN TO CORRECT THE PROBLEM RIGHT THE FIRST TIME. *JB
NHTSA ODI #10153859
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration