NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports54,000 miles · Sep 1, 2010
Electrical System
OUR ARMADA WOULD INTERMITTENTLY NOT WANT TO START OR TAKE A LONG TIME TO START. THEN SEVERAL WEEKS LATER IT DIED RIGHT AFTER STARTING. ALSO THE LIGHTS ON THE SASH WHERE GOING CRAZY (FLASHING AND STAYING SOLID). TRIED TO START THE TRUCK SEVERAL TIMES WITH IN THE NEXT HOUR WITH OUT ANY LUCK. HAS THE TRUCK TOWED TO NISSAN DEALER, W…
Read full complaint
OUR ARMADA WOULD INTERMITTENTLY NOT WANT TO START OR TAKE A LONG TIME TO START. THEN SEVERAL WEEKS LATER IT DIED RIGHT AFTER STARTING. ALSO THE LIGHTS ON THE SASH WHERE GOING CRAZY (FLASHING AND STAYING SOLID). TRIED TO START THE TRUCK SEVERAL TIMES WITH IN THE NEXT HOUR WITH OUT ANY LUCK. HAS THE TRUCK TOWED TO NISSAN DEALER, WHERE THEY SAID IT WAS THE IPDM MODULE. HAD THEM REPLACE THE PART. *TR
NHTSA ODI #10353322
108,000 miles · Aug 25, 2010
Service Brakes, Hydraulic
ABS BRAKES ENGAGE WHILE DRIVING WHICH CAUSES A LOUD GRINDING NOISE TO OCCUR WHEN I TRY TO APPLY MY BRAKES. THE BRAKING SYSTEM DOES NOT SEEM TO ENGAGE. IT HAS HAPPENED 6 TIMES IN THE PAST 8 WEEKS. THE LAST ONE OCCURRED 08/23/2010. *TR
NHTSA ODI #10351679
65,000 miles · Aug 19, 2010
Service Brakes, Hydraulic
WHEN DRIVING TO WORK AND GOING OVER A SPEED BUMP THE BRAKE LIGHT CAME ON. THE BRAKE PEDAL WENT TO THE FLOOR. I THEN STARTED TO FEEL THE BRAKE PEDAL VIBRATING, AS IF THE ABS HAD KICKED ON. THIS HAS HAPPENED SEVERAL TIMES. I PROCEED TO PULL TO THE SIDE OF THE ROAD AND TURNED THE IGNITION OFF. I LEARNED THAT BY DOING SO THE COMPUTE…
Read full complaint
WHEN DRIVING TO WORK AND GOING OVER A SPEED BUMP THE BRAKE LIGHT CAME ON. THE BRAKE PEDAL WENT TO THE FLOOR. I THEN STARTED TO FEEL THE BRAKE PEDAL VIBRATING, AS IF THE ABS HAD KICKED ON. THIS HAS HAPPENED SEVERAL TIMES. I PROCEED TO PULL TO THE SIDE OF THE ROAD AND TURNED THE IGNITION OFF. I LEARNED THAT BY DOING SO THE COMPUTER RESETS ITSELF AND IT GOES AWAY. I AM CONCERNED ABOUT THIS PROBLEM. I TOW THREE QUADS IN THE WEEKEND TO HAVE SOME FUN, BUT I DON'T WANT TO GET INTO AN ACCIDENT WHEN GOING DOWN A HILL ON THE WAY TO MY DESTINATION. I ALSO CARRY MY KIDS AND THAT IS MY MAIN CONCERN. I HAVE TOOK IT TO THE DEALERSHIP AND THEY DON'T SEE ANYTHING WRONG WITH IT? THEY COULD NOT DUPLICATE BECAUSE IT DOESN'T HAPPEN OFTEN. I SUGGEST CHECKING THE 05 ON A DOWNHILL, THAT ALWAYS SEEMS TO CAUSE IT TO HAPPEN? *TR
NHTSA ODI #10350671
60,000 miles · Aug 17, 2010
Engine And Engine Cooling
MY WIFE WAS DRIVING THE 2005 NISSAN ARMADA WHEN IT TOTALLY SHUT DOWN. LUCKILY SHE WAS IN A PARKING LOT AND WAS ABLE TO GET OUT OF THE LANE OF TRAFFIC. WE TOOK IT TO THE DEALER, AND HE ADVISED IT WAS THE IPDM AND IS TYPICAL ISSUE WITH ARMADA. THEY REPLACED BUT SINCE THERE WERE NO RECALLS OR SERVICE BULLETINS, I HAD TO PAY FOR THE…
Read full complaint
MY WIFE WAS DRIVING THE 2005 NISSAN ARMADA WHEN IT TOTALLY SHUT DOWN. LUCKILY SHE WAS IN A PARKING LOT AND WAS ABLE TO GET OUT OF THE LANE OF TRAFFIC. WE TOOK IT TO THE DEALER, AND HE ADVISED IT WAS THE IPDM AND IS TYPICAL ISSUE WITH ARMADA. THEY REPLACED BUT SINCE THERE WERE NO RECALLS OR SERVICE BULLETINS, I HAD TO PAY FOR THE REPAIRS. I'D LIKE TO BE REIMBURSED AS IT APPEARS THIS IS A KNOWN ISSUE. *TR
NHTSA ODI #10349927
Mileage unknown · Aug 13, 2010
Engine And Engine Cooling
THE A/C HAS BEEN CUTTING HIGH AND GOING LOW ALL ON ITS OWN. SOMETIMES NOT COMING ON AT ALL. I WAS TOLD IT IS THE VBC AND THAT IT IS FRIED. NO AIR NO PART IN THE DEAD OF SUMMER IN THE SOUTH. I ASKED IF THERE WAS A RECALL BECAUSE OF THE LEAKING CONDENSER AT WHICH THAT COULD CAUSE MY PROBLEM. I WAS TOLD NO AND NO FURTHER ASSISTANC…
Read full complaint
THE A/C HAS BEEN CUTTING HIGH AND GOING LOW ALL ON ITS OWN. SOMETIMES NOT COMING ON AT ALL. I WAS TOLD IT IS THE VBC AND THAT IT IS FRIED. NO AIR NO PART IN THE DEAD OF SUMMER IN THE SOUTH. I ASKED IF THERE WAS A RECALL BECAUSE OF THE LEAKING CONDENSER AT WHICH THAT COULD CAUSE MY PROBLEM. I WAS TOLD NO AND NO FURTHER ASSISTANCE. IF THERE IS NO RECALL OR NO ONE ELSE IS HAVING THIS PROBLEM. WHY IS THIS PART ON BACK ORDER WITH NO ETD. *TR
NHTSA ODI #10349129
98,000 miles · Aug 5, 2010
Engine And Engine CoolingFuel System, Gasoline
THE VEHICLE UNEXPECTEDLY SHUT DOWN WHILE I WAS DRIVING ON A HIGHWAY AT 65 MPH. THE ENGINE SHUTDOWN COMPLETELY BUT THE ELECTRICAL PARTS WERE STILL FUNCTIONING. LUCKILY I WAS DRIVING AT A TIME WHEN THERE WAS NO TRAFFIC SO I WAS ABLE TO COAST TO THE SIDE OF THE ROAD. I WAITED FOR ABOUT 5 MINUTES AND TRIED TO RE-START THE VEHICLE H…
Read full complaint
THE VEHICLE UNEXPECTEDLY SHUT DOWN WHILE I WAS DRIVING ON A HIGHWAY AT 65 MPH. THE ENGINE SHUTDOWN COMPLETELY BUT THE ELECTRICAL PARTS WERE STILL FUNCTIONING. LUCKILY I WAS DRIVING AT A TIME WHEN THERE WAS NO TRAFFIC SO I WAS ABLE TO COAST TO THE SIDE OF THE ROAD. I WAITED FOR ABOUT 5 MINUTES AND TRIED TO RE-START THE VEHICLE HOPING THAT I COULD AT LEAST GET HOME. AFTER ABOUT 20 MINUTES AND A COUPLE OF ATTEMPTS, THE VEHICLE DID START BUT STALLED AND SHUT DOWN AGAIN A FEW BLOCKS FROM HOME WHILE I WAS DRIVING AT 35MPH. AGAIN I WAS ABLE TO COAST TO THE SIDE OF THE ROAD AND TRIED TO RE-START IT WITH NO SUCCESS. AT THIS POINT I HAD THE VEHICLE TOWED. THE NISSAN DEALERSHIP CHANGED THE IPDM AND SUPPOSEDLY FIXED THE VEHICLE. I PICKED IT UP AND AFTER DRIVING ONLY 10 MILES, IT WOULD NOT START BACK UP. I TOOK IT BACK TO THE DEALER AGAIN AND THEY CAME BACK SAYING THAT NOW THE CATALYTIC CONVERTERS HAD TO BE REPLACED AND INFORMED ME THAT BOTH THE IPDM AND CATALYTIC CONVERTERS WERE A COMMON ISSUE WITH THE ARMADA. SOUNDS TO ME LIKE A RECALL SHOULD BE IN PLACE FOR THIS. I CAN ONLY THANK GOD FOR HELPING ME TO STAY CALM WHEN THE VEHICLE SHUTDOWN AND THAT NEITHER MY KIDS OR I GOT INTO AN ACCIDENT ON THE FREEWAY. WHAT MAKES THIS MATTER WORSE IS THAT THERE WAS NO WARNING! NO ENGINE LIGHT OR ANYTHING TO WARN YOU OF THE FAILURE OR DANGER! *TR
NHTSA ODI #10347379
107,000 miles · Jul 26, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE VEHICLE WAS TAKEN IN FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS INFORMED THAT THE RADIATOR EXHIBITED A HOLE AND WOULD NEED TO BE REPLACED. IN ADDITION, THE CATALYTIC CONVERTER HAS ALSO FAILED AND WOULD NEED TO BE REPLACED. THE DEALER INFORMED HIM THERE WERE NO RECALLS AND HE WOUL…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE VEHICLE WAS TAKEN IN FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS INFORMED THAT THE RADIATOR EXHIBITED A HOLE AND WOULD NEED TO BE REPLACED. IN ADDITION, THE CATALYTIC CONVERTER HAS ALSO FAILED AND WOULD NEED TO BE REPLACED. THE DEALER INFORMED HIM THERE WERE NO RECALLS AND HE WOULD HAVE TO PAY FOR THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 107,000. UPDATED 10/13/10*BF UPDATED 10/19/10*JB
NHTSA ODI #10345261
143,000 miles · Jul 16, 2010
Fuel System, Other
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 50 MPH, AN UNKNOWN WARNING LIGHT BEGAN FLASHING ON THE DASHBOARD AND THE VEHICLE SLOWLY BEGAN TO LOSE POWER UNTIL FINALLY STALLING. THE CONTACT WAS ABLE TO COAST OFF THE ROADWAY. A TOW TRUCK WAS CALLED WHO ADDED MORE GASOLINE TO THE VEHICLE. THE VEHICLE THEN …
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 50 MPH, AN UNKNOWN WARNING LIGHT BEGAN FLASHING ON THE DASHBOARD AND THE VEHICLE SLOWLY BEGAN TO LOSE POWER UNTIL FINALLY STALLING. THE CONTACT WAS ABLE TO COAST OFF THE ROADWAY. A TOW TRUCK WAS CALLED WHO ADDED MORE GASOLINE TO THE VEHICLE. THE VEHICLE THEN RESUMED NORMAL OPERATION. THE CONTACT DROVE TO A LOCAL FUEL STATION AND REFUELED THE VEHICLE. THE CONTACT STATED THE FUEL LEVEL GAUGE WOULD INDICATE THE FUEL TANK WAS ONE HALF FULL WHEN IT WAS ACTUALLY EMPTY. HE WAS ABLE TO LOCATE NHTSA RECALL CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM, OTHER: STORAGE: FUEL GAUGE SYSTEM) BUT WHEN INQUIRING WITH THE DEALER, HE WAS TOLD HIS VIN WAS NOT INCLUDED WITH THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 143,000 AND THE CURRENT MILEAGE WAS 144,000.
NHTSA ODI #10343590
20,000 miles · Jul 15, 2010
Parking Brake
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE PARKING BRAKE WARNING LIGHT WOULD ILLUMINATE WHILE DRIVING AT VARIOUS SPEEDS. IN ADDITION, WHEN DEPRESSED, THE BRAKE PEDAL WOULD FALL INTO THE FLOORBOARD MUCH FARTHER THAN USUAL. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES BUT THE FAILURE COULD NOT BE DU…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE PARKING BRAKE WARNING LIGHT WOULD ILLUMINATE WHILE DRIVING AT VARIOUS SPEEDS. IN ADDITION, WHEN DEPRESSED, THE BRAKE PEDAL WOULD FALL INTO THE FLOORBOARD MUCH FARTHER THAN USUAL. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 66,000. UPDATED 09/16-10 *BF UPDATED 09/20/10*JB
NHTSA ODI #10343440
99,000 miles · Jul 13, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE VEHICLE WAS SHUT OFF AND RESUMED NORMAL OPERATION WHEN RESTARTED. THE CONTACT STATED THE FAILURE HAS OCCURRED AT LEAST FOUR TIMES EVEN WHILE AT A STOP. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THERE WERE NO REPAIRS. THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE VEHICLE WAS SHUT OFF AND RESUMED NORMAL OPERATION WHEN RESTARTED. THE CONTACT STATED THE FAILURE HAS OCCURRED AT LEAST FOUR TIMES EVEN WHILE AT A STOP. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THERE WERE NO REPAIRS. THE FAILURE MILEAGE WAS 99,000 AND THE CURRENT MILEAGE WAS 103000. UPDATED 09/22/10. *LJ UPDATED 09/23/10
NHTSA ODI #10343062
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration