NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
109 reportsClear category filter106,482 miles · Apr 22, 2013
Service Brakes
THE BRAKES LOCKED UP, EXPERIENCED VIBRATION ON THE STEERING WHEEL, AND BRAKES BEGAN STUTTERING. THIS IS ABOUT THE FOURTH TIME THAT THIS INCIDENT OCCURS. THIS OCCURS AS YOU APPLY THE BRAKE SLOWLY AT SLOW SPEEDS, USUALLY AROUND 20-30 MPH. BRAKE WARNING LIGHT IN THE INSTRUMENT PANEL FLASHES. THE ONLY WAY TO RESET IS BY TURNING OFF …
Read full complaint
THE BRAKES LOCKED UP, EXPERIENCED VIBRATION ON THE STEERING WHEEL, AND BRAKES BEGAN STUTTERING. THIS IS ABOUT THE FOURTH TIME THAT THIS INCIDENT OCCURS. THIS OCCURS AS YOU APPLY THE BRAKE SLOWLY AT SLOW SPEEDS, USUALLY AROUND 20-30 MPH. BRAKE WARNING LIGHT IN THE INSTRUMENT PANEL FLASHES. THE ONLY WAY TO RESET IS BY TURNING OFF THE CAR AND TURNING IT BACK ON. *TR
NHTSA ODI #10509173
124,775 miles · Mar 5, 2013
Electrical SystemElectronic Stability Control (esc)Service Brakes
THE INCIDENT HAS HAPPENED TWICE ALREADY ONCE WHILE DRIVING AND GOING ABOUT 35 MILES PER HOUR. THE 2ND WHILE SITTING IN A DRIVE THRU. WHILE SLOWING DOWN FOR THE LIGHT, IT FELT AS THE BRAKES GAVE OUT. THE BRAKE PEDAL DID NOT HAVE ANY PRESSURE IN THEM AND GAVE THIS LOUD CRUNCHING SOUND. ALSO SOUNDED LIKE A SPRING MOANING. IMMEDIATE…
Read full complaint
THE INCIDENT HAS HAPPENED TWICE ALREADY ONCE WHILE DRIVING AND GOING ABOUT 35 MILES PER HOUR. THE 2ND WHILE SITTING IN A DRIVE THRU. WHILE SLOWING DOWN FOR THE LIGHT, IT FELT AS THE BRAKES GAVE OUT. THE BRAKE PEDAL DID NOT HAVE ANY PRESSURE IN THEM AND GAVE THIS LOUD CRUNCHING SOUND. ALSO SOUNDED LIKE A SPRING MOANING. IMMEDIATELY THE BRAKE LIGHT CAME ON AS IF I HAD MY EMERGENCY BRAKES ON. I WAS IN A PANIC AND SWERVED TO THE SIDE OF THE ROAD NOT TO REAR END THE CAR IN FRONT OF ME. THIS CONTINUED UNTIL AFTER I COMPLETELY TURNED OFF THE CAR, LET IT SIT THEN TURNED IT BACK ON. THE LIGHT WENT OFF AND THE BRAKES WORKED AS NORMAL. THE 2ND TIME I WAS IN A DRIVE THRU MOVING FORWARD AND THE BRAKES SEEM TO GIVE OUT. CRUNCHING SOUND, BRAKE LIGHT AND ONLY WENT AWAY WHEN I TURNED THE ARMADA COMPLETELY OFF AND THEN ON AGAIN. AFTER RESEARCHING THE PROBLEM ONLINE IT APPEARS THAT MANY OTHER PEOPLE ARE EXPERIENCING THE SAME PROBLEM. THIS ARMADA, MY WIFE DRIVES TO WORK EVERY DAY BACK AND FORTH. WE CAN'T AFFORD ANOTHER CAR AND I FEAR FOR HER SAFETY AND THE CARS AROUND HER. HERE IS A LINK OF JUST SOME OF THE PEOPLE HAVING THE SAME ISSUE. HTTP://X.NISSANHELP.COM/FORUMS/ARMADA/1852-BRAKE-PROBLEMS-2.HTML. *TR
NHTSA ODI #10501416
23,523 miles · Jan 29, 2013
Service Brakes
IN MARCH 2009 MY 2005 NISSAN ARMADA, WHICH I BOUGHT NEW IN LATE 2004, STARTED TO HAVE PROBLEMS WITH THE BRAKES. THE RED WARNING LAMPS LIGHT UP AND THE CAR LOST MOST OF ITS BRAKING POWER, LIKE NOT HAVING ANY SERVO SUPPORT. THERE WERE ALSO NOISE AND A SOFT PULSING FEELING. WE FOUND THAT IF WE TURNED OF THE ENGINE AND THEN STARTED …
Read full complaint
IN MARCH 2009 MY 2005 NISSAN ARMADA, WHICH I BOUGHT NEW IN LATE 2004, STARTED TO HAVE PROBLEMS WITH THE BRAKES. THE RED WARNING LAMPS LIGHT UP AND THE CAR LOST MOST OF ITS BRAKING POWER, LIKE NOT HAVING ANY SERVO SUPPORT. THERE WERE ALSO NOISE AND A SOFT PULSING FEELING. WE FOUND THAT IF WE TURNED OF THE ENGINE AND THEN STARTED IT AGAIN, EVERYTHING WORKED FINE. NISSAN COULD NOT FIND ANY FAULTS WITH THE CAR. THE PROBLEM REPEATED ITSELF 4-6 TIMES A YEAR. NISSAN COULD STILL NOT FIND ANY FAULTS THEY COULD NOT REPEAT THE FAULT WHEN THEY HAD THE CAR IN FOR TESTS. IN JULY 2012, ON MY ANNUAL SERVICE, I ASKED AGAIN ABOUT THE BRAKES. I WAS THEN TOLD THAT OTHER CUSTOMERS HAVE HAD THE SAME PROBLEM AND THAT THEY NOW HAS A SOLUTION FOR THE PROBLEM. I AM SURPRISED THAT NISSAN HAS NOT RECALLED THE FAILING BRAKES. NISSAN'S ANSWER IS STILL THAT THERE WAS NO PROBLEM. I HAVE THE WORK PAPERS TO SHOW WHAT WAS NEEDED TO FIX THE PROBLEM. *TR
NHTSA ODI #10495109
27,000 miles · Dec 18, 2012
Service BrakesSuspensionWheels
THE BRAKES SOUNDS ALOUD METAL CONTACT THE BRAKE LIGHT COMES ON THE TRUCK SHAKES YOU HAVE TURN ENGINE OFF FOR AT LEAST FIVE MINUTES. *TR
NHTSA ODI #10489209
30,568 miles · Dec 12, 2012
Service Brakes
I HAVE A 2005 ARMADA AND I EXPERIENCED THE ABS/BRAKE/VDC LIGHT COMING ON. TOOK IT TO THE DEALER AND THEY COULD NOT FIND ANYTHING WRONG. THEY RESET THE COMPUTER AND ADDED FLUID TO THE MASTER CYLINDER. THIS HAPPENED AFTER HAVING THE VEHICLE FOR 13 MONTHS. SYMPTOMS: BRAKE PEDDLE FELL TO THE FLOORBOARD, GRINDING WAS FELT AND HEARD,…
Read full complaint
I HAVE A 2005 ARMADA AND I EXPERIENCED THE ABS/BRAKE/VDC LIGHT COMING ON. TOOK IT TO THE DEALER AND THEY COULD NOT FIND ANYTHING WRONG. THEY RESET THE COMPUTER AND ADDED FLUID TO THE MASTER CYLINDER. THIS HAPPENED AFTER HAVING THE VEHICLE FOR 13 MONTHS. SYMPTOMS: BRAKE PEDDLE FELL TO THE FLOORBOARD, GRINDING WAS FELT AND HEARD, DASH BRAKE LIGHT CAME ON. IT FELT LIKE THE BRAKE PADS FELL OFF THE CALIPERS AND THE CALIPERS AND ROTORS WERE RUBBING AGAINST EACH OTHER TO STOP THE TRUCK, WHICH DIDN'T HAPPEN. I HAD ROUGHLY 20% BRAKING POWER, COMPARED TO NORMAL, WHEN THIS OCCURRED. I HAVE HAD BAKE WORK DONE OVER AND OVER AGAIN AND THE ISSUE CONTINUE TO COME BACK AND IT'S VERY RANDOM. MY COUSIN WHOM HAS A 2005 NISSAN ARMADA ALSO CALL ME TODAY COMPLAINING ABOUT THE SAME ISSUE. DID MORE RESEARCH AND FOUND THIS WEB SITE HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0FFEA4 WERE THERE WERE OVER 100 POST OF PEOPLE COMPLAINING ABOUT THE EXACT SAME ISSUE WITH THERE ARMADA. LUCKY I HAVE NOT HAD AN ACCIDENT WITH THIS ISSUE, BUT I FEEL AS IF MY DAY IS COMING. MY VEHICLE IS PAID OFF, AND I DON'T FEEL AS IF THIS IS A NORMAL WEAR AND TEAR ISSUE OF THE VEHICLE, AND I DON'T WANT TO HAVE TO PURCHASE ANOTHER VEHICLE BECAUSE NISSAN IS REFUSING TO REPAIR AN SAFETY ISSUE WITH ONE IF IT VEHICLES. PLEASE HELP, RESOLVING THIS ISSUE COULD PREVENT ME OR SOMEONE ELSE FROM HAVING AN ACCIDENT BUT MORE IMPORTANTLY IT COULD HELP SAVE SOMEONE'S LIFE. PLEASE PLEASE PLEASE LOOK AT THE WEB SITE I PROVIDED. I FEEL AS IF THE THERE MAY NOT BE A LOT OF COMPLAINTS ABOUT THIS ISSUE BECAUSE PEOPLE DON'T KNOW HOW TO REPORT ISSUES. *TR
NHTSA ODI #10488138
100,000 miles · Dec 5, 2012
Service Brakes
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE EMERGENCY BRAKE WARNING LIGHT ILLUMINATED AS THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE. THE CONTACT MERGED TO THE SHOULDER AND POWERED OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE EMERGENCY BRAKE WARNING LIGHT ILLUMINATED AS THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE. THE CONTACT MERGED TO THE SHOULDER AND POWERED OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE POWER BOOSTER SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER TWICE FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 106,000.
NHTSA ODI #10487454
94,000 miles · Oct 23, 2012
Service Brakes
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKES MADE A GRINDING SOUND WHENEVER THE BRAKES WERE ENGAGED. THE CONTACT MENTIONED THAT THE GRINDING NOISE WOULD CEISED AFTER TURNING THE VEHICLE OFF AND BACK ON. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKES MADE A GRINDING SOUND WHENEVER THE BRAKES WERE ENGAGED. THE CONTACT MENTIONED THAT THE GRINDING NOISE WOULD CEISED AFTER TURNING THE VEHICLE OFF AND BACK ON. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE BRAKE BOOSTER WAS FAILING AND THE DELTA BOOSTER SENSOR INSIDE THE BRAKE BOOSTER NEEDED TO BE REPLACED AND REPROGRAMMED. THE CONTACT STATED THAT THE VEHICLE HAD NEW BRAKES PADS AT THE TIME OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 103,000.
NHTSA ODI #10481498
40,000 miles · Sep 19, 2012
Service Brakes
BRAKE LIGHT CAME ON DURING NORMAL DRIVING CONDITIONS. WHEN I PRESSED THE BRAKE TO STOP, THE ABS SYSTEM KICKED ON AND BRAKING DISTANCE WAS GREATLY REDUCED. PROBLEM RESET ITSELF WHEN VEHICLE WAS TURNED OFF AND TURNED BACK ON. IT HAS BEEN AN INTERMITTENT PROBLEM NOW FOR 5 YEARS. NEVER HAVE HAD IT NEAR A DEALER WHEN IT HAS HAPPENED …
Read full complaint
BRAKE LIGHT CAME ON DURING NORMAL DRIVING CONDITIONS. WHEN I PRESSED THE BRAKE TO STOP, THE ABS SYSTEM KICKED ON AND BRAKING DISTANCE WAS GREATLY REDUCED. PROBLEM RESET ITSELF WHEN VEHICLE WAS TURNED OFF AND TURNED BACK ON. IT HAS BEEN AN INTERMITTENT PROBLEM NOW FOR 5 YEARS. NEVER HAVE HAD IT NEAR A DEALER WHEN IT HAS HAPPENED SO I HAVE NOT GOTTEN IT FIXED. IT MAY COME ON TWO OR THREE TIMES A DAY THEN IT MIGHT NOT COME BACK ON FOR 6 MONTHS THEN IT WILL HAPPEN EVERYDAY FOR A WEEK AND THE STOP FOR THREE MONTHS. SOMETHING IS CLEARLY WRONG WITH THEIR BRAKING SYSTEM AND I DON'T WANT TO PAY THEM TO FIX THEIR MISTAKES. HERE WE ARE AFTER OWNING THE CAR FOR 5 YEARS AND SEEING MANY TALK FORUMS OF OTHER PEOPLE HAVE THE SAME ISSUE AND NISSAN HAS NOT STEPPED UP TO RESOLVE IT. THE BRAKE SYSTEM IS A DANGEROUS COMPONENT TO HAVE FAIL GOING DOWN THE ROAD. *TR
NHTSA ODI #10475901
65,000 miles · Sep 17, 2012
Service Brakes
LIKE MANY OTHERS, WHEN APPLYING BRAKES, HARSH GRINDING NOISE AND INABILITY TO BRAKE EASILY. THE PROBLEM GOES AWAY WHEN CAR RE-STARTED. HAS HAPPENED ABOUT 25 TIMES IN 3 YEARS. SEEMS TO BE COMPUTER ISSUE BUT NEVER HAPPENS WHEN AT SERVICE CENTER. WHEN MY WIFE DROVE THE CAR , THE FIRST TIME IT HAPPENED SHOOK HER QUITE A BIT AS S…
Read full complaint
LIKE MANY OTHERS, WHEN APPLYING BRAKES, HARSH GRINDING NOISE AND INABILITY TO BRAKE EASILY. THE PROBLEM GOES AWAY WHEN CAR RE-STARTED. HAS HAPPENED ABOUT 25 TIMES IN 3 YEARS. SEEMS TO BE COMPUTER ISSUE BUT NEVER HAPPENS WHEN AT SERVICE CENTER. WHEN MY WIFE DROVE THE CAR , THE FIRST TIME IT HAPPENED SHOOK HER QUITE A BIT AS SHE WAS IN HIGH TRAFFIC AREA GOING ABOUT 40 MPH. IT IS UNSAFE TO TURN THE ENGINE OFF AND ON WHILE DRIVING BUT THIS IS ONLY WAY TO GET BRAKES OPERATING. *TR
NHTSA ODI #10475652
45,000 miles · Sep 17, 2012
Service Brakes
WHILE TRAVELING ON THE HIGHWAY (50MPH) RED BRAKE LIGHT CAME ON DASH AND WHEN APPLYING PRESSURE TO THE BRAKES, GRINDING NOISE IMMEDIATELY BEGAN AND PEDAL PRESSURE WAS NOT AVAILABLE. ALMOST FULL PEDAL TRAVEL TO THE FLOOR BOARD. AT THE TIME, ABS WAS KICKING IN AND BRAKES WERE NOT WORKING PROPERLY. HAD TO SWERVE TO MISS CARS THAT WE…
Read full complaint
WHILE TRAVELING ON THE HIGHWAY (50MPH) RED BRAKE LIGHT CAME ON DASH AND WHEN APPLYING PRESSURE TO THE BRAKES, GRINDING NOISE IMMEDIATELY BEGAN AND PEDAL PRESSURE WAS NOT AVAILABLE. ALMOST FULL PEDAL TRAVEL TO THE FLOOR BOARD. AT THE TIME, ABS WAS KICKING IN AND BRAKES WERE NOT WORKING PROPERLY. HAD TO SWERVE TO MISS CARS THAT WERE STOPPED OFF OF THE EXIT RAMP AT A RED LIGHT, PULLING OFF TO THE SIDE OF THE RAMP. HAD TO TURN THE CAR OFF AND RESTART THE CAR IN ORDER FOR THE BRAKES TO WORK PROPERLY AGAIN. AFTER RESEARCH, THIS IS A CONFIRMED AND KNOWN PROBLEM BY NISSAN OF AMERICA WITH THE BRAKE BOOSTER/DELTA SENSOR IN ARMADA AND TITAN TRUCKS MANUFACTURED BY NISSAN. *TR
NHTSA ODI #10475645
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration