NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
43 reportsClear category filterMileage unknown · Jan 11, 2018
Air BagsFuel/propulsion SystemSeat Belts
HEATING PROBLEM STOPPED WORKING, REPLACED PART AND HAD TO UNPLUG A UNNEEDED WIRE HARNESS AND RELAY IN ORDER TO RESTORE HEAT. FUEL GAUGE NOT WORKING OR READING PROPERLY. STILL TRYING TO FIND RESOLUTION. FRONT WINDOWS AND LOCKS STOP WORKING AT ANY GIVEN TIME. STILL TRYING TO RESOLVE. CHECK ENGINE LIGHT, FAULTY EXHAUSTSYSTEM NEEDS…
Read full complaint
HEATING PROBLEM STOPPED WORKING, REPLACED PART AND HAD TO UNPLUG A UNNEEDED WIRE HARNESS AND RELAY IN ORDER TO RESTORE HEAT. FUEL GAUGE NOT WORKING OR READING PROPERLY. STILL TRYING TO FIND RESOLUTION. FRONT WINDOWS AND LOCKS STOP WORKING AT ANY GIVEN TIME. STILL TRYING TO RESOLVE. CHECK ENGINE LIGHT, FAULTY EXHAUSTSYSTEM NEEDS TO REPLACED. HARD STARTING STILL TRYING TO FIND RESOLUTION. AIRBAG LIGHT ON WAS SUGGESTED SEAT BELT BUCKLE REPLACEMENT
NHTSA ODI #11062174
Mileage unknown · Jan 8, 2018
Fuel/propulsion System
MY GAS GAUGE HAS BEEN STUCK ON 1/4 OF A TANK SINCE THURSDAY I CRUNK UP MY CAR THIS MORNING,IT WAS FINEI WENT BACK IN MY CAR WAS CUT OFF SO MY NEIGHBOR WENT AND GOT A GALLON OF GAS POURED IT IN MY GAS TANK IN MY CAR CRUNK BACK UP. THEN I WENT AND PUT $15 IN MY TANK AM I GAS HAND NEVER MOVEDSO I CHECKED ONLINE AND I SEEN MANY …
Read full complaint
MY GAS GAUGE HAS BEEN STUCK ON 1/4 OF A TANK SINCE THURSDAY I CRUNK UP MY CAR THIS MORNING,IT WAS FINEI WENT BACK IN MY CAR WAS CUT OFF SO MY NEIGHBOR WENT AND GOT A GALLON OF GAS POURED IT IN MY GAS TANK IN MY CAR CRUNK BACK UP. THEN I WENT AND PUT $15 IN MY TANK AM I GAS HAND NEVER MOVEDSO I CHECKED ONLINE AND I SEEN MANY THINGS THAT WAS TALKING ABOUT RECALLS SO I'LL CALL THE ONE 800 NUMBER AND THEY TOLD ME THAT MY CAR DID NOT HAVE A RECALL FOR THE FUEL SENDING UNIT AND I KNOW THAT'S WHAT'S WRONG WITH MY CAR AND I DO NOT HAVE THE MONEY TO FIX THAT NOR DO I HAVE THE MONEY TO GET MY CAR DIAGNOSED AT A NISSAN DEALERSHIP WHAT DO I NEED TO DO BECAUSE I KNOW MY VIN NUMBER SHOULD HAVE BEEN ON THE RECALL LIST AND I REFUSE TO PAY FOR SOMETHING THAT SHOULD BE ABLE TO BE FIXED I SEE WHERE A LOT OF PEOPLE HAD THIS PROBLEM AS WELL
NHTSA ODI #11061096
140,000 miles · Dec 29, 2017
Fuel/propulsion SystemUnknown Or Other
IN MY 2005 NISSAN ARMADA THE FUEL PUMP GAUGE DOES NOT NOTIFIY YOU WHEN THE SUV IS RUNNING OUT OF FUEL AS WELL AS THE GAS LIGHT IT DOES NOT COME ON TO LET YOU KNOW YOU ARE LOW ON GAS.
NHTSA ODI #11057273
95,201 miles · May 5, 2017
Fuel/propulsion System
MY ARMADA RAN OUT OF GAS AFTER HAVING PICKED UP MY DAUGHTER FROM SCHOOL ON A CITY STREET. I BARELY MADE IT ACROSS THE INTERSECTION AND WAS ABLE TO COAST TO THE SIDE OF THE ROAD WITH THE STEERING WHEEL STIFFENING UP. I'VE RAN OUT OF GAS THREE TIMES SINCE THEN AND EACH TIME THE GAS TANK SHOWS THERE IS AT LEAST A QUARTER TANK LEFT…
Read full complaint
MY ARMADA RAN OUT OF GAS AFTER HAVING PICKED UP MY DAUGHTER FROM SCHOOL ON A CITY STREET. I BARELY MADE IT ACROSS THE INTERSECTION AND WAS ABLE TO COAST TO THE SIDE OF THE ROAD WITH THE STEERING WHEEL STIFFENING UP. I'VE RAN OUT OF GAS THREE TIMES SINCE THEN AND EACH TIME THE GAS TANK SHOWS THERE IS AT LEAST A QUARTER TANK LEFT. THE DEALER DOES NOT RECOGNIZE THIS AS AN ISSUE SINCE MY VIN IS NOT ONE OF "THOSE" AFFECTED. WHAT CAN I DO? THE FIRST INCIDENT HAPPENED IN FEBRUARY WHEN THE VEHICLE HAD LESS THAN 96000 MILES ON IT.
NHTSA ODI #10983679
160,000 miles · Feb 24, 2017
Air BagsEngineFuel/propulsion System
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING 70 MPH, SMOKE APPEARED FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A PIPE BURST. THE PIPE WAS REPLACED. SEVERAL DAYS LATER, WHILE DRIVING APPROXIMATEL…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING 70 MPH, SMOKE APPEARED FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A PIPE BURST. THE PIPE WAS REPLACED. SEVERAL DAYS LATER, WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE LOST POWER AND THE SERVICE ENGINE AND OTHER WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FUEL GAUGE DISPLAYED BETWEEN 1/4 TO EMPTY. THE VEHICLE RESTARTED ONCE THE CONTACT PLACED FUEL IN THE TANK. THE CONTACT ALSO STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE AIR BAG WARNING INDICATOR OR THE FUEL GAUGE MISREADING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA ODI #10956793
160,000 miles · Feb 23, 2017
Air BagsEngineFuel/propulsion System
NISSAN STATES THERE ARE NO RECALLS OPEN FOR THIS VIN ALTHOUGH NETS STATES THIS MAKE MODEL AND YEAR HAS A RECALL OUT FOR THE THE FUEL GAUGE. MY GAS TANK INCORRECTLY READS THE GAS WHICH CAUSED ME TO STALL ON THE HIGHWAY! I CAN DRIVE AROUND ALL DAY AND WILL STILL SHOW ITS FULL. ENGINE IS ALSO VERY LOUD DURING ACCELERATION AND OVERH…
Read full complaint
NISSAN STATES THERE ARE NO RECALLS OPEN FOR THIS VIN ALTHOUGH NETS STATES THIS MAKE MODEL AND YEAR HAS A RECALL OUT FOR THE THE FUEL GAUGE. MY GAS TANK INCORRECTLY READS THE GAS WHICH CAUSED ME TO STALL ON THE HIGHWAY! I CAN DRIVE AROUND ALL DAY AND WILL STILL SHOW ITS FULL. ENGINE IS ALSO VERY LOUD DURING ACCELERATION AND OVERHEATS THE CAR. PASSENGER AIRBAG LIGHT WILL ALSO NOT TURN OFF, NOT SURE IF THIS IS A RECALL, BUT CAR INDICATES NO PASSENGER IS SITTING WHEN THERE IS AND SHOWS THE AIRBAG WILL NOT DEPLOY OF A CRASH HAPPENS.
NHTSA ODI #10956436
164,240 miles · Sep 12, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. AFTER THE CONTACT FILLED THE VEHICLE WITH FUEL, THE FUEL GAUGE FALSELY DISPLAYED A QUARTER OF A TANK. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED, BUT THE DEALER STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT R…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. AFTER THE CONTACT FILLED THE VEHICLE WITH FUEL, THE FUEL GAUGE FALSELY DISPLAYED A QUARTER OF A TANK. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED, BUT THE DEALER STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS UNAWARE IF THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 164,240.
NHTSA ODI #10905768
187,355 miles · Jul 5, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE FUEL GAGE ON THE INSTRUMENT PANEL BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE FUEL GAGE ON THE INSTRUMENT PANEL BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 187,355. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10882658
112,869 miles · May 20, 2016
Air BagsFuel/propulsion SystemService Brakes
THE DRIVER SIDE AIRBAG IS NOT WORKING DUE TO A FAULTY HARNESS ASSEMBLY. THE FUEL GAUGE DOES NOT MEASURE FUEL ACCURATELY. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES STOP WORKING WHILE YOU ARE DRIVING. NISSAN REFUSES TO FIX THE ISSUES WITHOUT US PAYING OVER 3 GRAND EVEN THOUGH THESE ITEMS WERE RECALLED ON OTHER NISSANS BUT THERE …
Read full complaint
THE DRIVER SIDE AIRBAG IS NOT WORKING DUE TO A FAULTY HARNESS ASSEMBLY. THE FUEL GAUGE DOES NOT MEASURE FUEL ACCURATELY. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES STOP WORKING WHILE YOU ARE DRIVING. NISSAN REFUSES TO FIX THE ISSUES WITHOUT US PAYING OVER 3 GRAND EVEN THOUGH THESE ITEMS WERE RECALLED ON OTHER NISSANS BUT THERE IS NO RECALL ON THIS PARTICULAR NISSAN. THIS NISSAN NEEDS TO BE ADDED TO THE RECALLS. WE BOUGHT THE CAR 5 MONTHS AGO FROM GO AUTOMOTIVE AND THEY ALSO REFUSED TO FIX THE ISSUES.
NHTSA ODI #10870106
154,385 miles · May 5, 2016
Electrical SystemFuel/propulsion System
I RECENTLY LEARNED OF THE SAFETY RECALL 10V-074 THAT DESCRIBED THE EXACT SITUATION I ENCOUNTERED IN 2014. I WAS DRIVING ON EXPRESSWAY AT 70 MPH WHEN ENGINE DIED. LUCKILY I WAS ABLE TO COAST OVER TO SIDE OF ROAD, BUT WAS BETWEEN AN ON RAMP AND OFF RAMP--VERY DANGEROUS. FUEL GAUGE SHOWED 1/3 OF A TANK. ROADSIDE ASSISTANCE ADDED A …
Read full complaint
I RECENTLY LEARNED OF THE SAFETY RECALL 10V-074 THAT DESCRIBED THE EXACT SITUATION I ENCOUNTERED IN 2014. I WAS DRIVING ON EXPRESSWAY AT 70 MPH WHEN ENGINE DIED. LUCKILY I WAS ABLE TO COAST OVER TO SIDE OF ROAD, BUT WAS BETWEEN AN ON RAMP AND OFF RAMP--VERY DANGEROUS. FUEL GAUGE SHOWED 1/3 OF A TANK. ROADSIDE ASSISTANCE ADDED A COUPLE GALLONS OF GAS. I WAS ABLE TO START AND DRIVE TO DEALER. NO RECALLS WERE IDENTIFIED FOR MY VIN AT THE TIME SO I WAS CHARGED NEARLY $1000 TO REPLACE FUEL PUMP/SENDER. I AM BRINGING THIS TO YOUR ATTENTION BECAUSE I HAVE SO FAR BEEN UNSUCCESSFUL IN NEGOTIATING REIMBURSEMENT FROM NISSAN. BASED ON THE NUMBER OF COMPLAINTS I SEE ON YOUR WEBSITE, I BELIEVE A NON-VIN SPECIFIC SAFETY RECALL CAMPAIGN MUST BE INITIATED BECAUSE THIS PROBLEM WILL MOST LIKELY CONTINUE SINCE THESE VEHICLES CAN LAST A LONG TIME--MY ARMADA HAD 154,000 MILES ON IT AT THAT TIME.
NHTSA ODI #10863332
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration