IllustrationTAKATA RECALL I HAVE PROBLEM WITH MY SECURITY ALARM SYSTEM IT GOES OFF FOR NO REASON AND ALSO THE HORN WHEN THE WEATHER DROPS COLD THE HORN GOING OFF CONTINUOUSLY MY MECHANIC CHANGE THE HORN RELAY MORE THAN 3 TIMES BUT THE ISSUE STILL THE SAME. I DON'T UNDERSTAND THESE TWO ISSUES ARE CONNECTED OR NOT BUT I NEED HELP.
2002 Mitsubishi Montero
Owner reports · Recalls · Investigations
More warning signs than most Montero years
Owner complaints for the 2002 Mitsubishi Montero are substantially higher than the model-year median of 20.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Montero years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
925–50K
1850–75K
1975–100K
25100–150K
4150K+
81 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports5 injury reports
Unknown Or Other complaints
4 reportsI ALSO OWN A 2002 MITSUBISHI MONTERO LTD. I HAVE OWNED IT FOR 6 YEARS AND HAVE HAD TO REPLACE THE BRAKES 6 TIMES. I DRIVE UP AND DOWN THE SOUTHERN CA MOUNTAINS, AND HAVE EXPERIENCED THE SAME SAME SHAKING A SHIMMING AS I HAVE HEARD OTHER OWNERS EXPRESS. THE BRAKES CONTINUALLY WEAR WITH BLACK "DUST" AROUND THE WHEELS, AND MAKE THE…
Read full complaint
I ALSO OWN A 2002 MITSUBISHI MONTERO LTD. I HAVE OWNED IT FOR 6 YEARS AND HAVE HAD TO REPLACE THE BRAKES 6 TIMES. I DRIVE UP AND DOWN THE SOUTHERN CA MOUNTAINS, AND HAVE EXPERIENCED THE SAME SAME SHAKING A SHIMMING AS I HAVE HEARD OTHER OWNERS EXPRESS. THE BRAKES CONTINUALLY WEAR WITH BLACK "DUST" AROUND THE WHEELS, AND MAKE THE GRINDING AND GROANING SOUNDS AS WELL. I HAVE NOT ATTEMPTED TO CONTACT MITSUBISHI REGARDING THIS PROBLEM, BUT HOWEVER, AM REALIZING THAT IT HAS BECOME A REAL ISSUE, AND CONTINUES TO COST UPWARDS OF $600 EACH TIME I HAVE TO REPLACE THE BRAKES. ANY ASSISTANCE REGARDING THE BRAKES WOULD BE GREATLY APPRECIATED.
RE SAFETY RECALL SR-04-008 FM MITSUBISHI FOR 2002 MONTERO, HAVING SAFETY NOTICE AUTHORIZED BY DEALERSHIP IN ROTA, SPAIN. *BF THE CONSUMER WAS INFORMED THAT THE RECALL DID NOT APPLY TO HER VEHICLE ANY LONGER. *SC
THIS VEHICLE HAS HAD MULTIPLE PROBLEMS WHICH THE DEALERSHIP, ON MULTIPLE ATTEMPTS TO FIX, HAS NOT BEEN ABLE TO FIX FAILURE. INITIALLY, THE VEHICLE WAS LEAKING FUEL AT THE PASSENGER REAR WHEEL WELL. THIS HAS OCCURRED ON 3 SEPARATE OCCASIONS. NO REASON FOR THIS WAS FOUND UPON INSPECTION. THE 3RD TIME THERE WAS FUEL LEAKAGE, T…
Read full complaint
THIS VEHICLE HAS HAD MULTIPLE PROBLEMS WHICH THE DEALERSHIP, ON MULTIPLE ATTEMPTS TO FIX, HAS NOT BEEN ABLE TO FIX FAILURE. INITIALLY, THE VEHICLE WAS LEAKING FUEL AT THE PASSENGER REAR WHEEL WELL. THIS HAS OCCURRED ON 3 SEPARATE OCCASIONS. NO REASON FOR THIS WAS FOUND UPON INSPECTION. THE 3RD TIME THERE WAS FUEL LEAKAGE, THERE WAS ALSO A FAILURE OF THE ENGINE IN WHICH HESITATING AND STALLING OCCURRED. THE SES LIGHT DID INITIATE. INITIALLY THE SOLENOID WAS REPLACED. 6 DAYS LATER THE SAME THING OCCURRED AND THE SES LIGHT DID AGAIN COME ON. THE VEHICLE WAS AGAIN TAKEN TO THE DEALER AND THE REAR CAMSTER AND FILTER WAS REPLACED. WE REQUESTED A MEETING WITH THE DISTRICT MANAGER TO DISCUSS THE PROBLEM. WE WERE TOLD HE WOULD BE BACK FROM VACATION AFTER 10/1 AND WE WOULD BE CONTACTED. AFTER THE LAST REPAIR, THE VEHICLE HAD A PROBLEM WITH LOSS OF POWER AT TIMES. THIS INCLUDED SLOW RESPONSE WHEN STEPPING ON THE FUEL (TO INCLUDE FLOORING IT) WHEN TRYING TO PASS. IT WAS TAKEN TO THE DEALER ON 10/4. THE SERVICE MANAGER DROVE IT AND STATED "COULD NOT DUPLICATE COMPLAINT". IT WAS TAKEN TO THE DEALER A SECOND TIME APPROX. 1 WK LATER AND EVEN THOUGH FLOORING IT AT 35 MPH INITIATED A SLUGGISH RESPONSE IN WHICH THE RPM NEVER JUMPED UP BUT JUST STEADILY INCLINED AT A SLOW RATE, THE SERVICE MANAGER AGAIN SAID HE FELT THERE WAS NO PROBLEM. THIS LOSS OF POWER HAPPENED ONCE WHEN TRYING TO MERGE ONTO THE FREEWAY AND I ALMOST GOT HIT BEFORE I COULD PULL BACK OVER AND OUT OF THE WAY. ON 10/21 THE VEHICLE AGAIN EXHIBITED PROBLEMS WITH ACCELERATION FROM A STOP THIS TIME STALLING. AFTER 3 ATTEMPTS, I WAS STILL UNABLE TO RESTART THE VEHICLE. IT SAT FOR 65 MINUTES WAITING FOR MITSUBISHI'S TOWING SERVICE. AT THAT TIME, MY HUSBAND CAME AND STARTED THE VEHICLE. IT STARTED ON THE 2ND ATTEMPT AND BLUE-BLACK SMOKE CAME OUT FROM THE EXHAUST. WE DID DRIVE IT DOWN TO THE DEALERSHIP WITH ONLY TWO INSTANCES OF SOME LOSS OF POWER. PROBLEM STILL NOT CORRECTED. DT
Official recalls
304V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
04V319000 · Fuel System, Gasoline:storage
Jul 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES, WHEN THE FUEL TANK IS FULL AND THE VEHICLE IS PARKED FACING FORWARD ON AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE MAY NOT MAINTAIN PROPER SEALING IN THE EVENT THE FUEL EXPANDS FROM A RISE IN THE AMBIENT TEMPERATURE.
Consequence & remedy
Consequence: IF THE FUEL LEVELING VALVE DOES NOT SEAL PROPERLY, FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE LEVELING VALVE. THE RECALL BEGAN ON AUGUST 30, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.
01V254001 · Service Brakes, Hydraulic:power Assist:vacuum
Aug 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN IMPROPERLY MANUFACTURED. OVER A PERIOD OF TIME, THIS COULD RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR.
Consequence & remedy
Consequence: THE LOSS OF THIS GAS PRESSURE COULD RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL AN IMPROVED ACCUMULATOR. OWNER NOTIFICATION MAILING BEGAN OCTOBER 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ06007 · Brake Booster Accumulator Failure
Opened May 24, 2006 · Closed Oct 12, 2006
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings; Service Brakes, Hydraulic:power Assist:vacuum; Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (7)
Service Brakes, Hydraulic:fluid
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:hydraulic
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:vacuum
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.