AT THE MOMENT THE ONLY SITUATION THAT I HAVE HAD WITH THE MITSUBISHI AIRBAG RECALL IS THAT WHEN I CALL THE CUSTOMER RELATIONS DEPARTMENT THEY SAY THEY DO NOT HAVE THE PARTS, THAT SUPPOSEDLY THE MITSUBISHI COMPANY HAS NOT YET SENT THE REPLACEMENT PARTS.....I HAVE TO CALL WITHIN 2 MONTHS TO SEE IF THE PARTS HAVE ARRIVED AT THE REP…
Read full complaint
AT THE MOMENT THE ONLY SITUATION THAT I HAVE HAD WITH THE MITSUBISHI AIRBAG RECALL IS THAT WHEN I CALL THE CUSTOMER RELATIONS DEPARTMENT THEY SAY THEY DO NOT HAVE THE PARTS, THAT SUPPOSEDLY THE MITSUBISHI COMPANY HAS NOT YET SENT THE REPLACEMENT PARTS.....I HAVE TO CALL WITHIN 2 MONTHS TO SEE IF THE PARTS HAVE ARRIVED AT THE REPAIR SHOPS.
NHTSA ODI #11415421
Mileage unknown · Oct 5, 2020
Air Bags
TL* THE CONTACT OWNS A 1998 MITSUBISHI MONTERO. THE CONTACT DISCOVERED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V035000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEED…
Read full complaint
TL* THE CONTACT OWNS A 1998 MITSUBISHI MONTERO. THE CONTACT DISCOVERED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V035000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11362913
106,000 miles · Sep 11, 2005
Air Bags
MINOR PROBLEM WITH SWELLING IN DRIVER SIDE AIRBAG, 1998 MITS MONTERO, VIN[XXX]. PURCHASED NEW IN SANTA MARIA CA. THE SWELLING AIRBAG HAS CAUSED CONTINUOUS HORN ACTIVATION. THE HORN HAS BEEN DISCONNECTED. QUESTIONS: DO YOU HAVE ANY OTHER INCIDENTS THAT INDICATE A TREND WHERE THE DRIVER SIDE AIR BAG HAS AFFECTED THE HORN? IS…
Read full complaint
MINOR PROBLEM WITH SWELLING IN DRIVER SIDE AIRBAG, 1998 MITS MONTERO, VIN[XXX]. PURCHASED NEW IN SANTA MARIA CA. THE SWELLING AIRBAG HAS CAUSED CONTINUOUS HORN ACTIVATION. THE HORN HAS BEEN DISCONNECTED. QUESTIONS: DO YOU HAVE ANY OTHER INCIDENTS THAT INDICATE A TREND WHERE THE DRIVER SIDE AIR BAG HAS AFFECTED THE HORN? IS THIS A SAFETY ISSUE? THE DEALER IN SAN ANTONIO SAYS THE AIRBAG STILL WORKS BUT CAN'T BE REPLACED UNDER WARRANTY SINCE THE VEHICLE HAS OVER 100,000 MILES ON IT. REPLACEMENT PART QUOTED IS MR390111, MODULE AIR BAG, D-BROWN, PYRO TYPE FOR $688.33. *NM UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10136122
85,000 miles · Nov 10, 2004
Air BagsCrashInjury
WHILE DRIVING 35 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A THREE VEHICLE PILE UP. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED MAJOR HEAD INJURIES, AND PASSENGER BROKE HIS SHOULDER. *AK
NHTSA ODI #10099789
Mileage unknown · Sep 5, 2000
Air BagsSeat BeltsCrashInjury
ON IMPACT, THE REAR SEAT BELT CAME UNDONE AND THE AIRBAGS DID NOT DEPLOY.
NHTSA ODI #730325
Mileage unknown · Oct 29, 1999
Air BagsCrash
WHILE TRAVELING 40 MPH A SA RESULT OF AN ACCIDENT VEHICLE ROLLED OVER, AND AIR BAGS DID NOT DEPLOY WITHOUT INDICATIONS. PLEASE PROVIDE FURTHER INFORMATION. *AK
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 1998-2000 Montero vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: MMNA will notify owners, and dealers will replace the air bag inflator, free of charge. The recall began February 25, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-001.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.
Consequence & remedy
Consequence: BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP.
Remedy: DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE98042 · Rear Folding Seat Disengagement
Opened Jul 31, 1998 · Closed Sep 3, 1998
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
A POLICE REPORT RECEIVED BY ODI ALLEGED THAT DISENGAGEMENT OF THE RIGHT REAR FOLDING SEAT DURING A SINGLE VEHICLE ROLLOVER INCIDENT PERMITTED ITS OCCUPANT TO BE EJECTED
1998 Mitsubishi Montero Problems, Complaints & Recalls | Skip That Year
Illustration