IllustrationTL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. DURING AN OIL CHANGE, FIRESTONE FOUND A LEAK IN THE GASKET AND VALVE. THE MECHANIC BELIEVED THE FLOW ENGINE VALVE CAUSED THE LEAK. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND CURRENT MILEAGE WERE UNKNOWN.
2002 Mitsubishi Montero Sport
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Mitsubishi Montero Sport do not stand out strongly from the model-year median of 33.
About this comparison →How this year compares
Owner complaints by model year
Compare all Montero Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
425–50K
550–75K
475–100K
8100–150K
7150K+
33 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports0 fire reports11 injury reports
Engine And Engine Cooling complaints
6 reportsI HAD A BAD 02 SENSOR REPLACED ON MY 2002 MITSUBISHI MONTERO SPORT IN JUNE 2006. A MONTH LATER ANOTHER 02 SENSOR NEEDED TO BE REPLACED. TOTAL EXPENSE WAS $600+. *JB
HARD KNOCKING NOISE AND OIL LAMP ON IMMEDIATELY AFTER OIL HAS BEEN CHANGED. CHECKED OIL, DIP STICK SHOWED NO OIL IN ENGINE. TOOK BACK TO MECHANIC WHO PERFORMED AN OIL PUMP PRESSURE TEST, DIAGNOSED WITH NO OIL PRESSURE RECOMMENDED TAKE TO DEALERSHIP. DEALERSHIP CLAIMS PROBLEM DUE TO LACK OF OIL CHANGES, HAVE DOCUMENTS PROVING …
Read full complaint
HARD KNOCKING NOISE AND OIL LAMP ON IMMEDIATELY AFTER OIL HAS BEEN CHANGED. CHECKED OIL, DIP STICK SHOWED NO OIL IN ENGINE. TOOK BACK TO MECHANIC WHO PERFORMED AN OIL PUMP PRESSURE TEST, DIAGNOSED WITH NO OIL PRESSURE RECOMMENDED TAKE TO DEALERSHIP. DEALERSHIP CLAIMS PROBLEM DUE TO LACK OF OIL CHANGES, HAVE DOCUMENTS PROVING SCHEDULED MAINTENANCE PERFORMED AS RECOMMENDED. VEHICLE IS AT THE DEALERSHIP WITH $4000 WORTH OF WORK NEEDED TO REPAIR SLUDGE IN ENGINE THAT IS THE RESULT OF SOMETHING OTHER THAN FAULTY MAINTENANCE. ONLY SOLUTION FROM DEALERSHIP IS TO GET A NEW VEHICLE (FROM THEM OF COURSE). *NM
PROBLEMS WITH VEHICLE LOSING POWER AND CUTTING OFF.*MR VEHICLE RUNS ROUGH WHEN DRIVING UPHILL. VEHICLE STALLED. *TS
WHILE PULLING INTO A PARKING LOT THE ENGINE STARTED RACING AND THE VEHICLE CRASHED. *NLM
ON TWO SEPARATE OCCASIONS VEHICLE STALLS WHILE DRIVING. VEHICLE TAKEN TO DEALER AND UNABLE TO DUPLICATE THE PROBLEM.AK CONSUMER STATES THE 2ND OCCASION HAPPENED DURING THE MONTH OF APRIL APPROX 56 MPH. *MJ
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ06007 · Brake Booster Accumulator Failure
Opened May 24, 2006 · Closed Oct 12, 2006
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings; Service Brakes, Hydraulic:power Assist:vacuum; Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (7)
Service Brakes, Hydraulic:fluid
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:hydraulic
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Service Brakes, Hydraulic:power Assist:vacuum
IN OCTOBER 2001, MITSUBISHI NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 01V-254) TO REMEDY A DEFECT CONDITION THAT COULD RESULT IN A LEAK OF PRESSURIZED NITROGEN GAS FROM THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR IN APPROXIMATELY 39,000 MODEL YEARS (MY) 2001-2002 MITSUBISHI MONTERO VEHICLES PRODUCED FROM DECEMBER 12, 1999 THROUGH JUNE 20, 2001. ACCORDING TO MITSUBISHI, THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN MANUFACTURED IMPROPERLY, WHICH OVER A PERIOD OF TIME MAY RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE MAY RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME.DURING RQ06-007, MITSUBISHI INDICATED THAT THE DECISION TO CONDUCT RECALL 01V-254 WAS BASED ON PROJECTED FAILURE RATES OF 36.5% WITHIN 2-YEARS OF SERVICE AND 100% IN THE FIRST 4-YEARS OF SERVICE. THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED RQ06-007 BASED ON SIX COMPLAINTS OF HYDRAULIC BRAKE BOOSTER ACCUMULATOR FAILURE IN THE APPROXIMATELY 23,335 MY 2002 MONTERO VEHICLES THAT WERE BUILT AFTER THE VEHICLES RECALLED IN 01V-254.ONE OF THE COMPLAINTS ALLEGED THAT THE FAILURE RESULTED IN A CRASH.DURING THE INVESTIGATION, ODI IDENTIFIED 20 CONSUMER COMPLAINTS AND 58 WARRANTY CLAIMS RELATED TO BRAKE BOOSTER ACCUMULATOR FAILURE IN THE SUBJECT VEHICLES, RESULTING IN A COMPLAINT RATE OF APPROXIMATELY 85 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.25%.MITSUBISHI?S PROJECTED ACCUMULATOR FAILURE RATES AT 2- AND 4-YEARS IN SERVICE FOR THE SUBJECT VEHICLES WERE 0.5% AND 1.3% RESPECTIVELY AND ODI?S ANALYSES PRODUCED SIMILAR RESULTS.ODI?S INVESTIGATION FOUND THAT THE INCIDENTS OF INCREASED BRAKE PEDAL EFFORT TYPICALLY OCCURRED WITHIN THE FIRST FEW SECONDS AFTER THE ENGINE WAS STARTED AND WERE ACCOMPANIED BY NOISE ASSOCIATED WITH THE ACCUMULATOR CHARGING.ODI?S INVESTIGATION OF THE CRASH INCIDENT CONCLUDED THAT IT COULD NOT BE ATTRIBUTED TO THE ALLEGED DEFECT CONDITION.ODI ALSO COLLECTED AND ANALYZED DATA FOR POST-REMEDY ACCUMULATOR FAILURES IN VEHICLES THAT HAD THE 01V-254 REPAIRS COMPLETED.MITSUBISHI PROVIDED DATA DURING THE INVESTIGATION THAT INDICATED 95% OF THE RECALLED VEHICLES HAD RECEIVED THE RECALL REMEDY.FOR THESE VEHICLES, THERE WERE 14 COMPLAINTS AND 249 WARRANTY CLAIMS IDENTIFIED, RESULTING IN A COMPLAINT RATE OF 28 PER 100,000 VEHICLES AND A WARRANTY CLAIM RATE OF 0.64%.ANALYSIS OF THESE FAILURES SHOWED A DECLINING TREND WITH INCREASING VEHICLE AGE, WITH ALMOST HALF OF THE WARRANTY CLAIMS OCCURRING WITHIN THE FIRST 12-MONTHS AFTER RECEIVING THE RECALL REMEDY. DUE TO THE LOW FAILURE RATES, ABSENCE OF RELATED CRASHES, AND NO INDICATION OF INCREASING FAILURE TRENDS IN EITHER THE SUBJECT VEHICLES OR POST-REPAIR RECALL POPULATION THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.