IllustrationWHILE DRIVING 25 MPH DRIVER'S SIDE CONTROL ARM POPPED OFF THE WHEEL . HOWEVER, DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. CONSUMER HAD VEHICLE TOWED TO THE DEALER FOR ANALYSIS, AND MECHANIC DETERMINED THAT VEHICLE HAD BEEN IN A PREVIOUS ACCIDENT. VEHICLE COULD NOT BE REPAIRED DUE TO BENT CHASSIS. *AK
2002 Mitsubishi Lancer
Owner reports · Recalls · Investigations
More warning signs than most Lancer years
Owner complaints for the 2002 Mitsubishi Lancer are substantially higher than the model-year median of 27.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lancer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1825–50K
1050–75K
1475–100K
16100–150K
12150K+
86 reports with mileage · 62 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports1 fire reports17 injury reports
Suspension complaints
15 reportsTHE BRAKES WORE OUT PREMATURELY. THE PART WAS REPLACED THREE TIMES, BUT THE PROBLEM CONTINUED EXISTS. *AK THE VEHICLE LEFT BLACK OIL SPOTS ON THE GARAGE GROUND NEAR ALL FOUR TIRES THE CONSUMER WAS TOLD IT WAS FROM EXCESS FACTORY OVER COATING. THE BRAKES SQUEALED CONTINUOUSLY, THE FRONT BRAKE PADS WORE OUT PREMATURELY AN…
Read full complaint
THE BRAKES WORE OUT PREMATURELY. THE PART WAS REPLACED THREE TIMES, BUT THE PROBLEM CONTINUED EXISTS. *AK THE VEHICLE LEFT BLACK OIL SPOTS ON THE GARAGE GROUND NEAR ALL FOUR TIRES THE CONSUMER WAS TOLD IT WAS FROM EXCESS FACTORY OVER COATING. THE BRAKES SQUEALED CONTINUOUSLY, THE FRONT BRAKE PADS WORE OUT PREMATURELY AND A NAIL WAS IN THE SIDEWALL OF THE REAR TIRE AND COULDN'T BE REPAIRED BECAUSE TO THE FRONT AND REAR STRUTS NEEDED TO BE REPLACED DUE TO LEAKAGE, HOWEVER THE CONSUMER WAS GETTING DIFFERENT OPINIONS REGARDING THE STRUTS. THE CONSUMER FELT THAT THERE WAS SOMETHING WRONG WITH THE CALIPERS AND OR BRAKE DESIGN WHICH CAUSED THE BRAKES TO PREMATURELY WEAR OUT. *SCC THE CONSUMER WAS TOLD THE TIRES NEEDED TO BE REPLACED *JB
HAVING A PROBLEM WITH REAR SUSPENSION. THE ENTIRE BACK END SOUNDS AS IF THE FRAME IS BROKEN. WAS ASSURED BY MITSU SERVICE THAT IT IS NOT A SAFETY ISSUE. I WAS TOLD IT NEEDED BEARINGS AND BUSHINGS AND PARTS ARE ON BACK ORDER. THIS IS A 2002 LANCER OZ WITH 30000 MILES THIS SHOULD NOT BE HAPPENING TO A CAR OF THIS AGE. I AM FILING…
Read full complaint
HAVING A PROBLEM WITH REAR SUSPENSION. THE ENTIRE BACK END SOUNDS AS IF THE FRAME IS BROKEN. WAS ASSURED BY MITSU SERVICE THAT IT IS NOT A SAFETY ISSUE. I WAS TOLD IT NEEDED BEARINGS AND BUSHINGS AND PARTS ARE ON BACK ORDER. THIS IS A 2002 LANCER OZ WITH 30000 MILES THIS SHOULD NOT BE HAPPENING TO A CAR OF THIS AGE. I AM FILING THIS COMPLAINT BECAUSE I FEEL IF THERE ARE TWO COMPLAINTS ON THIS SITE THERE ARE MOST CERTAINLY DOZENS MORE OUT THERE OR MORE TO COME.*AK
I AM HAVING PROBLEMS WITH THE REAR SUSPENSION OF MY 2002 MITSUBISHI LANCER. SERVICE TELLS ME THAT THEY HAVE RECEIVED A BULLETIN FROM MITSUBISHI REGARDING AN ISSUE WITH THE CONTROL ARM BUSHINGS. APPARENTLY BOTH ARE BAD ON MY AUTOMOBILE. THE RECOMMENDED FIX TO THIS PROBLEM ACCORDING TO THE SERVICE BULLETIN IS A SPECIAL LUBE, HOWEV…
Read full complaint
I AM HAVING PROBLEMS WITH THE REAR SUSPENSION OF MY 2002 MITSUBISHI LANCER. SERVICE TELLS ME THAT THEY HAVE RECEIVED A BULLETIN FROM MITSUBISHI REGARDING AN ISSUE WITH THE CONTROL ARM BUSHINGS. APPARENTLY BOTH ARE BAD ON MY AUTOMOBILE. THE RECOMMENDED FIX TO THIS PROBLEM ACCORDING TO THE SERVICE BULLETIN IS A SPECIAL LUBE, HOWEVER AFTER TWO ATTEMPTS THE PROBLEM HAS NOT BEEN CORRECTED. ALTHOUGH MY CAR IS UNDER A FULL BUMPER-TO-BUMPER WARRANTY, SERVICE HAS MADE NO ATTEMPT TO REPAIR THE PROBLEM FOR OVER A MONTH, DESPITE NUMEROUS COMPLAINTS AND PROTESTS BY ME. THEY ARE INSTEAD "WAITING FOR MITSUBISHI TO TELL THEM HOW TO CORRECT THE PROBLEM". IN THE MEANTIME I AM FORCED TO DRIVE A DEFECTIVE AUTOMOBILE. *JB
LOWER CONTROL ARM ON FRONT PASSENGER SIDE OF VEHICLE BUCKLED UNDER RESULTING IN LOSS OF STEERING CONTROL AND THE VEHICLE STRIKING A CURB AT ~55 MPH. DEALERSHIP REFUSES TO FIX UNDER WARRANTY CITING THERE IS NO PROOF THAT HITTING THE CURB DID NOT CAUSE THE DAMAGE. I WAS INFORMED BY THE DEALERSHIP THAT THERE HAD BEEN A SIMILIAR I…
Read full complaint
LOWER CONTROL ARM ON FRONT PASSENGER SIDE OF VEHICLE BUCKLED UNDER RESULTING IN LOSS OF STEERING CONTROL AND THE VEHICLE STRIKING A CURB AT ~55 MPH. DEALERSHIP REFUSES TO FIX UNDER WARRANTY CITING THERE IS NO PROOF THAT HITTING THE CURB DID NOT CAUSE THE DAMAGE. I WAS INFORMED BY THE DEALERSHIP THAT THERE HAD BEEN A SIMILIAR INCIDENT THE PREVIOUS WEEK INVOLVING ANOTHER LANCER. ON THIS VEHICLE THE FAILURE WAS ON THE FRONT DRIVER SIDE OF THE VEHICLE. THIS FAILURE ALSO RESULTED IN A LOSS OF STEERING CONTROL AS WELL AS STRIKING AN OBJECT WITH THE VEHICLE. DT
Official recalls
216V458000 · Suspension:front:control Arm:lower Arm
Jun 23, 2016
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence & remedy
Consequence: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
04V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.