IllustrationCHECK ENGINE LIGHT CAME ON AND THE CAR QUIT ON ME WHEN I WAS DRIVING IT
2003 Mitsubishi Galant
Owner reports · Recalls · Investigations
More warning signs than most Galant years
Owner complaints for the 2003 Mitsubishi Galant are substantially higher than the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all Galant years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1425–50K
2150–75K
1875–100K
6100–150K
5150K+
76 reports with mileage · 50 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports4 fire reports11 injury reports
Power Train complaints
6 reportsI HAVE A 2003 MITSUBISHI GALANT PURCHASED NEW WITH 12 MILES. I HAVE KEPT UP MAINTENANCE ON MY CAR AND HAVE A MANUFACTURER AND EXTENDED WARRANTY (BOUGHT FROM THE DEALER) BOTH COVERING MY CAR UP TO 100,00 MILES. MY CAR HAS 91,000 MILES. I WAS DRIVING DOWN THE FREEWAY AND NOTICED THAT MY FOOT WAS ON THE GAS PEDAL BUT THE CAR WAS SL…
Read full complaint
I HAVE A 2003 MITSUBISHI GALANT PURCHASED NEW WITH 12 MILES. I HAVE KEPT UP MAINTENANCE ON MY CAR AND HAVE A MANUFACTURER AND EXTENDED WARRANTY (BOUGHT FROM THE DEALER) BOTH COVERING MY CAR UP TO 100,00 MILES. MY CAR HAS 91,000 MILES. I WAS DRIVING DOWN THE FREEWAY AND NOTICED THAT MY FOOT WAS ON THE GAS PEDAL BUT THE CAR WAS SLOWING DOWN. I IMMEDIATELY BEGAN EXITING THE FREEWAY TO THE RIGHT TO AT LEAST TRY TO REACH THE EMERGENCY LANE BEFORE THE CAR DIED ON THE FREEWAY. WHILE GETTING OVER SMOKE STARTED COMING OUT THE HOOD ENTERING THE CAR THROUGH THE AIR VENTS, BY THE TIME I CROSSED 4 LANES; MY CAR LOOKED LIKE IT WAS GOING TO BLOW UP. I JUMPED OUT THE CAR DUE TO FEAR ONCE I WAS ABLE TO DRIFT TO THE SIDE. I HAD IT TOWED TO AN AUTO MECHANIC SHOP WHERE THEY TOLD ME MY ENGINE AND TRANSMISSION WERE BLOWN. I HAD MY CAR TOWED TO A MITSUBISHI DEALERSHIP FOR REPAIRS AND WAS INFORMED (AFTER A WEEK OF GETTING THE RUN AROUND FROM MITSUBISHI, THE DEALER, AND THE EXTENDED WARRANTY COMPANY) THAT NONE OF THE MAINTENANCE WOULD BE COVERED. SO, I THE CONSUMER HAVE TO PAY AN OUT OF POCKET EXPENSE OF $3500. I WAS TOLD BY MITSUBISHI THAT IT WAS A PROBLEM WITH THE RADIATOR, (TEMPERATURE GAUGE WAS STUCK) WHICH CAUSED THE ENGINE AND TRANSMISSION TO GO OUT AND SINCE THE RADIATOR IS NOT COVERED BY THE MANUFACTURER OR THE EXTENDED WARRANTY THEN NONE OF THE REPAIRS WERE COVERED. IT TOOK THE DEALER 2 WEEKS TO START WORK ON MY CAR. *TR
I HAVE A 2003 MITSUBISHI GALANT PURCHASED NEW WITH 12 MILES. I HAVE KEPT UP MAINTENANCE ON MY CAR AND HAVE A MANUFACTURER AND EXTENDED WARRANTY (BOUGHT FROM THE DEALER) BOTH COVERING MY CAR UP TO 100,00 MILES. MY CAR HAS 91,000 MILES. I WAS DRIVING DOWN THE FREEWAY AND NOTICED THAT MY FOOT WAS ON THE GAS PEDAL BUT THE CAR WAS SL…
Read full complaint
I HAVE A 2003 MITSUBISHI GALANT PURCHASED NEW WITH 12 MILES. I HAVE KEPT UP MAINTENANCE ON MY CAR AND HAVE A MANUFACTURER AND EXTENDED WARRANTY (BOUGHT FROM THE DEALER) BOTH COVERING MY CAR UP TO 100,00 MILES. MY CAR HAS 91,000 MILES. I WAS DRIVING DOWN THE FREEWAY AND NOTICED THAT MY FOOT WAS ON THE GAS PEDAL BUT THE CAR WAS SLOWING DOWN. I IMMEDIATELY BEGAN EXITING THE FREEWAY TO THE RIGHT TO ATLEAST TRY TO REACH THE EMERGENCY LANE BEFORE THE CAR DIED ON THE FREEWAY. WHILE GETTING OVER SMOKE STARTED COMING OUT THE HOOD ENTERING THE CAR THROUGH THE AIR VENTS, BY THE TIME I CROSSED 4 LANES; MY CAR LOOKED LIKE IT WAS GOING TO BLOW UP. I JUMPED OUT THE CAR DUE TO FEAR ONCE I WAS ABLE TO DRIFT TO THE SIDE. I HAD IT TOWED TO AN AUTO MECHANIC SHOP WHERE THEY TOLD ME MY ENGINE AND TRANSMISSION WERE BLOWN. I HAD MY CAR TOWED TO A MITSUBISHI DEALERSHIP FOR REPAIRS AND WAS INFORMED (AFTER A WEEK OF GETTING THE RUN AROUND FROM MITSUBISHI, THE DEALER, AND THE EXTENDED WARRANTY COMPANY) THAT NONE OF THE MAINTENANCE WOULD BE COVERED. SO, I THE CONSUMER HAVE TO PAY AN OUT OF POCKET EXPENSE OF $3500. I WAS TOLD BY MITSUBISHI THAT IT WAS A PROBLEM WITH THE RADIATOR, (TEMPERATURE GAUGE WAS STUCK) WHICH CAUSED THE ENGINE AND TRANSMISSION TO GO OUT AND SINCE THE RADIATOR IS NOT COVERED BY THE MANUFACTURER OR THE EXTENDED WARRANTY THEN NONE OF THE REPAIRS WERE COVERED. IT TOOK THE DEALER 2 WEEKS TO START WORK ON MY CAR. *TR
THE TRANSMISSION IS DEFECTIVE. THE GEARS DO NOT CONNECT LIKE THEY SHOULD. SOMETIMES THE GEARS DO NOT RESPOND AT ALL.*AK THE CONSUMER STATED THAT THE AUTOMATIC TRANSMISSION DOES NOT SHIFT SMOOTHLY FROM 2ND TO 3RD GEAR. THE VEHICLE WAS CHECKED BY THE DEALER BUT THE PROBLEM WAS NOT FIXED. *TC
POTENTIAL SAFETY HAZARD REGARDING 2003 MITSUBISHI GALANT.*MR THE CONSUMER BELIEVES THE VEHICLE'S TRANSMISSION WAS SLIPPING. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRS WERE MADE. TEN DAYS AFTER REPAIRS THE TRANSMISSION BEGAN TO SLIP AGAIN. *NM
I HAVE A '03 MITSUBISHI GALANT (AUTOMATIC) WHICH NOW HAS APPROX 8000 MILES. AT APPROX. 4500 MILES THE VEHICLE BEGAN HESITATING UPON HARD ACCELERATION, SUCH AS WHEN ENTERING A FREEWAY. THE VEHICLE ALSO HESITATES WHILE DRIVING IN "STOP AND GO" TRAFFIC, SUCH AS WHAT IS DONE WITH IN-TOWN DRIVING IN TRAFFIC. AT FIRST I BELIEVED I …
Read full complaint
I HAVE A '03 MITSUBISHI GALANT (AUTOMATIC) WHICH NOW HAS APPROX 8000 MILES. AT APPROX. 4500 MILES THE VEHICLE BEGAN HESITATING UPON HARD ACCELERATION, SUCH AS WHEN ENTERING A FREEWAY. THE VEHICLE ALSO HESITATES WHILE DRIVING IN "STOP AND GO" TRAFFIC, SUCH AS WHAT IS DONE WITH IN-TOWN DRIVING IN TRAFFIC. AT FIRST I BELIEVED I HAD FILLED THE GAS TANK WITH BAD GASOLINE. THE VEHICLE ACTED LIKE IT HAD A CLOGGED FUEL FILTER/LINE. I CONTINUED DRIVING THE VEHICLE WHILE TRYING TO FIGURE OUT WHAT WAS WRONG. A WARNING LIGHT FINALLY CAME ON AND I TOOK THE VEHICLE IN TO THE DEALER WHERE I PURCHASED IT ON 6/9/03. I WAS INFORMED THAT THERE WAS A PROBLEM WITH THE TRANSMISSION. THE DEALER KEPT THE VEHICLE FOR APPROX 3 WEEKS TO MAKE THE REPAIRS. DIAGNOSIS: INTERNAL TRANS FAILURE UPON INSPECTION FOURND 4TH GEAR CLUTCH PAST CLEARANCE OUT OF SPEC AND CLUTCHES BURNED. REPLACED 4TH GEAR CLUTCHES AND RESET SNAP RING CLEARANCE. INSP 2ND BRAKE PISTON AND REPLACED O-RINGS. REMOVED VALVE BODY. INSP AND FOUND CHECK BALL WEARING THROUGH SEPARATOR PLATE. REPLACED VALVE BODY SEPARATOR PLATE. REPLACE SEAL FROM VALVE BODY TO 2ND BRAKE. I PICKED UP MY VEHICLE 6/27/03. AFTER DRIVING FOR ONE DAY, I AM EXPERIENCING THE SAME PROBLEMS. MY CONCERN IS THAT THIS IS A SAFETY HAZARD. WHEN TRYING TO GET ONTO A FREEWAY AND/OR MANUEVERING THROUGH IN TOWN TRAFFIC, THIS VEHICLE IS POSING A HAZARD FOR MYSELF AND/OR OTHER DRIVERS. I WILL RETURN THE VEHICLE TO THE DEALER AS SOON AS I DETERMINE WHAT MY OPTIONS ARE. PLEASE FEEL FREE TO CONTACT ME IF THERE ARE ANY QUESTIONS OR TO LET ME KNOW IF I NEED TO REPORT THIS TO ANOTHER AGENCY. THANKS. *AK
Official recalls
204V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
03V442000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 4, 2003
ON CERTAIN PASSENGER VEHICLES, THE FUEL RETURN LINE HOSE FITTING ON THE ELECTRIC FUEL PUMP MAY BE RESTRICTED, CAUSING EXCESSIVE FUEL PRESSURE TO BUILD UP IN THE FUEL INJECTION SYSTEM. EXCESSIVE FUEL PRESSURE MAY RESULT IN A LEAK IN THE FUEL RETURN HOSE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP PRESSURE. THOSE VEHICLES EXHIBITING HIGHER THAN NORMAL FUEL PUMP PRESSURE WILL RECEIVE FUEL PUMP MODIFICATIONS. THE RECALL BEGAN DECEMBER 3, 2003. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-800-981-0452.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08011 · Passenger Door Fire
Opened Jul 1, 2008 · Closed Aug 21, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Visibility; Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Additional source detail variants (5)
Electrical System
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:fuses And Circuit Breakers
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:interior/under Dash
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
PE08014 · Passenger Door Fire
Opened Mar 4, 2008 · Closed Jul 1, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash; Visibility; Visibility:glass, Side/rear; Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Additional source detail variants (6)
Electrical System
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring:interior/under Dash
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:glass, Side/rear
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.