IllustrationSON WAS DRIVING HOME FROM COLLEGE AND THE PASSENGER SIDE DOOR CAUGHT ON FIRE AS HE WAS LEAVING THE PARKING LOT. HE IMMEDIATELY PULLED OVER AND PUT OUT THE FIRE BURNING THE TIPS OF HIS FINGERS. *TR
2002 Mitsubishi Galant
Owner reports · Recalls · Investigations
More warning signs than most Galant years
Owner complaints for the 2002 Mitsubishi Galant are substantially higher than the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all Galant years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
1725–50K
1450–75K
1475–100K
16100–150K
1150K+
77 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports10 fire reports15 injury reports
Electrical System complaints
26 reports18 DEMEITS ? HORN NOT WORKING REPOLLED NO REASON BAD VIN# CAR TURNED OFF LO-JACK. *TR
TWO WEEKS AGO OUR CARS? PASSENGER FRONT PANEL STARTED TO SMOKE WITHIN A FEW MINUTES THE ENGINE WAS STARTED. AT THE TIME IT HAPPENED WE DID NOT KNOW WHERE THE SMOKE WAS COMING FROM. WHEN I WENT TO GET CLOSER TO THE SMOKE IT WAS THE PANEL WHERE THE WINDOW AND DOOR BUTTONS ARE. THE SECURITY GUARD IN OUR BUILDING HAD A FLASHLIGHT A…
Read full complaint
TWO WEEKS AGO OUR CARS? PASSENGER FRONT PANEL STARTED TO SMOKE WITHIN A FEW MINUTES THE ENGINE WAS STARTED. AT THE TIME IT HAPPENED WE DID NOT KNOW WHERE THE SMOKE WAS COMING FROM. WHEN I WENT TO GET CLOSER TO THE SMOKE IT WAS THE PANEL WHERE THE WINDOW AND DOOR BUTTONS ARE. THE SECURITY GUARD IN OUR BUILDING HAD A FLASHLIGHT AND SAW THE TOP PART OF THE PANEL WAS MELTING, HE WAS ABLE TO LIFT THE MELTING PLASTIC AND INSIDE THE DOOR THE SMOKE AND FLAMES WERE. THE FIRE EXTINGUISHED AND WE PULLED THE FUSE. NOW WE HAVE NO POWER WINDOWS ON ALL SO WE ARE DRIVING WITHOUT THE ABILITY OF OPENING THE WINDOWS. THANK GOD WE WERE NOT ON THE HIGHWAY WHEN IT STARTED. I CALLED MITSUBISHI AND THEY TOLD ME THERE WERE NO RECALLS FOR THIS PROBLEM YET ON YOUR SITE THERE WERE TWO OTHERS WITH THE SAME PROBLEM. SINCE IT?S PASSED THE WARRANTY TIME THEY ARE NOT RESPONSIBLE TO PAY FOR THE DAMAGES. I DO UNDERSTAND THE INSURANCE COMPANY WILL PAY FOR IT BUT SINCE I HAVE A DEDUCTIBLE OF $500 I MUST PAY FOR IT. MITSUBISHI CUSTOMER SERVICE SAID IF THE INSURANCE COMPANY FINDS THE PIECE TO BE A DEFECT, THEY WOULD NEED TO PUT IN A CLAIM FOR IT. I DON?T UNDERSTAND WHY A CAR OF ONLY 5 YEARS OLD HAD THIS PROBLEM. I ALSO HAVE OTHER PROBLEMS TO MENTION SINCE WHEN I LOOKED AT THIS SITE I TOO HAVE A PROBLEM WITH CLICKING SOUND WHEN I PUT ON THE HEATER. SOMETIMES THE HEATER DOESN?T WORK. THIS COULD HAVE BEEN A TRAGIC SITUATION. DOES SOMEONE HAVE TO DIE FOR THESE PROBLEMS TO GET FIXED. I AM NOW WORRY SINCE I ALSO HAVE ANOTHER CAR THE SAME MAKE , MODEL AND YEAR. PLEASE INFORM ME WHAT ELSE I NEED TO DO TO SOLVE THIS PROBLEM. THANK YOU.*CN
AIR CONDITION/ HEAT (BLUE- RED) DIAL MAKES CLIKING SOUND WHEN TURNING FROM BLUE TO RED AND SOME TIMES DOES NOT ALLOW WARM AIR TO HEAT THE CAR. *AK
2002 MITSUBISHI GALANT 3.0 V6, HEATER CONTROL MOTOR FAILED AFTER ONLY 5 YEARS OF SERVICE. ALSO, SPEEDOMETER WAS CONSISTANTLY 4 MPH FAS, ALWAYS HAS BEEN. *AK
RESPONDED TO A VEHICLE FIRE IN A 2002 MITSUBISHI, GALANT ON MARCH 22, 2007. THERE IS NO POSSIBLE CAUSE OF THIS FIRE BUT FROM THE OUTSTANDING RECALL FOR THE WIRING UNDER THE HOOD, RECALL NUMBER NHTSA 02V147000. IT HAD NOT BEEN DRIVEN FOR THREE HOURS AND THE AREA OF ORIGIN, IS UNDER THE HOOD INVOLVING THE BATTERY AND WIRING.
IN DEC OF 2004 FOUND A PROBLEM WHILE THE VEHICLE WAS UNDER WARRANTY. THE PROBLEM IS WHEN THE READING LAMP IS ACTIVATED WITH THE VEHICLE DOOR OPEN A SHORT CIRCUIT APPEARS WHICH CAUSES THE FUSE TO BLOW. *JB
DT*: THE CONTACT STATED THE VEHICLE' S TAIL LIGHT AND TURN SIGNAL STOPPED OPERATING. THESE FAILURES WERE NOT INCLUDED IN THE RECALL FOR THE ELECTRICAL SYSTEM (02V147000). THE VEHICLE WAS NOT TAKEN TO A DEALER. THE CONTACT WAS USING DEDUCTIVE REASONING TO ASSUME THE PROBLEMS WITH THE VEHICLE MUST HAVE AN ELECTRICAL ISSUE. UPD…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE' S TAIL LIGHT AND TURN SIGNAL STOPPED OPERATING. THESE FAILURES WERE NOT INCLUDED IN THE RECALL FOR THE ELECTRICAL SYSTEM (02V147000). THE VEHICLE WAS NOT TAKEN TO A DEALER. THE CONTACT WAS USING DEDUCTIVE REASONING TO ASSUME THE PROBLEMS WITH THE VEHICLE MUST HAVE AN ELECTRICAL ISSUE. UPDATED 10/3/2006 - THE CONSUMER WAS ABLE TO DETERMINE THAT EH PROBLEM WAS NOT WITH THE BULBS OR FUSES. THE REPLACEMENT FUSES WOULD BLOW IMMEDIATELY. *NM UPDATED 12/15/2006 - RECALL 02V147000: WIRING HARNESS ABRASION INDICATED THAT ON CERTAIN PASSENGER VEHICLES, THE ROUTING OF THE VEHICLE'S FRONT WIRING HARNESS COULD ALLOW IT TO COME IN CONTACT WITH A ROUGH EDGE, CAUSING ABRASION.
2002 MITSUBISHI GALANT PASSENGER SIDE DOOR CAUGHT ON FIRE LOCKING THE WINDOWS AND DOORS. *KB WHEN THE FIRE ERUPTED IT BURNED THE RIGHT LEG OF THE PASSENGER. THE PASSENGER ALSO SPRAINED HER RIGHT ANKLE TRYING TO BREAK OUT THE WINDOW. *NM
DT: THE CONTACT STATED WHILE DRIVING NOTICED SMOKE COMING FROM UNDERNEATH THE FRONT RIGHT PANEL. AFTER HE PULLED OVER AND EXITED THE VEHICLE A FIRE ERUPTED FROM THE FRONT RIGHT PASSENGER DOOR PANEL. THE CONTACT SAID IT LOOKED LIKE A WIRE SHORTED OUT WHICH CAUSED THE SPEAKER TO CATCH ON FIRE. UPON INSPECTION BY THE DEALER,…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING NOTICED SMOKE COMING FROM UNDERNEATH THE FRONT RIGHT PANEL. AFTER HE PULLED OVER AND EXITED THE VEHICLE A FIRE ERUPTED FROM THE FRONT RIGHT PASSENGER DOOR PANEL. THE CONTACT SAID IT LOOKED LIKE A WIRE SHORTED OUT WHICH CAUSED THE SPEAKER TO CATCH ON FIRE. UPON INSPECTION BY THE DEALER, THEY CONCLUDED THE FIRE WAS CAUSE BY A SHORT IN THE WIRING. *AK
Official recalls
204V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
02V147000 · Electrical System:wiring:front Underhood
May 29, 2002
ON CERTAIN PASSENGER VEHICLES, ROUTING OF THE VEHICLE'S FRONT HARNESS CAN ALLOW IT TO COME IN CONTACT WITH A ROUGH EDGE, ALLOWING ABRASION. THIS COULD RESULT IN GROUNDED CIRCUITS.
Consequence & remedy
Consequence: THERE COULD BE A LOSS OF STOP OR TURN SIGNAL LAMP OPERATION OR ENGINE HESITATION.
Remedy: DEALERS WILL INSTALL A PROTECTOR, ELIMINATING ANY HARNESS CONTACT. OWNER NOTIFICATION BEGAN JULY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08011 · Passenger Door Fire
Opened Jul 1, 2008 · Closed Aug 21, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Visibility; Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Additional source detail variants (5)
Electrical System
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:fuses And Circuit Breakers
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:interior/under Dash
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
PE08014 · Passenger Door Fire
Opened Mar 4, 2008 · Closed Jul 1, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash; Visibility; Visibility:glass, Side/rear; Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Additional source detail variants (6)
Electrical System
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring:interior/under Dash
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:glass, Side/rear
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.