IllustrationTRANSMISSION GOES OUT IN MIDDLE OF HIGHWAY HAD TO PUSH CAR TO SAFETY AND WAS ALMOST RUN OVER NO WARNING THIS WAS GONNA DO THIS.
1992 Mitsubishi Expo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 41 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports2 injury reports
Power Train complaints
6 reportsTHIS IS THE SECOND TIME THE TRANSMISSION HAS HAD TO BE REPLACED SINCE 1992 WHEN THE AUTOMOBILE WAS PURCHASED. IN BOTH CASES WE WERE TOLD THE TRANSMISSION WAS DAMAGED DUE TO INSUFFICIENT LUBRICATION. NEITHER WERE COVERED UNDER WARRANTY AND DUE TO THIS BEING A REAR WHEEL DRIVE VEHICLE WE WERE NOT INFORMED OF THE RECALL.
THERE IS A CURRENT RECALL #98V168002 DESCRIBING THE VERY SIMILAR SYMPTOMS, NAMELY LOCKUP DUE TO INSUFFICIENT LUBRICATION CAUSED BY EXCESSIVE PARTS WEAR. ACCORDING TO THE MANUFACTURER, THE RECALL DOES NOT COVER MY VIN EVEN THOUGH THE VEHICLE YEAR AND THE MODELS ARE IDENTICAL. ALSO THE NUMBER OF THE UNITS POTENTIALLY AFFECTED EXCE…
Read full complaint
THERE IS A CURRENT RECALL #98V168002 DESCRIBING THE VERY SIMILAR SYMPTOMS, NAMELY LOCKUP DUE TO INSUFFICIENT LUBRICATION CAUSED BY EXCESSIVE PARTS WEAR. ACCORDING TO THE MANUFACTURER, THE RECALL DOES NOT COVER MY VIN EVEN THOUGH THE VEHICLE YEAR AND THE MODELS ARE IDENTICAL. ALSO THE NUMBER OF THE UNITS POTENTIALLY AFFECTED EXCEEDS 9500. IT IS MY OPINION THAT DUE TO THE EXTREMELY DANGEROUS NATURE OF THE DEFECT, POTENTIAL LOCKUP AT FREEWAY SPEEDS, THE RECALL HAS TO BE EXPANDED. *AK
REPLACED TRANSMISSION 1997/GONE AGAIN 1999
AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR CONTINUALLY NUMEROUS REPAIRS PRIOR TO COMPLETE FAILURE.
AT 20,000 MILES THE CLUTCH NEEDED TO BE REPLACED AND TRUCK IS AT 38,000 AND CLUTCH NEEDS TO BE REPLACED AGAIN. PLEASE DESCRIBE . *AK
Official recalls
298V168000 · Power Train:automatic Transmission
Jul 22, 1998
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
97V063001 · Latches/locks/linkages:doors:latch
Apr 18, 1997
EXCESS LUBRICATION CAN CAUSE THE RUBBER DOOR LATCH SWITCH COVER TO DEFORM, AND THE DOOR LATCH SWITCH TO MALFUNCTION, SO THAT THE SHOULDER BELT ANCHORAGE WOULD REMAIN AT THE A-PILLAR WHEN THE DOOR WAS CLOSED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE DOOR LATCH SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA98002 · Transfer Case Lockup
Opened Jan 30, 1998 · Closed Apr 30, 1998
Status: closed (inferred from source dates) · Wheels
No summary supplied.
Additional source detail variants (2)
Wheels
Wheels