IllustrationTHERE IS A CONSTANT FUEL / GASOLINE SMELL IN MY CAR AND OUTSIDE THE VEHICLE. NO VISIBLE LEAKS. THE SMELL IS CONSTANT.
2006 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2006 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
3825–50K
5350–75K
2475–100K
17100–150K
2150K+
161 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports9 fire reports6 injury reports
Fuel/propulsion System complaints
4 reportsTL* THE CONTACT OWNS A 2006 MINI COOPER S. WHILE DRIVING 65 MPH, THE FUEL SENSOR GAUGE MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE RAN OUT OF FUEL, BUT THE GAUGE INDICATED THAT THERE WAS 74 MILES LEFT IN THE FUEL TANK. TEMPE MINI, LOCATED AT 7855 SOUTH TEST DRIVE, TEMPE, ARIZONA 85284, WAS MADE AWARE OF THE FAILURE AND ST…
Read full complaint
TL* THE CONTACT OWNS A 2006 MINI COOPER S. WHILE DRIVING 65 MPH, THE FUEL SENSOR GAUGE MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE RAN OUT OF FUEL, BUT THE GAUGE INDICATED THAT THERE WAS 74 MILES LEFT IN THE FUEL TANK. TEMPE MINI, LOCATED AT 7855 SOUTH TEST DRIVE, TEMPE, ARIZONA 85284, WAS MADE AWARE OF THE FAILURE AND STATED THAT THE FUEL PUMP, FUEL HOUSING, AND FUEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000. THE VIN WAS NOT AVAILABLE.
BLUE BLACK SMOKE FROM FRONT GRILL OF WARM (20 MILES) DRIVEN CAR. CAR WAS OFF AND PARKED IN HIGHWAY 40 MCDONALDS RESTAURANT PARKING LOT NEXT TO A 10,000 GALLON HEATING FUEL TANK. PARKER FUEL COMPANY EMPLOYEES PUT OUT THE FIRE IN THE ENGINE COMPARTMENT JUST BELOW THE ENGINE. NOTE THE BATTERY WAS DISCONNECTED IMMEDIATELY BEFORE OP…
Read full complaint
BLUE BLACK SMOKE FROM FRONT GRILL OF WARM (20 MILES) DRIVEN CAR. CAR WAS OFF AND PARKED IN HIGHWAY 40 MCDONALDS RESTAURANT PARKING LOT NEXT TO A 10,000 GALLON HEATING FUEL TANK. PARKER FUEL COMPANY EMPLOYEES PUT OUT THE FIRE IN THE ENGINE COMPARTMENT JUST BELOW THE ENGINE. NOTE THE BATTERY WAS DISCONNECTED IMMEDIATELY BEFORE OPENING THE BONNET/HOOD AT WHICH TIME THE SMOKE AND VISIBLE FLAME WAS EXTINGUISHED 5 TIMES VIA 1 SMALL (DEPLETED) AND 3 TIMES ENDING VIA A 2ND LARGER PARKER FUEL COMPANY UNIT. HOWARD COUNTY FIRE AND POLICE VEHICLES ARRIVED AFTER FIRE HAD ENDED. CAR SEEMED NORMAL OVER 20 MILE PORTION OF TRIP ON HIGHWAY 70 + 40 @ 70 + 55 MPH SPEEDS. FLAME COULD BE VIEWED ORIGINATING UNDER ENGINE WHEN LOOKING DOWNWARD IN SPACE BETWEEN ENGINE AND FIREWALL BELOW EXHAUST MANIFOLD. NOT SURE IF FIRE WAS FROM POWER STEERING PUMP DRIVE (ELECTRIC MOTOR), POWER STEERING HOSE(S), PS FAN OR COMPROMISED OIL PUMP VOLUME CONTROL SOLENOID VALVE LEAKING OIL ON VERY HOT SUPERCHARGED ENGINE EXHAUST. I WAS VERY LUCKY THAT THE 4 MINUTES I WAS INSIDE MCDONALDS ,THAT MULTIPLE PARKER FUEL COMPANY EMPLOYEES ARRIVING TO WORK HAD SEEN THE SMOKE AND HAD MULTIPLE FIRE EXTINGUISHERS AND TRAINING TO PUT OUT FIRES. MY CAR WOULD HAVE COMPLETELY BURNED UP IN THE TIME IT WOULD HAVE TAKEN THE FIRE DEPT TO ARRIVE. THE 1ST PARKER FUEL COMPANY EMPLOYEE WAS ALREADY AT MY CAR WITH PLIERS TO DISCONNECT THE BATTERY AS HE KNEW IT WAS NOT STEAM FROM A RADIATOR, BUT BLACK SMOKE FROM A ELECTRICAL, GAS, OIL OR RUBBER/PLASTIC SOURCES BEING DIFFICULT TO EXTINGUISH. *TR
AS I TURN ON THE ENGINE, BATTERY LIGHT CAME ON, 5 SECONDS LATER, ENGINE STARTED TO SMOKE. I TURNED OFF THE ENGINE. ENGINE WON'T TURN BACK ON AND LOST ALL POWER, STEERING WHEEL WON'T TURN. BEFORE THIS INCIDENT, GEAR WOULD SHIFT UP AND DOWN ON IT'S OWN WHILE I'M DRIVING. VERY DANGEROUS! *TR
Official recalls
115V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.