IllustrationPOWER STEERING ASSIST FAILED TO OPERATE WITHOUT WARNING WHILE I WAS PARKING THE CAR, MINI COOPER S 2005 MODEL YEAR. THERE WAS NO SERVICE LIGHT OR ANY OTHER WARNING BEFORE THE FAILURE OCCURRED.
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
Steering complaints
212 reportsNOTICED A WHIRRING NOISE FROM THE ENGINE COMPARTMENT. THEN SUDDENLY THE STEERING BECAME DIFFICULT LIKELY DUE TO POWER STEERING PUMP FAILURE. LOOKED UP POSSIBLE ISSUES ON LINE AND NOTICED THAT OTHER FOLKS HAD VERY SIMILAR EXPERIENCES.
POWER STEERING APPEARS TO NOT BE WORKING. POWER IN THE VEHICLE IS INTERRUPTED AT LOW SPEEDS AFTER DRIVING THE VEHICLE FOR A BRIEF PERIOD OF TIME. SYMPTOMS OF THIS BEGAN OCCURRING OVER THREE MONTHS AGO WITH THE BATTERY OF THE CAR BEING DRAINED AFTER SITTING FOR A PERIOD OF 4 DAYS OR MORE. ALL RELAYS AND FUSES HAVE BEEN CHECKED…
Read full complaint
POWER STEERING APPEARS TO NOT BE WORKING. POWER IN THE VEHICLE IS INTERRUPTED AT LOW SPEEDS AFTER DRIVING THE VEHICLE FOR A BRIEF PERIOD OF TIME. SYMPTOMS OF THIS BEGAN OCCURRING OVER THREE MONTHS AGO WITH THE BATTERY OF THE CAR BEING DRAINED AFTER SITTING FOR A PERIOD OF 4 DAYS OR MORE. ALL RELAYS AND FUSES HAVE BEEN CHECKED. THE POWER STEERING PUMP COOLING FAN WAS FOUND TO HAVE BEEN INOPERATIVE AND WAS REMOVED, CLEANED AND REINSTALLED APPROXIMATELY 2 WEEKS AGO.
I HAVE A 2005 MINI COOPER S WITH 51,000 MILES ON IT. I RECENTLY HAD TO REPLACE THE LOWER CONTROL ARM BUSHINGS AND HAVE HAD A CREAK IN MY STEERING COLUMN THAT IS GETTING WORSE. LAST MONTH, I FIRST EXPERIENCED COMPLETE LACK OF POWER STEERING. THE CAR CORRECTED ITSELF AND WORKED PROPERLY UNTIL A FEW INTERMITTENT OCCASIONS THIS WEEK…
Read full complaint
I HAVE A 2005 MINI COOPER S WITH 51,000 MILES ON IT. I RECENTLY HAD TO REPLACE THE LOWER CONTROL ARM BUSHINGS AND HAVE HAD A CREAK IN MY STEERING COLUMN THAT IS GETTING WORSE. LAST MONTH, I FIRST EXPERIENCED COMPLETE LACK OF POWER STEERING. THE CAR CORRECTED ITSELF AND WORKED PROPERLY UNTIL A FEW INTERMITTENT OCCASIONS THIS WEEK. TURNING OFF THE CAR AND TURNING IT BACK ON SEEM TO TEMPORARILY CORRECT THE LACK OF POWER STEERING. HOWEVER, IT IS VERY TEMPORARY. WHILE DRIVING, I CAN FEEL THE STEERING RESPONSE CHANGE ON/OFF DUE TO LACK OF POWER STEERING CONTROL. WHEN THE POWER STEERING FAILS, THE WHEEL IS VERY DIFFICULT TO TURN. IT FEELS LIKE A 1961 CHEVY TRUCK WITH A 350 V8. IT IS NEARLY IMPOSSIBLE TO STEER THE CAR FROM A DEAD STOP MAKING PARKING EXTREMELY DIFFICULT. I AM BEING FORCED TO DRIVE BELOW THE SPEED LIMIT TO LIMIT MY LIABILITY IN CORNERS AND TURNS, ESPECIALLY ON THE INTERSTATE. I AM SETTING UP AN APPOINTMENT WITH MY LOCAL MINI DEALER TO ADDRESS AND CORRECT THE FAILURE. I UNDERSTAND THIS IS UNDER INVESTIGATION BY NHTSA, BUT I CANNOT WAIT TO HAVE THE REPAIR. I AM BEWILDERED AS TO WHY THERE HASN'T BEEN A RECALL YET. IT IS UNACCEPTABLE THAT A VEHICLE'S STEERING SYSTEM CAN FAIL AFTER VERY LITTLE MILES. MINI NEEDS TO BE HELD ACCOUNTABLE FOR THIS PROBLEM. *TR
MY 2005 MINI COOPER S SUDDENLY LOST POWER STEERING AS I WAS DRIVING ALMOST CAUSING AN ACCIDENT. I'VE NOT HAD IT IN FOR REPAIRS YET, BUT RESEARCHING ON THE INTERNET IT SEEMS MANY CONSUMERS HAVE HAD THE SAME PROBLEM. I HAVE EVEN READ OF THOSE WHOSE CAR CAUGHT ON FIRE AND AM FEARFUL OF THE SAME HAPPENING TO ME NOT TO MENTION THE …
Read full complaint
MY 2005 MINI COOPER S SUDDENLY LOST POWER STEERING AS I WAS DRIVING ALMOST CAUSING AN ACCIDENT. I'VE NOT HAD IT IN FOR REPAIRS YET, BUT RESEARCHING ON THE INTERNET IT SEEMS MANY CONSUMERS HAVE HAD THE SAME PROBLEM. I HAVE EVEN READ OF THOSE WHOSE CAR CAUGHT ON FIRE AND AM FEARFUL OF THE SAME HAPPENING TO ME NOT TO MENTION THE EXTREMELY HIGH COST OF REPAIR. MINI SHOULD RECALL THE 2005 AND FIX THIS ISSUE. *TR
I HAVE AN 05 MINI COOPER S AND THE POWER STEERING PUMP IS DEFECTIVE ALONG WITH 80,000+ OTHERS. I AM ROUGHLY AROUND 90,000 MILES AND THE PUMP HAS JUST RECENTLY STARED GOING OUT DUE TO WHAT THE DEALERSHIP CALLED A "DEFECTIVE LEAK ON THE ACTUALLY BODY OF THE PUMP". I ASKED THEM WHAT I SHOULD DO AND THEY WANTED TO CHARGE ME $1100 TO…
Read full complaint
I HAVE AN 05 MINI COOPER S AND THE POWER STEERING PUMP IS DEFECTIVE ALONG WITH 80,000+ OTHERS. I AM ROUGHLY AROUND 90,000 MILES AND THE PUMP HAS JUST RECENTLY STARED GOING OUT DUE TO WHAT THE DEALERSHIP CALLED A "DEFECTIVE LEAK ON THE ACTUALLY BODY OF THE PUMP". I ASKED THEM WHAT I SHOULD DO AND THEY WANTED TO CHARGE ME $1100 TO "FIX IT" BUT SAID THAT IT COULD GO OUT AND FAIL AT ANYTIME WHILE I AM DRIVING. THIS IS A SERIOUS ISSUE BECAUSE MY WIFE WOULD NOT BE ABLE TO CONTROL THE CAR IF IT COULD GO OUT AT ANYTIME? THEY ALSO SAID THAT THIS WAS A VERY COMMON PROBLEM IN 04/05 MINI COOPERS. I REALLY WISH SOMEBODY WOULD MAKE THEM RECALL THIS POTENTIAL LIFE THREATENING PROBLEM WITHOUT CHARGING US $1100 FOR THEIR MISTAKE IN DESIGNING/INSTALLING THE POWER STEERING PUMPS??? *TR
MULTIPLE POWER STEERING FAILURES. INITIALLY WHEN DRIVING FOR MORE THAN 1 HOUR, NOW (JAN. 2011) OFTEN GOES OUT WHEN DRIVING MORE THAN 10 MINUTES. SOMETIMES COMES/GOES DURING A TURN. EXTREMELY DIFFICULT TO HANDLE WHEN CORNERING IN THE CITY OR PARALLEL PARKING.
ON 1/14/11 WHILE DRIVING MY CAR ON A HIGHWAY MY STEERING WHEEL TIGHTENED UP AND MADE STEERING IMPOSSIBLE. I WAS ABLE TO GET BACK TO MY DRIVEWAY. IT DIDN'T HAPPEN AGAIN UNTIL 1/16/11 AND THEN 1/20/11, ALL WHILE DRIVING MY CAR AT DIFFERENT SPEEDS, ALSO WHILE TRYING TO BACK INTO MY DRIVEWAY. IT HAPPENS WITH ABSOLUTELY NO WARNING. N…
Read full complaint
ON 1/14/11 WHILE DRIVING MY CAR ON A HIGHWAY MY STEERING WHEEL TIGHTENED UP AND MADE STEERING IMPOSSIBLE. I WAS ABLE TO GET BACK TO MY DRIVEWAY. IT DIDN'T HAPPEN AGAIN UNTIL 1/16/11 AND THEN 1/20/11, ALL WHILE DRIVING MY CAR AT DIFFERENT SPEEDS, ALSO WHILE TRYING TO BACK INTO MY DRIVEWAY. IT HAPPENS WITH ABSOLUTELY NO WARNING. NO WARNING LIGHTS OR NOTIFICATION FROM THE MINI COMPUTER SYSTEM HAS ALERTED ME. *TR
POWER STEERING SUDDENLY FAILED WHILE DRIVING AND THE VEHICLE BECAME VERY DIFFICULT TO STEER AT ALL SPEEDS. UPDATED VIN. 02/22/11. *TR
INTERMITTENT POWER STEERING LOSS RESULTING IN SEVERAL COMPLAINTS TO DEALER. DEALER PROVIDED NO WORKING RESOLUTION. POWER STEERING LOSS IN THIS VEHICLE MADE STEERING VERY DIFFICULT AND RESULTED IN EXCESSIVELY DANGEROUS DRIVING CONDITIONS. POWER PUMP FINALLY FAILED AND NEEDED TO BE REPLACED. *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).