IllustrationPASSENGER AIRBAG OFF LIGHT ILLUMINATED. *TR
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
Air Bags complaints
71 reportsI HAVE A 2005 MINI COOPER S WITH 60,000 MILES ON IT AND ABOUT 55,000 MILES THE AIRBAG WARNING LAMP AND PASSENGER AIRBAG OFF LAMP ILLUMINATED INTERMITTENTLY. AT 58,000 MILES IT HAS STAYED ON CONSTANTLY. AFTER RESEARCHING THE ISSUE I TOOK THE CAR TO A TRUSTED MECHANIC AND HE DIAGNOSED THAT THE WEIGHT SENSOR PAD IN THE SEAT CUSHION…
Read full complaint
I HAVE A 2005 MINI COOPER S WITH 60,000 MILES ON IT AND ABOUT 55,000 MILES THE AIRBAG WARNING LAMP AND PASSENGER AIRBAG OFF LAMP ILLUMINATED INTERMITTENTLY. AT 58,000 MILES IT HAS STAYED ON CONSTANTLY. AFTER RESEARCHING THE ISSUE I TOOK THE CAR TO A TRUSTED MECHANIC AND HE DIAGNOSED THAT THE WEIGHT SENSOR PAD IN THE SEAT CUSHION IS DEFECTIVE AND WOULD REQUIRE THE CAR TO GO TO THE DEALER TO BE REPLACED. I FEEL THAT THIS IS A SAFETY ISSUE AND THE DEALER SHOULD ISSUE A RECALL ON THE VEHICLE SINCE IT IS A WELL KNOWN PROBLEM. I HAVE ATTEMPTED TO CONTACT MINIUSA BY EMAIL AND HAVE BEEN WAITING OVER A WEEK FOR A RESPONSE. *LN
I HAVE A 2005 MINI COOPER. THE AIRBAG SENSOR IN THE PASSENGER SEAT FAILED AROUND 50,000 MILES. I WAS TOLD THAT THE PASSENGER SEAT HAD TO BE REPLACED AT A COST OF $1400.00. THIS IS A KNOW ISSUE WITH THIS YEAR OF MINI COOPER S. DEALSHIPS NEED TO BE AWARE OF THIS PROBLEM AND MINI/BMW NEEDS TO HAVE A RECALL. *TR
THE AIRBAG SENSOR LIGHT ON THE CENTER DASHBOARD AND "AIRBAG OFF" LIGHT ABOVE THE REAR VIEW MIRROR TURN ON WHEN A PASSENGER IS IN THE CAR. IT APPEARS AS THE PASSENGER AIRBAG SENSOR IS FAILING TO PROPERLY DETECT THE PASSENGER'S WEIGHT. *TR
THE RED AIRBAG WARNING LIGHT IN THE SPEEDOMETER AREA CAME ON AT APPROXIMATELY 99,450 MILES. IT CAME ON AFTER DRIVING ACROSS A CITY RAILROAD CROSSING AT LOW SPEED. I TOOK THE VEHICLE TO THE DEALER AND ASKED ABOUT THE LIGHT, AND THEY INDICATED THAT IT WOULD REQUIRE ADDITIONAL INVESTIGATION BUT COULD BE A FAULTY SEAT SENSOR WHI…
Read full complaint
THE RED AIRBAG WARNING LIGHT IN THE SPEEDOMETER AREA CAME ON AT APPROXIMATELY 99,450 MILES. IT CAME ON AFTER DRIVING ACROSS A CITY RAILROAD CROSSING AT LOW SPEED. I TOOK THE VEHICLE TO THE DEALER AND ASKED ABOUT THE LIGHT, AND THEY INDICATED THAT IT WOULD REQUIRE ADDITIONAL INVESTIGATION BUT COULD BE A FAULTY SEAT SENSOR WHICH WOULD COST APPROXIMATELY $1250 TO REPLACE. THEY ALSO INDICATED THAT THEY WERE NOT SURE WHETHER OR NOT THE AIRBAGS WOULD DEPLOY PROPERLY IN THE EVENT OF AN ACCIDENT. FURTHER RESEARCH INDICATES THAT THIS MODEL AND YEAR MAY ALSO HAVE PROBLEMS WITH THE WIRING HARNESSES AND CONNECTIONS, AND THAT ONLY THE DEALER CAN RESET THE WARNING LIGHT. AS OF DECEMBER 2 2010 THE VEHICLE HAS 113,000 MILES ON IT AND THE WARNING LIGHT IS STILL ON. I BELIEVE THIS IS A SAFETY RELATED ISSUE THAT SHOULD BE ADDRESSED BY THE DEALER AS A WARRANTY ISSUE AS I AM NOT COMFORTABLE WITH THE CURRENT SITUATION BUT DO NOT WANT TO PAY FOR AN EXPENSIVE SAFETY RELATED DEFECT. I AM THE ORIGINAL OWNER OF THE VEHICLE AND STILL HAVE IT. THANKS. *TR
THE AIR BAG LIGHT COMES ON FOR NO REASON. THIS HAS BEEN HAPPENING SINCE I GOT THE CAR AND I READ THAT IT HAD TO DO WITH PUTTING BAGS ON THE SEAT. I LATER DISCOVERED THAT IT DOES NOT MATTER IF THERE IS A BAG, A PERSON OR AN EMPTY PASSENGER SEAT. *TR
THE SRS LIGHT WAS ON AND WOULDN'T GO OUT. THE DEALER CHECKED IT AND SAID THAT THE PASSENGER SEAT MAT IS DEFECTIVE AND IT WAS A HARD FAULT WHICH PREVENTS THE AIR BAG FROM WORKING. THE LIGHT SOMETIMES GOES OUT BUT USUALLY STAYS ON. THEY WOULD NOT WARRANTY THIS AND WANTED $1330 TO REPAIR IT. THE PASSENGER SEAT HAS PROBABLY ONLY…
Read full complaint
THE SRS LIGHT WAS ON AND WOULDN'T GO OUT. THE DEALER CHECKED IT AND SAID THAT THE PASSENGER SEAT MAT IS DEFECTIVE AND IT WAS A HARD FAULT WHICH PREVENTS THE AIR BAG FROM WORKING. THE LIGHT SOMETIMES GOES OUT BUT USUALLY STAYS ON. THEY WOULD NOT WARRANTY THIS AND WANTED $1330 TO REPAIR IT. THE PASSENGER SEAT HAS PROBABLY ONLY BEEN SAT IN 10% OF THE TIME. *TR
I HAVE A 2005 MINI COOPER. THE AIRBAG SENSOR IN THE PASSENGER SEAT FAILED AROUND 66,000 MILES. I WAS TOLD THAT THE PASSENGER SEAT AIRBAG AND BOTH DOOR SENSORS HAD TO BE REPLACED ALONG WITH THE BATTERY CABLE AT A COST OF $4000.00. SOUNDS AS IF BMW STILL HAS REAL ELECTRICAL PROBLEMS IN THEIR CARS AND ARE STICKING IT TO CONSUMERS…
Read full complaint
I HAVE A 2005 MINI COOPER. THE AIRBAG SENSOR IN THE PASSENGER SEAT FAILED AROUND 66,000 MILES. I WAS TOLD THAT THE PASSENGER SEAT AIRBAG AND BOTH DOOR SENSORS HAD TO BE REPLACED ALONG WITH THE BATTERY CABLE AT A COST OF $4000.00. SOUNDS AS IF BMW STILL HAS REAL ELECTRICAL PROBLEMS IN THEIR CARS AND ARE STICKING IT TO CONSUMERS TO FIX IT INSTEAD OF FIXING THESE PROBLEMS THEMSELVES. THE CAR HAS NEVER BEEN INVOLVED IN ANY ACCIDENT. *TR
ON 2005 MINI COOPER S WITH 13,000 MILES THE PASSENGER AIRBAG WARNING LIGHT CAME ON. MINI DIAGNOSED REASON AS FAILURE OF THE SENSOR IN THE PASSENGER SEAT, WHICH WOULD REQUIRE $1100 REPAIR. MINI WILL NOT FIX BECAUSE CAR IS OUT OF WARRANTY. MINI DID NOT STATE WHETHER THE AIRBAG WILL OR WILL NOT FUNCTION. PASSENGER SEAT HAS RARE…
Read full complaint
ON 2005 MINI COOPER S WITH 13,000 MILES THE PASSENGER AIRBAG WARNING LIGHT CAME ON. MINI DIAGNOSED REASON AS FAILURE OF THE SENSOR IN THE PASSENGER SEAT, WHICH WOULD REQUIRE $1100 REPAIR. MINI WILL NOT FIX BECAUSE CAR IS OUT OF WARRANTY. MINI DID NOT STATE WHETHER THE AIRBAG WILL OR WILL NOT FUNCTION. PASSENGER SEAT HAS RARELY BEEN USED. MINI DENIES RESPONSIBILITY. *TR
THE AIRBAG LIGHT IS ON AND THE PASSENGER SEAT AIRBAG DETECTION LIGHT SAYS OFF EVEN WHEN AN ADULT IS SITTING IN THE SEAT. I TOOK THE CAR IN AND THE AIRBAG CODE READ WAS A 71 INDICATING THAT THE OC3 MAT IN THE PASSENGER SEAT IS FAULTING. THE DEALERSHIP IS TELLING ME THAT THE AIRBAG MAY OR MAY NOT WORK EVEN IF A PASSENGER IS IN …
Read full complaint
THE AIRBAG LIGHT IS ON AND THE PASSENGER SEAT AIRBAG DETECTION LIGHT SAYS OFF EVEN WHEN AN ADULT IS SITTING IN THE SEAT. I TOOK THE CAR IN AND THE AIRBAG CODE READ WAS A 71 INDICATING THAT THE OC3 MAT IN THE PASSENGER SEAT IS FAULTING. THE DEALERSHIP IS TELLING ME THAT THE AIRBAG MAY OR MAY NOT WORK EVEN IF A PASSENGER IS IN THE SEAT. I WAS TOLD BY THE DEALERSHIP THAT IT WOULD COST UP TO 3000.00 FOR MY CAR TO REPLACE THE OC3 MAT!!! NO SAFETY RECALL WARRANTY AVAILABLE FOR THIS MODEL YEAR AS THERE IS ON OTHERS! *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).