IllustrationWHEN ADJUSTING THE DRIVER AND PASSENGER SEATS, THE AIRBAG LIGHT ILLUMINATED. AFTER RESEARCHING ONLINE, I CONDUCTED TROUBLESHOOTING. I VERIFIED THAT THE WIRING HARNESSES AND CONNECTORS FOR THE AIRBAG SENSORS UNDER BOTH SEATS HAD COME LOOSE, AND CERTAIN WIRES DE-PINNED. THE CAR WAS RUNNING, AND PARKED WHEN THIS OCCURRED.
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
Air Bags complaints
71 reports2005 MINI COOPER S WAS TRAVELING 50MPH WHEN IT HIT ICY BRIDGE SPUN AROUND AND ROLLED 3 TIMES DRIVER WAS WEARING A SEATBELT AND PASSENGER WAS NOT AND GOT EJECTED AND DIED.NO AIRBAGS DEPLOYED. HWY 299.*DT *JS
THE PASSENGER SEAT OCCUPANCY MAT WAS REPLACED BY RECALL ON 10/28/2016. ON 10/2018 I NOTICED THAT WHEN THERE IS A PASSENGER IN THE SEAT WITH THEIR SEAT BELT ON THE AIR BAG WAS OFF, IN 1 WEEKS TIME THE PASSENGER SIDE SEAT BELT LIGHT WAS ON ALL THE TIME AND THE AIR BAG IS OFF ALL THE TIME WITH OR WITHOUT SOMEONE OCCUPING THE SEAT. …
Read full complaint
THE PASSENGER SEAT OCCUPANCY MAT WAS REPLACED BY RECALL ON 10/28/2016. ON 10/2018 I NOTICED THAT WHEN THERE IS A PASSENGER IN THE SEAT WITH THEIR SEAT BELT ON THE AIR BAG WAS OFF, IN 1 WEEKS TIME THE PASSENGER SIDE SEAT BELT LIGHT WAS ON ALL THE TIME AND THE AIR BAG IS OFF ALL THE TIME WITH OR WITHOUT SOMEONE OCCUPING THE SEAT. REGUARDLESS IF THE CAR IS IDILING OR GOING DOWN THE RODE. AT LEAST BEFORE THE RECALLED MAT SENSOR WAS REPLACED THE SEAT MAT SENSOR WORKED MOST OF THE TIME. NOW IT DOES NOT WORK AT ALL. I TOOK IT TO THE DEALERSHIP AND THEY TESTED THE OC3 MAT (PASSENGER SIDE MAT SENSOR) AND SAID THERE ARE MULTIPLE CODES FOR THE OC3 MAT AND THEY FOUND INTERNAL FAULTS AND IT REQUIRES REPLACEMENT AGAIN. THEY SAID THIS RECALL IS NO LONGER UNDER WARRENTY AND I NEED TO PAY OVER 1500.00 TO HAVE IT REPLACED. IT IS UNSAFE FOR ME TO HAVE A PASSENGER IN MY CAR IF WE GOT INTO AN ACCIDENT THEIR AIRBAG WOULD NOT BE ON, THERE FOR THEY WOULD HAVE NO AIRBAGS TO DEPLOY TO TRY AND PROTECT THEM. HOW IS THIS MY FAULT? THEY REPLACED MY MAT SENSOR WITH ANOTHER FAULTY ONE THAT IS WORSE THEN THE FIRST ONE. HOW LONG ARE THE WARRENTIES FOR RECALLS AND THE PARTS REPLACED? I HAVE THE PAPERS FROM THE DEALERSHIP STATING WHAT I JUST REPORTED TO YOU.
AIRBAG LIGHT ILLUMINATED AT ALL TIMES. DEALERSHIP REPORTS $1200 TO REPLACE SENSOR FOR PASSENGER SEAT AND MAY IMPACT ALL AIRBAGS IF NOT FIXED.
I HAVE A SAFETY RECALL (NO. 25V-205), AN AIR BAG PROBLEM, ISSUED LAST JUNE AND HAVE NOW RECEIVED ANOTHER RECALL ((15V-660). THE FIRST RECALL HAS YET TO BE REPAIRED.THE AIR BAG "OFF" LIGHT IS ON ALL THE TIME. I HAVE CONTACTED MINI AND THE DEALER TWICE AND THEY TELL ME THERE IS NOT A FIX YET. I THINK 6 MONTHS IS LONG ENOUGH FOR A…
Read full complaint
I HAVE A SAFETY RECALL (NO. 25V-205), AN AIR BAG PROBLEM, ISSUED LAST JUNE AND HAVE NOW RECEIVED ANOTHER RECALL ((15V-660). THE FIRST RECALL HAS YET TO BE REPAIRED.THE AIR BAG "OFF" LIGHT IS ON ALL THE TIME. I HAVE CONTACTED MINI AND THE DEALER TWICE AND THEY TELL ME THERE IS NOT A FIX YET. I THINK 6 MONTHS IS LONG ENOUGH FOR AN AIR BAG PROBLEM. I HAVE NOT HAD A PROBLEM WITH THE SECOND RECALL, A STEERING PROBLEM, BUT I ASSUME IT COULD HAPPEN. I AM CONCERNED THAT THE COMBINATION OF THESE TWO CREATES AN EXTRA DANGEROUS CONDITION. I ASKED MINI IF THEY WOULD PAY FOR A RENTAL WHEN I NEEDED TO HAVE A PASSENGER. THEY REFUSED. THIS IS MY ONLY VEHICLE AND I HAVE NO OTHER CHOICE.
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HA…
Read full complaint
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 11/18/15*LJ THE CONSUMER STATED SHE PAID FOR AN AIR BAG SENSOR TWO YEARS. UPDATED 12/15/15. *JB
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIMEFRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COU…
Read full complaint
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIMEFRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT WAS NOT EXPERIENCING A FAILURE.
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. IN ADDITION, THE CONTACT STATED THAT THE AI…
Read full complaint
TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. IN ADDITION, THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
MY PASSENGER AIR BAG HAS BEEN INACTIVE FOR OVER TWO YEARS DUE TO A PROBLEM WITH THE SEAT SENSOR. I RECENTLY SAW THERE WAS A RECALL FOR THIS ISSUE, BUT ACCORDING TO MY VIN MY VEHICLE HAS NO OPEN RECALLS SO IT WOULD SEEM I'M NOT COVERED BY THE CURRENT RECALL EVEN THOUGH I HAVE THE ISSUE. CAN YOU PLEASE INVESTIGATE AND LET ME KNOW …
Read full complaint
MY PASSENGER AIR BAG HAS BEEN INACTIVE FOR OVER TWO YEARS DUE TO A PROBLEM WITH THE SEAT SENSOR. I RECENTLY SAW THERE WAS A RECALL FOR THIS ISSUE, BUT ACCORDING TO MY VIN MY VEHICLE HAS NO OPEN RECALLS SO IT WOULD SEEM I'M NOT COVERED BY THE CURRENT RECALL EVEN THOUGH I HAVE THE ISSUE. CAN YOU PLEASE INVESTIGATE AND LET ME KNOW AS I WOULD LOVE TO GET THIS FAULTY SAFETY FEATURE REPAIRED!
PASSENGER BAG SYSTEM HAS NOT WORKED FOR OVER TWO YEARS. *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).