2012 Mini Cooper Countryman

My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

THE VEHICLE STARTS INTERMITTENTLY. THE IMMOBILIZER OF THE VEHICLE DOES NOT DETECT THE PRESENCE OF THEY KEY FOB IN THE SLOT AND THEREFORE WONT START THE VEHICLE. THESE EVENTS HAPPEN INTERMITTENTLY. ONE INSTANCE WAS IN A GASOLINE STATION. I STOP THE ENGINE AND REFUELED. WHEN IT WAS OVER I COULDNT GET THE CAR TO START BECAUSE THER WAS NO RESPONSE FROM THE CAR. I TRIED TO INSERT/EJECT THE KEY FOB IN ITS SLOT AND AFTER COUNTELESS AND MORE THAN THIRTY MINUTES WAS ABLE TO GET IT STARTED. ONE TIME , I WENT GROCERY SHOPPPING AND WHEN I WAS DONE WHEN BACK TO THE CAR AND IT WOULDN'T START. KNOWING THAT THIS HAS BEEN HAPPENING , I DID THE INSERT/EJECT OF KEY FOB IN ITS SLOT COUNTLESS NUMBER OF TIMES. I DID THIS FOR OVER AN HOUR BEFORE I GOT A RESPONSE FROM THE CAR AND GET IT STARTED. MY WIFE IS AFRAID TO DRIVE THIS CAR BECAUSE SHE MAY GET STUCK IN THE MIDDLE OF NOWHERE. IF THERE IS A MEDICAL EMERGENCY AND THIS IS THE ONLY CAR AVAILABLE, IT WOULD BE BETTER OFF TO JUST WAIT FOR THE AMBULANCE THAN ATTEMPT TO BRING THE PERSON NEEDING MEDICAL ATTENTION TO THE HOSPITAL IN THIS CAR BECAUSE YOU MAY GET STUCK IN THE MIDDLE OF NOWHERE. ANY ROAD TRIP THAT WILL GET YOU 100 MILES AWAY FROM YOUR PLACE OR DRIVING AT NIGHT IS A SAFETY RISK BECAUSE YOU MAY RUN OUT OF FUEL AND REFUEL AT A REMOTE GASOLINE STATION BUT THEN YOU CANT GET THE CAR TO START AGAIN.