TL* THE CONTACT OWNS A 1998 MERCURY VILLAGER. THE CONTACT STATED THAT THE REAR BRAKE LIGHTS ILLUMINATED AND FAILED TO TURN OFF ALTHOUGH THE BRAKE PEDAL WAS NOT DEPRESSED. AFTER INSPECTING THE VEHICLE AND CRUISE CONTROL SWITCH THE CONTACT DISCOVERED THAT THE PLASTIC BUSHINGS LOCATED ON THE BRAKE PEDAL AGAINST THE STOP LIGHT SWIT…
Read full complaint
TL* THE CONTACT OWNS A 1998 MERCURY VILLAGER. THE CONTACT STATED THAT THE REAR BRAKE LIGHTS ILLUMINATED AND FAILED TO TURN OFF ALTHOUGH THE BRAKE PEDAL WAS NOT DEPRESSED. AFTER INSPECTING THE VEHICLE AND CRUISE CONTROL SWITCH THE CONTACT DISCOVERED THAT THE PLASTIC BUSHINGS LOCATED ON THE BRAKE PEDAL AGAINST THE STOP LIGHT SWITCH WERE CRACKED INTO PIECES CAUSING THE REAR BRAKE LIGHT TO REMAIN ILLUMINATED. THE PLASTIC BUSHINGS WERE REPLACED BY THE CONTACT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 116,000...UPDATED 09/30/14 *BF UPDATED 2/27/2015 *JS
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH AUTOMOTIVE BATTERIES SUPPLIED BY GNB TECHNOLOGIES. THESE BATTERIES HAVE A DEFECTIVE NEGATIVE POST THAT CAN CAUSE ACID LEAKAGE AND RELATED CORROSION DAMAGE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A CATASTROPHIC FAILURE OF THE BATTERY WHICH COULD LEAD TO AN ENGINE FIRE OR BATTERY EXPLOSION.
Remedy: DEALERS WILL REPLACE THESE BATTERIES. UNTIL A NEW BATTERY IS OBTAINED, OWNERS SHOULD NOT ATTEMPT TO "JUMP START" THESE BATTERIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
1998 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration