IllustrationFUEL PRESSURE HOSE TO INJECTOR PREMATURELY CRACKED AND LEAKED FUEL WITH OUT PRIOR NOTICE. DEALERSHIP'S MECHANIC TOLD CONSUMER THAT THIS WAS NOT A MAINTENANCE PROBLEM. *AK THE VEHICLE WAS INOPERABLE AS THE RESULT OF LEAKING GAS. THE CONSUMER HAD INFORMED THE MANUFACTURER THROUGH INVESTIGATION QUESTIONNAIRE. *YH
1994 Mercury Villager
Owner reports · Recalls · Investigations
More warning signs than most Villager years
Owner complaints for the 1994 Mercury Villager are substantially higher than the model-year median of 125.
About this comparison →How this year compares
Owner complaints by model year
Compare all Villager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 253 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports6 fire reports4 injury reports
What owners actually said
253 reportsTHERE WAS FUEL SMELL IN INTERIOR OF VEHICLE, TAKEN TO DEALER ABOUT 6 MONTHS AGO WHO REPLACED A NARROW HOSE THAT APPARENTLY WAS TOO CLOSE TO ENGINE AND CAUSED SMELL. *AK
SEVERAL OF THE BOLTS THAT HOLD THE EXHAUST MANIFOLD ONTO THE ENGINE BLOCK HAVE POPPED OFF LEAVING THE STEM OF THE BOLT EMBEDDED IN THE ENGINE. AS A RESULT, DANGEROUS EXHAUST GASES ARE SEEPING OUT INTO THE ENGINE AREA BECAUSE THE MANIFOLD IS NO LONGER TIGHTLY ATTACHED TO THE ENGINE. IN ORDER TO FIX THE PROBLEM THE BOLTS MUST BE…
Read full complaint
SEVERAL OF THE BOLTS THAT HOLD THE EXHAUST MANIFOLD ONTO THE ENGINE BLOCK HAVE POPPED OFF LEAVING THE STEM OF THE BOLT EMBEDDED IN THE ENGINE. AS A RESULT, DANGEROUS EXHAUST GASES ARE SEEPING OUT INTO THE ENGINE AREA BECAUSE THE MANIFOLD IS NO LONGER TIGHTLY ATTACHED TO THE ENGINE. IN ORDER TO FIX THE PROBLEM THE BOLTS MUST BE DRILLED OUT. THIS IS A KNOWN DEFECT. THIS HAS OCCURED IN A NUMBER OF MERCURY VILLAGERS THAT USE THIS ENGINE. I HAVE PERSONALLY TALKED WITH SEVERAL MECHANICS THAT HAVE INDICATED IT IS A CONTINUAL PROPLEM WITH THIS MAKE. IT DID NOT TAKE ME LONG TO FIND OUT THAT THIS IS NOT AN ISSOLATED INSIDENT BUT ONE THAT HAS OCCURED IN MANY OF THE VILLAGER'S.
THE LOCKS WILL LOCK ALL DOORS BY THEMSELVES, AND I HAVE TO REPEATEDLY PRESS THE UNLOCK BUTTON OR HOLD THE UNLOCK BUTTON DOWN WHILE GETTING OUT OR GETTING MY SON OUT. FORD HAS TOLD ME THERE IS A TECHNICAL BULLETIN FOR THIS PROBLEM. THIS PROBLEM COULD MEAN LIFE OR DEATH IN AN ACCIDENT. *AK
ONGOING PROBLEM WITH FUEL ODOR GETTING INTO VEHICLE ONLY IN COLD WEATHER. VEHICLE BEEN IN DEALER SHOP ON FOUR OCCASIONS, AND PROBLEM STILL REOCCURRING. *AK AFTER TRYING TO FIX THE PROBLEM AND FAILING, THE CONSUMER DID INTERNET RESEARCH AND DISCOVERED THE CAUSE OF THE PROBLEM WAS COLD WEATHER WHICH MAKES THE HOSES TO BECOME U…
Read full complaint
ONGOING PROBLEM WITH FUEL ODOR GETTING INTO VEHICLE ONLY IN COLD WEATHER. VEHICLE BEEN IN DEALER SHOP ON FOUR OCCASIONS, AND PROBLEM STILL REOCCURRING. *AK AFTER TRYING TO FIX THE PROBLEM AND FAILING, THE CONSUMER DID INTERNET RESEARCH AND DISCOVERED THE CAUSE OF THE PROBLEM WAS COLD WEATHER WHICH MAKES THE HOSES TO BECOME UNPLIABLE AND LEAK FUEL. *YH
ONGOING PROBLEM WITH TAIL LIGHTS NOT ILUMINATING PROPERLY, BEEN TO AN INDEPENDENT REPAIR SHOP ON THREE OCCASIONS, AND PROBLEM STILL OCCURRING. DEALER/MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
FUEL SMELL INSIDE VEHICLE, FUEL LEAKING UNDERNEATH VEHICLE, REAR DRIVER'S SIDE WINDOW IMPLODED, BACK VENT WINDOW FELL OUT OF FRAME. *AK
CRANKSHAFT BROKE AFTER BELT TIGHTENING. VEHICLE STOPPED WHEN MOVING IN TRAFFIC. HARD TO CONTROL. DANGEROUS SITUATION. *AK
CONSUMER HAS HAD THIS PROBLEM FOR PASSED 4 YEARS. ONLY HAPPENS WHEN IT'S COLD. INSIDE OF VEHICLE FILLS UP WITH FUMES. ONCE VEHICLE IS WARMED UP FUMES GO AWAY. DEALER SAYS THEY'VE NEVER SEEN THIS BEFORE. CONSUMER HAS AN APPOINTMENT TO INSPECT VEHICLE.*AK
AT 46,000 MILES VEHICLE HAS BEEN EXPERIENCING ONGOING PROBLEM WITH FUEL FUMES/ODOR GETTING INTO VEHICLE ONLY AT 0 DEGREE WEATHER. VEHICLE BEEN IN/OUT OF DEALER SHOP ON SEVERAL OCCASIONS BEFORE THIS PROBLEM WAS CORRECTED. *AK THE PROBLEM OCCURS DURING WINTER AND HAD BEEN DIAGNOSED TO BE DUE TO FUEL HOSE LEAKING AND WAS REPLAC…
Read full complaint
AT 46,000 MILES VEHICLE HAS BEEN EXPERIENCING ONGOING PROBLEM WITH FUEL FUMES/ODOR GETTING INTO VEHICLE ONLY AT 0 DEGREE WEATHER. VEHICLE BEEN IN/OUT OF DEALER SHOP ON SEVERAL OCCASIONS BEFORE THIS PROBLEM WAS CORRECTED. *AK THE PROBLEM OCCURS DURING WINTER AND HAD BEEN DIAGNOSED TO BE DUE TO FUEL HOSE LEAKING AND WAS REPLACED BY THE DEALER. *YH
Official recalls
300V419002 · Fuel System, Gasoline:storage:tank Assembly
Jan 2, 2001
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE VENT HOSE.
96V253003 · Exterior Lighting:tail Lights
Aug 17, 1998
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
94V142000 · Visibility:windshield
Aug 1, 1994
THE WINDSHIELDS WERE MARKED WITH A "PROTOTYPE" DESIGNATION AND NOT MARKED AS REQUIRED BY FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: INCORRECT LABELING OF WINDSHIELD MAY CAUSE CONCERN OR CONFUSION ABOUT THE PROTOTYPE DESIGNATION.
Remedy: DEALERS WILL REPLACE THE WINDSHIELDS ON THE AFFECTED VANS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.