HAVING PROBLEM WITH THE BACK HEATER NOT WORKING AT ALL. TRANSMISSION HAS A SLOW SHIFT AND WILL SHIFT HARD WHEN DOWN SHIFTING, STERRING WHEEL GET HARD WHEN TEMP. ARE IN THE TEEN,S. CLUCK NOISES WHEN HITTING LIGHT BUMPS. BRAKES GRIND WHEN BRAKES ARE COLD. RADIO WILL LOOSE MEMORY. HEATER SWITCH WHEN ONE 1, MAKES A TICKING NOISE. SL…
Read full complaint
HAVING PROBLEM WITH THE BACK HEATER NOT WORKING AT ALL. TRANSMISSION HAS A SLOW SHIFT AND WILL SHIFT HARD WHEN DOWN SHIFTING, STERRING WHEEL GET HARD WHEN TEMP. ARE IN THE TEEN,S. CLUCK NOISES WHEN HITTING LIGHT BUMPS. BRAKES GRIND WHEN BRAKES ARE COLD. RADIO WILL LOOSE MEMORY. HEATER SWITCH WHEN ONE 1, MAKES A TICKING NOISE. SLIDING DOOR GETS HARD TO CLOSE. GAS TANK, HAVE TO TURN CAP SLOWLY SO GAS AIR WILL LEAK OUT. CHECK ENGINE LIGHT APPEARS THEN GOES OUT.
NHTSA ODI #10070101
Mileage unknown · Sep 25, 2001
Power Train
VEHICLE WAS PARKED IN A GARAGE LOCATED ON A SMALL INCLINE. VEHICLE ROLLED DOWN INCLINE INTO ANOTHER VEHICLE. VEHICLE WAS IN PARK, BUT CURRENTLY VEHICLE WILL NOT GO INTO PARK. CONTACTED DEALER, AND DEALER STATED SHIFT CABLE INDICATOR WAS BROKEN.*AK
NHTSA ODI #896835
Mileage unknown · Sep 25, 2000
Power TrainVehicle Speed Control
OWNER HAS BEEN WITHOUT A SPEEDOMETER FOR ALMOST A MONTH. SPEED SENSOR WAS TOTALLY UNAVAILABLE. OWNER WAS TOLD BY DEALERSHIP THAT THERE WERE 324 SPEED SENSORS ON BACK ORDER, AND THE PART WAS NOT AVAILABLE IN THE UNITED STATES. *AK
NHTSA ODI #871455
Mileage unknown · Jun 13, 2000
Power Train
WHILE DRIVING VAN JUST CUTS OFF/STALLS. PROBLEM HAS BEEN REPORTED TO DEALERSHIP. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #863465
Mileage unknown · Nov 10, 1999
Power Train
THE GEAR UNEXPECTEDLY SHIFTED ON THE RED LIGHT ON THE INTERSECTION WHAT CAUSED THE VAN TO "JUMP" FORWARD WHAT ALMOST CAUSE AN ACCIDENT. DID IT AGAIN SOMETIME LATER DURING "MICHIGAN U TURN" MANEUVER
NHTSA ODI #714583
Mileage unknown · Sep 28, 1999
Power Train
ON 8/24/99, PARKED VEHICLE. WENT TO START, WOULD NOT BACK UP, ONLY FORWARD GEAR. TOOK IT TO MULLINAX ON 8/30. APPROX. 9/9, MULLINAX SAID IT WAS TRANSMISSION. WOULD COST US APPROX. $3,000. THEY REBUILT 1 TRANY; DID NOT WORK. REBUILT IT AGAIN. STILL DID NOT WORK. FINALLY GAVE ME A RENTAL CAR ON 9/20. NOW THEY'RE WAITING FOR A R…
Read full complaint
ON 8/24/99, PARKED VEHICLE. WENT TO START, WOULD NOT BACK UP, ONLY FORWARD GEAR. TOOK IT TO MULLINAX ON 8/30. APPROX. 9/9, MULLINAX SAID IT WAS TRANSMISSION. WOULD COST US APPROX. $3,000. THEY REBUILT 1 TRANY; DID NOT WORK. REBUILT IT AGAIN. STILL DID NOT WORK. FINALLY GAVE ME A RENTAL CAR ON 9/20. NOW THEY'RE WAITING FOR A REBUILT TRANS FROM A FORD SUPPLIER. I COMPLAINED TO DETROIT. IT HAS BEEN 5 WEEKS.
CONSUMER STATES WHEN DRIVING THE AND APPLYING THE BRAKES THEY MAKE ALOT OF NOISE. ALSO, TRANMISSION IS GOING OUT. CONSUMER HAD TO KEEP PUTTING BULBS IN THE TAIL LIGHTS, AND THE DEALER CAN'T FOUND THE PROBLEM. *AK
NHTSA ODI #830484
Mileage unknown · Dec 4, 1997
Power Train
TRANSMISSION PLANETARY GEAR FAILURE, CAUSIGN GEARS TO FREEZE.
NHTSA ODI #526453
Mileage unknown · Jan 19, 1995
Power Train
TRANSMISSION MOUNT FAILED, CAUSING TRANSMISSION TO RATTLE AT LOW SPEEDS/WHEN SHIFTING GEAR FROM PARK INTO DRIVE. *AK
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
THE REAR LAMP SOCKET MAY NOT ILLUMINATE BECAUSE THE METAL CAN IN THE LAMP SOCKET MOVES OR SEPARATES FROM THE PLASTIC SOCKET HOUSING.
Consequence & remedy
Consequence: THIS CAN RESULT IN MALFUNCTION OF THE STOP OR REAR RUNNING LAMPS. CENTER HIGH MOUNT STOP LAMP FUNCTION IS UNAFFECTED. REAR LAMP MALFUNCTION CAN RESULT IN FOLLOWING DRIVERS NOT BEING ALERTED TO THE SUBJECT VEHICLE'S PRESENCE OR INTENDED ACTIONS, PARTICULARLY IN THE CASE IN WHICH BOTH LAMPS HAVE MALFUNCTIONED.
Remedy: DEALERS WILL INSTALL A REVISED REAR LAMP SOCKET AND WIRING ASSEMBLIES.
THE WINDSHIELDS WERE MARKED WITH A "PROTOTYPE" DESIGNATION AND NOT MARKED AS REQUIRED BY FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: INCORRECT LABELING OF WINDSHIELD MAY CAUSE CONCERN OR CONFUSION ABOUT THE PROTOTYPE DESIGNATION.
Remedy: DEALERS WILL REPLACE THE WINDSHIELDS ON THE AFFECTED VANS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
PE99077 · Fuel Tank Vent Hose Leakage
Opened Dec 28, 1999 · Closed May 22, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99015 · Fuel Rail Hose Fitting Leakage
Opened Jun 29, 1999 · Closed Apr 18, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE ENGINEERING ANALYSIS CLOSING REPORT COVERS 1993-1998 MERCURY VILLAGER AND NISSAN QUEST MINIVANS.THESE TWO MINIVANS SHARE A COMMON BODY PLATFORM AND POWER TRAIN.BASED ON THE LOW NUMBER OF REPORTED INCIDENTS AND THE ABSENCE OF A DEMONSTRABLE FAILURE TREND, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ENGINEERING CLOSING REPORT EA99-015 FOR DETAILS.
PE99013 · Fuel Rail Hose Fitting Leakage
Opened Feb 9, 1999 · Closed Jun 29, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SINCE SEPTEMBER 1998, ODI HAS RECEIVED SEVEN COMPLAINTS OF FUEL ODOR OR LEAKAGE IN 1994 THROUGH 1995 MERCURY VILLAGER VEHICLES.FOUR OF THE LEAKS HAVE BEEN TRACED TO A SHORT SECTION OF HOSE THAT CONNECTS THE FUEL SUPPLY TUBE TO THE REAR OF THE FUEL RAIL.INFORMAITON CONTAINED IN THE REPORTS INDICATE THAT THE PROBLEM MAY BE DIFFICULT TO DIAGNOSE, WITH SEVERAL OWNERS ALLEGING MULTIPLE DEALER SERVICE REPAIRS.ADVANCED COMPRESSION SET IS EVIDENT IN A HOSE REMOVED FROM THE MOST RECENT COMPLAINT VEHICLE.
EA96005 · Battery Explosions
Opened May 30, 1996 · Closed May 29, 1997
Status: closed (inferred from source dates) · Electrical System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1994 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration