Electronic Stability Control (esc)EngineCrashInjury
RELEVANT INFORMATION---ENGINE WAS REPAIRED ON SEPT. 9/10, 2012 SAME MORNING AS THE ACCIDENT--CAR WAS DRIVEN TO BANK BUT AS I WAS LEAVING I COULD NOT PUT CAR INTO REVERSE. A GENTLEMAN PASSERBY WAS ABLE TO PUT IT INTO REVERSE WITH EFFORT AND A LOUD NOISE IN THE GEARS. I PROCEEDED TO MY EXERCISE CLASS WHICH LASTED ONE HOUR. HAD NO…
Read full complaint
RELEVANT INFORMATION---ENGINE WAS REPAIRED ON SEPT. 9/10, 2012 SAME MORNING AS THE ACCIDENT--CAR WAS DRIVEN TO BANK BUT AS I WAS LEAVING I COULD NOT PUT CAR INTO REVERSE. A GENTLEMAN PASSERBY WAS ABLE TO PUT IT INTO REVERSE WITH EFFORT AND A LOUD NOISE IN THE GEARS. I PROCEEDED TO MY EXERCISE CLASS WHICH LASTED ONE HOUR. HAD NO TROUBLE WITH REVERSE GEAR THIS TIME. ABOUT 1/2 HOUR LATER I WAS TURNING INTO A PARKING LOT AND IN A MATTER OF MINUTES THE ENGINE STARTED REVVING UP AND SHOT FORWARD ON ITS OWN, WENT OVER A CURB & SIDEWALK AND CRASHED INTO A BRICK WALL AT HIGH SPEED. THE AIR BAGS WENT OFF AND WITH EFFORT I WAS ABLE TO OPEN THE FRONT DOOR. I HAD MINOR INJURIES--NOSE, CUT ON ELBOW, BANGED UP KNEES. THE ENGINE OF THE CAR KEPT ROARING FOR POSSIBLY 15 MINUTES UNTIL SOMEONE CUT THE CABLE TO THE BATTERY. THE POLICE REPORTED THAT I HAD STEPPED ON THE GAS INSTEAD OF THE BRAKE WHICH WAS TOTALLY FALSE. I REMEMBER DISTINCTLY THINKING--THERE'S SOMETHING TERRIBLE WRONG WITH MY CAR. THE INSURANCE COMPANY WAS NOT INTERESTED IN PURSUING THE CAUSE WHICH MAY HAVE BEEN RELATED TO THE REPAIR DONE ON THE ENGINE. THEY CALLED THE CAR A TOTAL LOSS. *TR
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.
Consequence & remedy
Consequence: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.
Consequence & remedy
Consequence: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.
Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Mercury Sable Problems, Complaints & Recalls | Skip That Year
Illustration