IllustrationWHILE DRIVING AT ANY SPEED THERE IS A NOISE COMING FROM FRONT OF VEHICLL. CONSUMER HAD TO GET REAR MOTOR MOUNTS FIXED. PREVIOUSLY HAD FRONT MOTOR MOUNTS FIXED THREE TIMES. ALSO, TRANMISSION HAS BEEN REPLACED AND THE VEHICLE JERKS AND CUTS OFF AT TIMES. *AK
1991 Mercury Sable
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Mercury Sable do not stand out strongly from the model-year median of 201.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sable years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 221 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports9 fire reports5 injury reports
Power Train complaints
101 reportsEXPERIENCING VARIOUS PROBLEM WITH VEHICLE WITHIN 63,000 MILE OF WEARS,HAD TRANSMISSION REBUILT/REPLACED FUEL INJECTION SYSTEM, AND COMPLETE OVERHAUL OF BRAKES SYSTEM. DEALER WAS NOT CONTACTED / WOULD LIKE TO KNOW IS THIS CONSIDERED NORMAL. *AK
CHECK ENGINE LIGHT COMES ON ALL THE TIME FOR NO REASON. THE TRANSMISSON LOCKED UP, CAUSING THE CAR TO CUT OFF WHEN PUT INTO GEAR. DEALER SAYS VEHICLE NEEDS NEW TRANSMISSION. *AK
IN CONTINUOUS OPERATION THE INTAKE FOR THE OIL IS TOO SMALL TO ALLOW SUFFICIENT OIL INTO THE TRANSMISSION, AND FRICTION CAUSES A LOCKUP WITH THE PLANITARY GEARS ,CAUSING EXTENSIVE DAMAGE. *AK
WHILE BACKING OUT OF A DRIVEWAY THERE WAS A LOUD NOISE COMING FROM THE VEHICLE, AND THE REAR MOUNT BOLTS PULLED THROUGH THE SUB-FRAME DUE TO CORROSION, CAUSING THE STEERING TO LOCK UP. *AK THE CUSTOMER WAS SEEKING REIMBURSEMENT FOR REPAIRS OF THE VEHICLE'S DEFECTIVE PARTS THAT WERE ON RECALL 93V106002. THE VEHICLE'S TRANSMISSI…
Read full complaint
WHILE BACKING OUT OF A DRIVEWAY THERE WAS A LOUD NOISE COMING FROM THE VEHICLE, AND THE REAR MOUNT BOLTS PULLED THROUGH THE SUB-FRAME DUE TO CORROSION, CAUSING THE STEERING TO LOCK UP. *AK THE CUSTOMER WAS SEEKING REIMBURSEMENT FOR REPAIRS OF THE VEHICLE'S DEFECTIVE PARTS THAT WERE ON RECALL 93V106002. THE VEHICLE'S TRANSMISSION FAILED AND WAS REPLACED BY THE CUSTOMER. *YH
TRANSMISSION FAILED RESULTING FROM EXCESSIVE METAL FOUND IN FLUID.
HEAD GASKET FAILED.
WHILE DRIVING VEHICLE TRANSMISSION SLIPPED, RESULTING IN VEHICLE LOSING POWER AND PULLING OVER. THE TRANSMISSION WENT COMPLETELY OUT CONSUMER HAS CONTACTED THE DEALER, PARTS HAVE BEEN REPLACED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
TRANSMISSION FAILED.
TRANSMISSION FAILURE.
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
92V065000 · Wheels
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
91V134000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available