Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Power Train complaints

2 reports

Clear category filter

Mileage unknown · Dec 10, 2018

Power Train

Read full complaint

REAR DIFFERENTIAL IS FILLING WITH WATER PASS THE FILL PLUG. THIS IS A GARAGE KEPT CAR AND NEVER OFF ROAD NOR DIRVEN IN DEEP WATER. FIRST TIME DISCOVERED AT 22000 MILES AND THE DEALER REPLACE THE PINION SEAL AND OIL, BUT COULD NOT FIND THE CAUSE. DIFFERENTIAL NOW MAKING NOISE AND AGAIN FULL OF WATER PAST THE FILL PLUG. SEARCHED ONLINE AND FOUND SEVERAL PEOPLE WITH THE SAME PROBLEM WITH FORD PRODUCTS. DEALER CANNOT FIND OR NOT WILLING TO FIND THE CAUSE. CALLED FORD AND THEY OFFER LITTLE TO NO SUPPORT. GUESS THEY ARE WAITING FOR THE DIFFERENTIALS TO LOCK UP AT HIGHWAY SPEED AND KILL A DOZEN OF SO PEOPLE.

NHTSA ODI #11157272

6,125 miles · May 30, 2012

EnginePower TrainSteering

Read full complaint

PULLED INTO PARKING SPACE, PLACED SHIFTER IN PARK, TURNED OFF IGNITION, RELEASED BRAKE AND VEHICLE ROLLED BACKWARDS AS IF NOT IN PARK. ATTEMPTED TO RESTART VEHICLE AND NO RESPONSE. SET PARKING BRAKE. COULD NOT GET VEHICLE TO LOCK INTO PARK, SHIFTER MOVED REGARDLESS OF BRAKE ON OR NOT AND WOULD NOT START. MOVED SHIFTER THROUGH ENTIRE RANGE OF GEARS AND RETURNED TO PARK, VEHICLE STILL WOULD NOT START AND PARK WOULD NOT HOLD. CALLED DEALER AND WAS TOLD TO HAVE IT TOWED IN. RETURNED TO VEHICLE AND TRIED ONCE MORE AND IT STARTED AND PROCEEDED TO RESPOND NORMALLY. VEHICLE TAKEN DIRECTLY TO DEALER WHO COULD NOT FIND ANY PROBLEM OR CAUSE OF PRECEDING SITUATION. ON TWO SUBSEQUENT DATES (MOST RECENT 5/25/2012), VEHICLE WAS BACKED INTO A PARKING SPACE, PLACED IN PARK AND IGNITION TURNED OFF. WHEN AN ATTEMPT TO RESTART VEHICLE WAS MADE THERE WAS NO RESPONSE. PARK APPEARED TO HOLD NORMAL, BUT UNABLE TO ENGAGE IGNITION. DASH LIGHTS, CHIMES AND ALL ELECTRICAL COMPONENTS APPEAR TO WORK NORMAL BUT WAS STILL UNABLE TO ENGAGE STARTER. AGAIN STARTED PROCESS TO HAVE VEHICLE TOWED TO DEALER. AFTER APPROXIMATELY 30 MINUTES TO AN HOUR OF SITTING (WITH NO OTHER ACTION) VEHICLE STARTED NORMALLY. AGAIN DEALER AT A LOSS FOR CAUSE AND CANNOT EFFECT REPAIR SINCE UNABLE TO RECREATE PROBLEM. CONCERN IS FOR TRANSMISSION/IGNITION INTERLOCK FAILURE OR OTHER ACTION THAT COULD RESULT IN DAMAGE OR INJURY. *TR

NHTSA ODI #10460011

Official recalls

10V161000 · Seats:front Assembly:recliner

Apr 20, 2010

FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEATBACK AND HEAD RESTRAINT MAY MOVE REARWARD, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.