NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
39 reportsClear category filter120,000 miles · May 27, 2020
Electrical System
TL* THE CONTACT OWNS A 2008 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING SYSTEM WAS INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE HOWEVER, WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE INSTRUMENT PANEL LIGHTS WERE REPLACED HOWEVER, THE FAILURE RECURRE…
Read full complaint
TL* THE CONTACT OWNS A 2008 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING SYSTEM WAS INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE HOWEVER, WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE INSTRUMENT PANEL LIGHTS WERE REPLACED HOWEVER, THE FAILURE RECURRED. THE VEHICLE THEN WAS TAKEN TO MARITIME FORD (1305 FRANKLIN ST, MANITOWOC, WI 54220) WHERE THE VEHICLE WAS DIAGNOSED AND IT WAS DETERMINED THAT THE DIMMER SWITCH NEEDED TO BE PLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. *DT*JB
NHTSA ODI #11326133
140,074 miles · May 9, 2020
Electrical SystemElectronic Stability Control (esc)Engine
CAR WHEN IDLE SHUTS OFF IN MIDDLE OF TRAFFIC LOCKING BREAK AN STEERING WHEEL CAN CAUSE ACCIDENT HAPPENED TO ME IN MIDDLE OF TRAFFIC THANK GOD I WAS CLOSE TO EMERGENCY EXIT CAR SHUTOFF NOT ALLOWING TO BRAKE HAD TO PRESS EMERGENCY BRAKE. *TR
NHTSA ODI #11323974
29,000 miles · Mar 7, 2020
Electrical SystemPower TrainService Brakes
AT 28000 MILES THE TRANSMISSION STARTED SHIFTING ERRATIC, THE DEALER REPROGRAMMED THE ECM AND COVERED UP THE PROBLEM UNTIL THE WARRANT ENDED AND THE BATTERY FAILED AT WHICH TIME THE CAR REVERTED BACK TO DEFAULT AND CONTINUED TO BUCK AND JERK UNTIL THE CAR REACHED HIGHWAY SPEED. THIS CONTINUED UNTIL THE TRANSMISSION FINALLY FAILE…
Read full complaint
AT 28000 MILES THE TRANSMISSION STARTED SHIFTING ERRATIC, THE DEALER REPROGRAMMED THE ECM AND COVERED UP THE PROBLEM UNTIL THE WARRANT ENDED AND THE BATTERY FAILED AT WHICH TIME THE CAR REVERTED BACK TO DEFAULT AND CONTINUED TO BUCK AND JERK UNTIL THE CAR REACHED HIGHWAY SPEED. THIS CONTINUED UNTIL THE TRANSMISSION FINALLY FAILED DURING OPERATION ON THE HIGHWAY ON 3/5/20. THE ABS MODULE JUST FAILED DURING LOW SPEED OPERATION FOR NO APPARENT REASON. ALSO THE CAR INDICATED THAT THERE IS AN ELECTRICAL PROBLEM EVEN THOUGH ALL ELECTRICAL COMPONENTS ARE IN GOOD OPERATIONAL CONDITION. THIS ERROR COMES AND GOES CONSTANTLY AT ANY GIVEN TIME.
NHTSA ODI #11316784
198,000 miles · Nov 25, 2019
Electrical SystemSeats
DRIVER SEAT ELECTRICAL ADJUSTMENT WILL MOVE ITSELF BACKWARDS WHILE CAR IS MOVING. THERE IS NO PATTERN TO THIS PROBLEM, IT IS RANDOM.
NHTSA ODI #11282163
135,000 miles · May 27, 2019
Electrical SystemSeats
WHILE DRIVING DRIVER SEAT GOES BACKWARD AND INTERIOR LIGHTS GOES ON WITH OUT USING OR PUSHING NO INSTRUMENTS
NHTSA ODI #11210214
13,000 miles · Oct 18, 2018
Electrical SystemSeats
WHILE DRIVING THE VEHICLE THE INTERIOR LIGHT TURNS ON AND THE SEAT MOVES BACK INTO THE PARK POSITION. THIS IS A SAFETY ISSUE AS IT IS DIFFICULT TO REACH THE PEDAL/BRAKE AND IT HAPPENS WITHOUT NOTICE. THERE IS NO RHYME OR REASON TO THIS PROBLEM. I HAVE SEEN MULTIPLE POSTS REGARDING THIS ISSUE AND DON'T SEE HOW IT CANNOT BE A REC…
Read full complaint
WHILE DRIVING THE VEHICLE THE INTERIOR LIGHT TURNS ON AND THE SEAT MOVES BACK INTO THE PARK POSITION. THIS IS A SAFETY ISSUE AS IT IS DIFFICULT TO REACH THE PEDAL/BRAKE AND IT HAPPENS WITHOUT NOTICE. THERE IS NO RHYME OR REASON TO THIS PROBLEM. I HAVE SEEN MULTIPLE POSTS REGARDING THIS ISSUE AND DON'T SEE HOW IT CANNOT BE A RECALL FOR SAFETY REASONS
NHTSA ODI #11141363
90,000 miles · Dec 7, 2017
Electrical SystemSeats
AFTER APPROXIMATELY 90,000 MILES THE DOME LIGHTS TURNED ON AND AUTOMATIC SEATS MOVE BACK WHILE DRIVING. THIS ISSUE PERSISTS AND OFTEN OCCURS SEVERAL TIMES. THERE ARE SEVERAL COMPLAINTS OF THIS ISSUE FOUND ONLINE. IT IS NOT DUE TO A HEAVY KEY CHAIN AS I ONLY HAVE THE FOB AND KEY ATTACKED. THIS IS A SAFETY ISSUE AS THE SEATS PU…
Read full complaint
AFTER APPROXIMATELY 90,000 MILES THE DOME LIGHTS TURNED ON AND AUTOMATIC SEATS MOVE BACK WHILE DRIVING. THIS ISSUE PERSISTS AND OFTEN OCCURS SEVERAL TIMES. THERE ARE SEVERAL COMPLAINTS OF THIS ISSUE FOUND ONLINE. IT IS NOT DUE TO A HEAVY KEY CHAIN AS I ONLY HAVE THE FOB AND KEY ATTACKED. THIS IS A SAFETY ISSUE AS THE SEATS PULL THE DRIVER AWAY FROM THE PEDALS AND STEERING WHEEL. INVESTIGATE! RECALL!
NHTSA ODI #11052947
112,580 miles · Oct 23, 2017
Electrical System
WHILE DRIVING DOWN THE ROAD, THE SEAT WILL SUDDENLY MOVE BACKWARDS TO THE "OPEN DOOR" POSITION, AS THOUGH THE KEY HAD BEEN PULLED OUT OF THE IGNITION. THIS CREATES A VERY DANGEROUS SITUATION, ESPECIALLY FOR PEOPLE WITH SHORT LEGS, AS ONE CAN NO LONGER REACH THE GAS PEDAL OR BRAKE. SLIGHTLY "WIGGLING" THE KEY OR IGNITION SWITCH…
Read full complaint
WHILE DRIVING DOWN THE ROAD, THE SEAT WILL SUDDENLY MOVE BACKWARDS TO THE "OPEN DOOR" POSITION, AS THOUGH THE KEY HAD BEEN PULLED OUT OF THE IGNITION. THIS CREATES A VERY DANGEROUS SITUATION, ESPECIALLY FOR PEOPLE WITH SHORT LEGS, AS ONE CAN NO LONGER REACH THE GAS PEDAL OR BRAKE. SLIGHTLY "WIGGLING" THE KEY OR IGNITION SWITCH WILL USUALLY GET THE SEAT TO MOVE BACK TO THE PRESET DRIVING POSITION. WHEN THIS HAPPENS, THE INTERIOR LIGHTS ALSO GO ON, AND TURN OFF WHEN THE SEAT MOVES BACK INTO POSITION. THIS SEEMS TO HAPPEN AT ALL DIFFERENT SPEEDS, AND IT SEEMS MOST EVENTS HAPPEN AFTER THE CAR HITS A BUMP, BUT NOT ALWAYS. THERE HAVE BEEN TIMES WHEN IT JUST SEEMS TO HAPPEN WITHOUT ANYTHING TO SET IT OFF. IT ALSO CAN HAPPEN WHEN THE VEHICLE IS FIRST STARTED UP, OR JUST AS YOU START TO SHUT THE VEHICLE OFF. IT IS ABSOLUTELY RIDICULOUS THAT REPAIR OF THIS CONDITION IS NOT A RECALL ITEM. THE DATE SHOWN FOR WHEN IT HAPPENED IS THE LATEST DATE - I HAVE NOT DRIVEN THE VEHICLE SINCE THEN - BUT IT HAS BEEN OCCURRING FOR AT LEAST THE LAST 10 MONTHS.
NHTSA ODI #11035952
Mileage unknown · Apr 19, 2017
Electrical System
TURN KEY ON AN SEAT GOES BACK AN FOURTH ,THEN STOPS ,WHILE DRIVING IT GOES BACK AN FORTH AGAIN SOME TIMES 3-4TIMES IT HAS GOTTEN MUCH WORSE RECENTLY ,DEFINITELY NOT SAFE TO DRIVE LIKE THAT,THIS HAPPENED WHEN STARTING UP THE CAR AN DRIVING,WHICH MAKES THE SEAT GO ALL THE WAY BACK AN I'M SHORT SO WHEN IT GOES BACK I BARELY REACH T…
Read full complaint
TURN KEY ON AN SEAT GOES BACK AN FOURTH ,THEN STOPS ,WHILE DRIVING IT GOES BACK AN FORTH AGAIN SOME TIMES 3-4TIMES IT HAS GOTTEN MUCH WORSE RECENTLY ,DEFINITELY NOT SAFE TO DRIVE LIKE THAT,THIS HAPPENED WHEN STARTING UP THE CAR AN DRIVING,WHICH MAKES THE SEAT GO ALL THE WAY BACK AN I'M SHORT SO WHEN IT GOES BACK I BARELY REACH THE PEDALS, THIS HAPPENED ALL THE TIME FOR NO REASON ON SIDE STREETS ON HIGHWAY
NHTSA ODI #10979404
90,000 miles · Mar 20, 2017
Electrical SystemExterior LightingService Brakes
WHILE DRIVING THE VEHICLE, THE SEAT SUDDENLY WENT ALL THE WAY BACK AND THE INTERIOR LIGHTS CAME ON. THIS HAS HAPPENED SEVERAL TIMES SINCE THEN, WE FINALLY FIGURED OUT IT WAS THE IGNITION, WITH THE CAR ACTING LIKE THE KEY JUST GOT PUT IN THE IGNITION OR JUST PULLED OUT, AND THE SEAT MOVING ALL THE WAY BACK FOR EASIER INGRESS/EGRE…
Read full complaint
WHILE DRIVING THE VEHICLE, THE SEAT SUDDENLY WENT ALL THE WAY BACK AND THE INTERIOR LIGHTS CAME ON. THIS HAS HAPPENED SEVERAL TIMES SINCE THEN, WE FINALLY FIGURED OUT IT WAS THE IGNITION, WITH THE CAR ACTING LIKE THE KEY JUST GOT PUT IN THE IGNITION OR JUST PULLED OUT, AND THE SEAT MOVING ALL THE WAY BACK FOR EASIER INGRESS/EGRESS AND THE COURTESY LIGHTS COMING ON. SINCE I AM ONLY 5 FOOT 4 INCHES, WHEN THE SEAT MOVES BACK I CAN NO LONGER REACH THE PETALS, A VERY DANGEROUS SITUATION WHILE DRIVING.
NHTSA ODI #10967171
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration