NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
70 reportsClear category filter90,000 miles · Jun 15, 2010
Power TrainStructureVehicle Speed Control
I OWN A 2002 MERCURY MOUNTAINEER. THE TAILGATE DEVELOPED A CRACK BETWEEN THE EMBLEM AND THE REAR GLASS LIFT. IT WAS FIXED ONCE ALREADY AND HAS SINCE CRACKED AGAIN. SINCE THIS CRACK HAS DEVELOPED, THE DOOR AJAR LIGHT HAS COME ON. I HAVE NOTICED THE SAME CRACK IN ALMOST EVERY FORD EXPLORER AND MOUNTAINEER THAT I SEE. I CONTACTED…
Read full complaint
I OWN A 2002 MERCURY MOUNTAINEER. THE TAILGATE DEVELOPED A CRACK BETWEEN THE EMBLEM AND THE REAR GLASS LIFT. IT WAS FIXED ONCE ALREADY AND HAS SINCE CRACKED AGAIN. SINCE THIS CRACK HAS DEVELOPED, THE DOOR AJAR LIGHT HAS COME ON. I HAVE NOTICED THE SAME CRACK IN ALMOST EVERY FORD EXPLORER AND MOUNTAINEER THAT I SEE. I CONTACTED THE DEALER TO HAVE IT REPAIRED AGAIN AND WAS TOLD THAT THEY ONLY COVER THE REPAIR ONCE. I DON'T FEEL I SHOULD HAVE TO PAY OUT OF POCKET FOR AN OBVIOUS MANUFACTURING DEFECT. I THEN CONTACTED FORD AND WAS TOLD THERE IS NOTHING THEY CAN DO FOR ME. KEEP IN MIND, I HAVE ALSO HAD NUMEROUS VISITS FOR MY TRANSMISSION HAVING ISSUES FROM THE BEGINNING AND I HAVE ALSO HAD ISSUES WITH THE CRUISE CONTROL WHERE IT SUDDENLY "TAKES OFF" AND GOES REALLY FAST. FORD NEEDS TO STAND BY IT'S VEHICLES AND FIX THEM WHEN THERE ARE OBVIOUS MANUFACTURER DEFECTS! *TR
NHTSA ODI #10336445
52,489 miles · Mar 8, 2010
Structure
TL* THE CONTACT HAS A 2002 MERCURY MOUNTAINEER. THE CONTACT FEELS THAT THE VEHICLE IS EXPERIENCING THE SAME FAILURE AS RECALL CAMPAIGN (04V442000) ISSUED FOR THE 2002 FORD EXPLORER. THE VEHICLE HAS A CRACK GOING FROM THE GLASS ALL THE WAY DOWN PAST THE MOUNTAINEER EMBLEM ON THE BACK HATCH OF THE VEHICLE. THE CONTACT HAS HEARD OF…
Read full complaint
TL* THE CONTACT HAS A 2002 MERCURY MOUNTAINEER. THE CONTACT FEELS THAT THE VEHICLE IS EXPERIENCING THE SAME FAILURE AS RECALL CAMPAIGN (04V442000) ISSUED FOR THE 2002 FORD EXPLORER. THE VEHICLE HAS A CRACK GOING FROM THE GLASS ALL THE WAY DOWN PAST THE MOUNTAINEER EMBLEM ON THE BACK HATCH OF THE VEHICLE. THE CONTACT HAS HEARD OF REAR WINDOWS EXPLODING ON THE FORD VEHICLE BECAUSE OF THIS PROBLEM AND THINKS THIS IS A SAFETY HAZARD FOR THIS VEHICLE. THE FAILURE MILEAGE WAS 52489 AND THE CURRENT MILEAGE WAS 53000.
NHTSA ODI #10317828
90,000 miles · Dec 30, 2009
StructureSuspensionVisibility
ON COLD MORNINGS, THE FRONT WINDSHIELD FOGS/FROSTS UP. TURNING HEAT ON AND SELECTING DEFROST PROVIDES LITTLE TO NO AIR TO WINDSHIELD. DEALERSHIP IDENTIFIED IT AS A BROKEN VENT SELECT DOOR, REQUIRING DASHBOARD TO BE REMOVED AND PART REPLACED, $1100 FIX. IN DOING RESEARCH ON THE VENT SELECT DOOR - CARS ARE DESIGNED THAT IF THE …
Read full complaint
ON COLD MORNINGS, THE FRONT WINDSHIELD FOGS/FROSTS UP. TURNING HEAT ON AND SELECTING DEFROST PROVIDES LITTLE TO NO AIR TO WINDSHIELD. DEALERSHIP IDENTIFIED IT AS A BROKEN VENT SELECT DOOR, REQUIRING DASHBOARD TO BE REMOVED AND PART REPLACED, $1100 FIX. IN DOING RESEARCH ON THE VENT SELECT DOOR - CARS ARE DESIGNED THAT IF THE SELECTOR BREAKS THAT THE AIR SHOULD DEFAULT TO THE FRONT DEFROST SO THAT WINDSHIELD WOULD NOT FOG/FROST AND CAUSE A LIFE THREATENING SITUATION. MULTIPLE TIMES THIS HAS OCCURRED WHILE DRIVING, ALL ALONG BELIEVING THAT THE FOGGING UP WAS DUE TO SNOW BUILD UP ON OUTSIDE VENTS. THE FACT THAT THE VENT BROKE AND DID NOT PUSH AIR TO THE WINDSHIELD IS WHY I'M LOGGING THIS COMPLAINT AS IT COULD HAVE RESULTED IN A LIFE THREATENING SITUATION. IN READING THE OTHER ENTRIES, NOTING THAT I'VE HAD TO HAVE THE REAR COIL SPRINGS REPLACED AND HAD BACK LIFTGATE REPLACED AFTER CRACKING. *TR
NHTSA ODI #10297587
65,000 miles · Dec 19, 2009
Structure
REAR TAILGATE LATCH BRAKES ACROSS THIS IS A KNOW ISSUE WITH ALL FORD EXPLORERS AND MERCURY MOUNTAINEERS. IT'S OBVIOUSLY A BAD DESIGN FROM FORD MOTOR CO. FORD NEEDS TO RECALL THIS AND IT'S THEIR DESIGN AND IT ALSO CAN REPRESENT AN INJURY TO SOMEONE IF A PIECE WAS TO FALL OFF AND HIT ANOTHER CAR. *TR
NHTSA ODI #10296422
445,690 miles · Sep 29, 2009
EquipmentStructureSuspension
2002 MERCURY MOUNTAINEER. IN THE PAST 4 YEARS WE HAVE REPLACED THE REAR BEARINGS 5 TIMES AND NOW FORD MOTOR COMPANY WILL NOT HONOR THE WARRANTY. EACH TIME THE BEARINGS LAST BETWEEN 4 AND 6 MONTHS. *TR
NHTSA ODI #10285600
Mileage unknown · Apr 23, 2009
Structure
UNDER BACK GLASS OF MERCURY MOUNTAINEER THERE IS A STRIP ALL THE WAY ACROSS THE BACK THAT IS CRACKED IN 2 I HAVE NOTICE EVERY MOUNTAINEER I HAVE SEEN OLD AND NEW ALL ARE DOING THE SAME ITS LIKE ALL THE ONES ON THE ROAD TO DAY ARE LIKE THAT AND IT COULD BREAK ALL THE WAY OFF AND HIT A CAR AND IT HAS SHARP EDGES AND DEALERS WANT …
Read full complaint
UNDER BACK GLASS OF MERCURY MOUNTAINEER THERE IS A STRIP ALL THE WAY ACROSS THE BACK THAT IS CRACKED IN 2 I HAVE NOTICE EVERY MOUNTAINEER I HAVE SEEN OLD AND NEW ALL ARE DOING THE SAME ITS LIKE ALL THE ONES ON THE ROAD TO DAY ARE LIKE THAT AND IT COULD BREAK ALL THE WAY OFF AND HIT A CAR AND IT HAS SHARP EDGES AND DEALERS WANT TO MUNCH TO FIX IT WELL I THANK IF ALL MOUNTAINEERS ARE LIKE THIS IT SHOULD BE RECALLED U CAN DRIVE DOWN THE ROAD AND LOOK AT THEM ALL THEY ARE LIKE THAT SO THANK YOU FOR YOUR TIME. *TR
NHTSA ODI #10266536
108,000 miles · Mar 26, 2009
Structure
I OWN A 2002 MERCURY MOUNTAINEER. THE TAILGATE DEVELOPED A CRACK BETWEEN THE EMBLEM AND THE REAR GLASS LIFT. SINCE THIS CRACK HAS DEVELOPED, THE DOOR AJAR LIGHT HAS STAYED ON CONSISTENTLY, CAUSING THE INTERIOR LIGHT TO STAY ON, DRAINING THE BATTERY, WHICH HAD TO BE REPLACED. I HAVE NOTICED THE SAME CRACK IN ALMOST EVERY FORD E…
Read full complaint
I OWN A 2002 MERCURY MOUNTAINEER. THE TAILGATE DEVELOPED A CRACK BETWEEN THE EMBLEM AND THE REAR GLASS LIFT. SINCE THIS CRACK HAS DEVELOPED, THE DOOR AJAR LIGHT HAS STAYED ON CONSISTENTLY, CAUSING THE INTERIOR LIGHT TO STAY ON, DRAINING THE BATTERY, WHICH HAD TO BE REPLACED. I HAVE NOTICED THE SAME CRACK IN ALMOST EVERY FORD EXPLORER THAT I SEE. I HAVE NOT YET ATTEMPTED A REPAIR BECAUSE I DON'T FEEL I SHOULD HAVE TO PAY OUT OF POCKET FOR AN OBVIOUS MANUFACTURING DEFECT. *TR
NHTSA ODI #10263178
65,000 miles · Mar 20, 2009
Structure
UPPER REAR LIFT GATE BELOW THE REAR GLASS WINDOW WAS FOUND WITH SEVERAL CRACKS ON A COLD WINTER MORNING. NO RECENT IMPACTS OTHER THAN NORMAL REAR HATCH CLOSINGS. HAVE NOTICED MANY OTHER SIMILAR MAKE/MODELS OF FORD/MERCURY WITH THE SAME DAMAGE IN EXACT SAME LOCATION. *TR
NHTSA ODI #10262595
52,000 miles · Feb 16, 2009
Engine And Engine CoolingStructure
REAR PANEL UNDER WINDOW HAS RECENTLY CRACKED, THERE ARE NOW 2 VERTICAL CRACKS RUNNING DOWN THE BACK OF THE VEHICLE. ALSO, HITCH TO REAR DOOR DOESN'T STAY UP. THIS VEHICLE HAS ALSO HAD A NEW ENGINE PUT IT AND INJECTORS HAVE POPPED OUT ON MORE THAN ONE OCCASION. THIS IS THE MOST EXPENSIVE VEHICLE I HAVE EVER PURCHASED AND IT HAS …
Read full complaint
REAR PANEL UNDER WINDOW HAS RECENTLY CRACKED, THERE ARE NOW 2 VERTICAL CRACKS RUNNING DOWN THE BACK OF THE VEHICLE. ALSO, HITCH TO REAR DOOR DOESN'T STAY UP. THIS VEHICLE HAS ALSO HAD A NEW ENGINE PUT IT AND INJECTORS HAVE POPPED OUT ON MORE THAN ONE OCCASION. THIS IS THE MOST EXPENSIVE VEHICLE I HAVE EVER PURCHASED AND IT HAS GIVEN ME MORE PROBLEMS THAN I COULD EVER EXPECT IN A VEHICLE. FORD NEEDS TO COMPENSATE FOR THIS VEHICLE. WE HAVE OWNED SEVERAL FORD'S AND HAVE NEVER SEEN ANYTHING LIKE THIS. IT IS A TRUE LEMON>>>> *TR
NHTSA ODI #10258886
Mileage unknown · Jan 28, 2009
Structure
JUST UNDER THE REAR WINDOW THE BACK PANEL CRACKED IN THE COLD WEATHER THE VEHICLE IS KEPT IN A GARAGE WHEN EXITING THE GARAGE INTO THE WEATHER IT JUST CRACKED JUST UNDER THE MOUNTAINEER EMBLEM ALL THE WAY DOWN THE LENGTH OF THE PANEL AND NOW THE BACK REAR WINDOW RATTLES. *TR
NHTSA ODI #10256625
NHTSA investigations
5EA09013 · Vehicle Rollaway Allegations
Opened Aug 18, 2009 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Additional source detail variants (5)
Power Train:automatic Transmission:gear Position Indication (prndl)
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Power Train:automatic Transmission:lever And Linkage:column Shift
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE05037 · Stuck Engine Throttle
Opened Jul 7, 2005 · Closed Nov 2, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables
ON JULY 7, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE COMPLAINTS IN CERTAIN MODEL YEAR (MY) 2002 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES EQUIPPED WITH THE STANDARD AVAILABLE 4.0L SOHC V6 ENGINE.AT THAT TIME, ODI WAS AWARE OF 15 COMPLAINTS THAT ALLEGED STUCK ENGINE THROTTLE CAUSING UNWANTED VEHICLE ACCELERATION AND 1 ALLEGED CRASH AS A RESULT.SIX COMPLAINANTS REPORTED THAT THROTTLE CONTROL CABLE REPLACEMENT REMEDIED THE ALLEGED STUCK THROTTLE CONDITION.ADDITIONALLY, ODI WAS AWARE OF A TECHNICAL SERVICE BULLETIN ISSUED BY THE MANUFACTURER THAT REFERRED TO AN ACCELERATOR CABLE DESIGN CHANGE.ODI SENT A LETTER TO THE MANUFACTURER ON JULY 18, 2005 REQUESTING CERTAIN INFORMATION ABOUT THESE VEHICLES. ACCORDING TO FORD, APPROXIMATELY 234,092 SUBJECT VEHICLES BUILT FROM AUGUST 14, 2000 (?JOB 1?) THROUGH OCTOBER 31, 2001 USED A PARTICULAR ACCELERATOR CABLE KNOWN AS A 16 LAY WIRE DESIGN.THIS DESIGN IS COMPRISED OF THE THROTTLE CABLE SURROUNDED BY A CONDUIT MADE OF SEVERAL CONCENTRIC LAYERS INCLUDING A TEFLON LINER, A NYLON TUBE EXTRUDED OVER THE TEFLON LINER, 16 LAY WIRES WRAPPED AROUND THE NYLON TUBE, AND FINALLY A NYLON JACKET EXTRUDED OVER AND AROUND THE LAY WIRES. FORD REPORTS THAT THROTTLE CONTROL CONCERNS RELATED TO THE ACCELERATOR CABLE ARE LIKELY CAUSED BY A MIGRATION OF THE INNER TEFLON LINER OUT OF THE CONDUIT AT THE DASH PANEL FITTING.SHOULD THE TEFLON LINER MIGRATE OUTWARD SUFFICIENTLY TO CONTACT THE ACCELERATOR PEDAL ARM IT COULD INTERFERE WITH THE PEDAL?S ABILITY TO RETURN TO IDLE.IN NOVEMBER 2001, FORD BEGAN USING A NEW 12 LAY WIRE DESIGN ACCELERATOR CABLE.THIS CHANGE WAS IMPLEMENTED TO ALLOW FOR INSTALLATION OF OPTIONALLY AVAILABLE POWER-ADJUSTABLE PEDALS. FIELD DATA SUGGESTS THAT THE CONDITION WITH THE SUBJECT CABLE IS MORE PREVALENT IN COLD (WINTER) CLIMATES.OF THE 396 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT, NEARLY 68% OCCURRED IN WINTER MONTHS AND MOST WARRANTY CLAIMS ARE ASSOCIATED WITH VEHICLES SOLD IN THE NORTHEASTERN, NORTHERN INTERIOR (MIDWEST), AND ROCKY MOUNTAIN REGIONS OF THE UNITED STATES.THIS SEASONAL TREND APPEARS TO BE IN DECLINE WITH FEWER WARRANTY CLAIMS PAID IN WINTER 2005 THAN IN PREVIOUS WINTERS.THERE ARE NO KNOWN CRASHES RELATED TO THE ALLEGED DEFECT ON THE SUBJECT VEHICLES, THE COMPLAINT RATE IS LOW AFTER APPROXIMATELY FOUR YEARS IN SERVICE (3.0 INCIDENTS PER 100,000 VEHICLES) AND THE FAILURE TREND IS DECLINING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2005.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.ODI WILL CONTINUE TO MONITOR ITS COMPLAINT DATABASE AND WILL RECEIVE UPDATED COMPLAINT AND WARRANTY DATA FROM FORD IN SPRING 2006 TO VERIFY THE TREND ANALYSIS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
ON JULY 7, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE COMPLAINTS IN CERTAIN MODEL YEAR (MY) 2002 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES EQUIPPED WITH THE STANDARD AVAILABLE 4.0L SOHC V6 ENGINE.AT THAT TIME, ODI WAS AWARE OF 15 COMPLAINTS THAT ALLEGED STUCK ENGINE THROTTLE CAUSING UNWANTED VEHICLE ACCELERATION AND 1 ALLEGED CRASH AS A RESULT.SIX COMPLAINANTS REPORTED THAT THROTTLE CONTROL CABLE REPLACEMENT REMEDIED THE ALLEGED STUCK THROTTLE CONDITION.ADDITIONALLY, ODI WAS AWARE OF A TECHNICAL SERVICE BULLETIN ISSUED BY THE MANUFACTURER THAT REFERRED TO AN ACCELERATOR CABLE DESIGN CHANGE.ODI SENT A LETTER TO THE MANUFACTURER ON JULY 18, 2005 REQUESTING CERTAIN INFORMATION ABOUT THESE VEHICLES. ACCORDING TO FORD, APPROXIMATELY 234,092 SUBJECT VEHICLES BUILT FROM AUGUST 14, 2000 (?JOB 1?) THROUGH OCTOBER 31, 2001 USED A PARTICULAR ACCELERATOR CABLE KNOWN AS A 16 LAY WIRE DESIGN.THIS DESIGN IS COMPRISED OF THE THROTTLE CABLE SURROUNDED BY A CONDUIT MADE OF SEVERAL CONCENTRIC LAYERS INCLUDING A TEFLON LINER, A NYLON TUBE EXTRUDED OVER THE TEFLON LINER, 16 LAY WIRES WRAPPED AROUND THE NYLON TUBE, AND FINALLY A NYLON JACKET EXTRUDED OVER AND AROUND THE LAY WIRES. FORD REPORTS THAT THROTTLE CONTROL CONCERNS RELATED TO THE ACCELERATOR CABLE ARE LIKELY CAUSED BY A MIGRATION OF THE INNER TEFLON LINER OUT OF THE CONDUIT AT THE DASH PANEL FITTING.SHOULD THE TEFLON LINER MIGRATE OUTWARD SUFFICIENTLY TO CONTACT THE ACCELERATOR PEDAL ARM IT COULD INTERFERE WITH THE PEDAL?S ABILITY TO RETURN TO IDLE.IN NOVEMBER 2001, FORD BEGAN USING A NEW 12 LAY WIRE DESIGN ACCELERATOR CABLE.THIS CHANGE WAS IMPLEMENTED TO ALLOW FOR INSTALLATION OF OPTIONALLY AVAILABLE POWER-ADJUSTABLE PEDALS. FIELD DATA SUGGESTS THAT THE CONDITION WITH THE SUBJECT CABLE IS MORE PREVALENT IN COLD (WINTER) CLIMATES.OF THE 396 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT, NEARLY 68% OCCURRED IN WINTER MONTHS AND MOST WARRANTY CLAIMS ARE ASSOCIATED WITH VEHICLES SOLD IN THE NORTHEASTERN, NORTHERN INTERIOR (MIDWEST), AND ROCKY MOUNTAIN REGIONS OF THE UNITED STATES.THIS SEASONAL TREND APPEARS TO BE IN DECLINE WITH FEWER WARRANTY CLAIMS PAID IN WINTER 2005 THAN IN PREVIOUS WINTERS.THERE ARE NO KNOWN CRASHES RELATED TO THE ALLEGED DEFECT ON THE SUBJECT VEHICLES, THE COMPLAINT RATE IS LOW AFTER APPROXIMATELY FOUR YEARS IN SERVICE (3.0 INCIDENTS PER 100,000 VEHICLES) AND THE FAILURE TREND IS DECLINING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2005.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.ODI WILL CONTINUE TO MONITOR ITS COMPLAINT DATABASE AND WILL RECEIVE UPDATED COMPLAINT AND WARRANTY DATA FROM FORD IN SPRING 2006 TO VERIFY THE TREND ANALYSIS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control:cables
ON JULY 7, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE COMPLAINTS IN CERTAIN MODEL YEAR (MY) 2002 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES EQUIPPED WITH THE STANDARD AVAILABLE 4.0L SOHC V6 ENGINE.AT THAT TIME, ODI WAS AWARE OF 15 COMPLAINTS THAT ALLEGED STUCK ENGINE THROTTLE CAUSING UNWANTED VEHICLE ACCELERATION AND 1 ALLEGED CRASH AS A RESULT.SIX COMPLAINANTS REPORTED THAT THROTTLE CONTROL CABLE REPLACEMENT REMEDIED THE ALLEGED STUCK THROTTLE CONDITION.ADDITIONALLY, ODI WAS AWARE OF A TECHNICAL SERVICE BULLETIN ISSUED BY THE MANUFACTURER THAT REFERRED TO AN ACCELERATOR CABLE DESIGN CHANGE.ODI SENT A LETTER TO THE MANUFACTURER ON JULY 18, 2005 REQUESTING CERTAIN INFORMATION ABOUT THESE VEHICLES. ACCORDING TO FORD, APPROXIMATELY 234,092 SUBJECT VEHICLES BUILT FROM AUGUST 14, 2000 (?JOB 1?) THROUGH OCTOBER 31, 2001 USED A PARTICULAR ACCELERATOR CABLE KNOWN AS A 16 LAY WIRE DESIGN.THIS DESIGN IS COMPRISED OF THE THROTTLE CABLE SURROUNDED BY A CONDUIT MADE OF SEVERAL CONCENTRIC LAYERS INCLUDING A TEFLON LINER, A NYLON TUBE EXTRUDED OVER THE TEFLON LINER, 16 LAY WIRES WRAPPED AROUND THE NYLON TUBE, AND FINALLY A NYLON JACKET EXTRUDED OVER AND AROUND THE LAY WIRES. FORD REPORTS THAT THROTTLE CONTROL CONCERNS RELATED TO THE ACCELERATOR CABLE ARE LIKELY CAUSED BY A MIGRATION OF THE INNER TEFLON LINER OUT OF THE CONDUIT AT THE DASH PANEL FITTING.SHOULD THE TEFLON LINER MIGRATE OUTWARD SUFFICIENTLY TO CONTACT THE ACCELERATOR PEDAL ARM IT COULD INTERFERE WITH THE PEDAL?S ABILITY TO RETURN TO IDLE.IN NOVEMBER 2001, FORD BEGAN USING A NEW 12 LAY WIRE DESIGN ACCELERATOR CABLE.THIS CHANGE WAS IMPLEMENTED TO ALLOW FOR INSTALLATION OF OPTIONALLY AVAILABLE POWER-ADJUSTABLE PEDALS. FIELD DATA SUGGESTS THAT THE CONDITION WITH THE SUBJECT CABLE IS MORE PREVALENT IN COLD (WINTER) CLIMATES.OF THE 396 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT, NEARLY 68% OCCURRED IN WINTER MONTHS AND MOST WARRANTY CLAIMS ARE ASSOCIATED WITH VEHICLES SOLD IN THE NORTHEASTERN, NORTHERN INTERIOR (MIDWEST), AND ROCKY MOUNTAIN REGIONS OF THE UNITED STATES.THIS SEASONAL TREND APPEARS TO BE IN DECLINE WITH FEWER WARRANTY CLAIMS PAID IN WINTER 2005 THAN IN PREVIOUS WINTERS.THERE ARE NO KNOWN CRASHES RELATED TO THE ALLEGED DEFECT ON THE SUBJECT VEHICLES, THE COMPLAINT RATE IS LOW AFTER APPROXIMATELY FOUR YEARS IN SERVICE (3.0 INCIDENTS PER 100,000 VEHICLES) AND THE FAILURE TREND IS DECLINING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2005.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.ODI WILL CONTINUE TO MONITOR ITS COMPLAINT DATABASE AND WILL RECEIVE UPDATED COMPLAINT AND WARRANTY DATA FROM FORD IN SPRING 2006 TO VERIFY THE TREND ANALYSIS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control
ON JULY 7, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE COMPLAINTS IN CERTAIN MODEL YEAR (MY) 2002 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES EQUIPPED WITH THE STANDARD AVAILABLE 4.0L SOHC V6 ENGINE.AT THAT TIME, ODI WAS AWARE OF 15 COMPLAINTS THAT ALLEGED STUCK ENGINE THROTTLE CAUSING UNWANTED VEHICLE ACCELERATION AND 1 ALLEGED CRASH AS A RESULT.SIX COMPLAINANTS REPORTED THAT THROTTLE CONTROL CABLE REPLACEMENT REMEDIED THE ALLEGED STUCK THROTTLE CONDITION.ADDITIONALLY, ODI WAS AWARE OF A TECHNICAL SERVICE BULLETIN ISSUED BY THE MANUFACTURER THAT REFERRED TO AN ACCELERATOR CABLE DESIGN CHANGE.ODI SENT A LETTER TO THE MANUFACTURER ON JULY 18, 2005 REQUESTING CERTAIN INFORMATION ABOUT THESE VEHICLES. ACCORDING TO FORD, APPROXIMATELY 234,092 SUBJECT VEHICLES BUILT FROM AUGUST 14, 2000 (?JOB 1?) THROUGH OCTOBER 31, 2001 USED A PARTICULAR ACCELERATOR CABLE KNOWN AS A 16 LAY WIRE DESIGN.THIS DESIGN IS COMPRISED OF THE THROTTLE CABLE SURROUNDED BY A CONDUIT MADE OF SEVERAL CONCENTRIC LAYERS INCLUDING A TEFLON LINER, A NYLON TUBE EXTRUDED OVER THE TEFLON LINER, 16 LAY WIRES WRAPPED AROUND THE NYLON TUBE, AND FINALLY A NYLON JACKET EXTRUDED OVER AND AROUND THE LAY WIRES. FORD REPORTS THAT THROTTLE CONTROL CONCERNS RELATED TO THE ACCELERATOR CABLE ARE LIKELY CAUSED BY A MIGRATION OF THE INNER TEFLON LINER OUT OF THE CONDUIT AT THE DASH PANEL FITTING.SHOULD THE TEFLON LINER MIGRATE OUTWARD SUFFICIENTLY TO CONTACT THE ACCELERATOR PEDAL ARM IT COULD INTERFERE WITH THE PEDAL?S ABILITY TO RETURN TO IDLE.IN NOVEMBER 2001, FORD BEGAN USING A NEW 12 LAY WIRE DESIGN ACCELERATOR CABLE.THIS CHANGE WAS IMPLEMENTED TO ALLOW FOR INSTALLATION OF OPTIONALLY AVAILABLE POWER-ADJUSTABLE PEDALS. FIELD DATA SUGGESTS THAT THE CONDITION WITH THE SUBJECT CABLE IS MORE PREVALENT IN COLD (WINTER) CLIMATES.OF THE 396 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT, NEARLY 68% OCCURRED IN WINTER MONTHS AND MOST WARRANTY CLAIMS ARE ASSOCIATED WITH VEHICLES SOLD IN THE NORTHEASTERN, NORTHERN INTERIOR (MIDWEST), AND ROCKY MOUNTAIN REGIONS OF THE UNITED STATES.THIS SEASONAL TREND APPEARS TO BE IN DECLINE WITH FEWER WARRANTY CLAIMS PAID IN WINTER 2005 THAN IN PREVIOUS WINTERS.THERE ARE NO KNOWN CRASHES RELATED TO THE ALLEGED DEFECT ON THE SUBJECT VEHICLES, THE COMPLAINT RATE IS LOW AFTER APPROXIMATELY FOUR YEARS IN SERVICE (3.0 INCIDENTS PER 100,000 VEHICLES) AND THE FAILURE TREND IS DECLINING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2005.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.ODI WILL CONTINUE TO MONITOR ITS COMPLAINT DATABASE AND WILL RECEIVE UPDATED COMPLAINT AND WARRANTY DATA FROM FORD IN SPRING 2006 TO VERIFY THE TREND ANALYSIS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04045 · Rear Liftgate Glass Assembly
Opened Jun 2, 2004 · Closed Sep 28, 2004
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:hinge And Attachments
COMPLAINTS REPORT FAILURE OF THE REAR LIFTGATE GLASS SUPPORT WHILE THE OPERATOR IS OPENING OR CLOSING THE GLASS.THE FALLING GLASS CAN STRIKE THE OPERATOR OR BYSTANDER.THE INJURIES REPORTED ARE BRUISES TO THE HEAD, NECK OR BACK, CUTS TO THE FACE, ARM OR HAND.ON SEPTEMBER 9, 2004, FORD NOTIFIED THE AGENCY THAT IT WILL RECALL APPROXIMATELY 955,732 MY 2002 AND 2003 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES TO REPLACE THE LIFTGATE GLASS STRUT BRACKETS AND/OR HINGES.SEE NHTSA RECALL 04V442 FOR DETAILS. THIS INVESTIGATION IS CLOSED.
EA02010 · MIS-ASSEMBLED Airbag Clockspring
Opened Jul 2, 2002 · Closed Feb 25, 2003
Status: closed (inferred from source dates) · Air Bags
IN JULY 2001, FORD ISSUED A SPECIAL SERVICE MESSAGE ANNOUNCING THAT SOME AIR BAGCLOCKSPRING DEVICES MAY PRODUCE NOISE WHEN THE STEERING WHEEL IS TURNED FULL LEFT OR RIGHT.FORD WAS AWARE THAT SOME CLOCKSPRINGS MAY HAVE BEEN IMPROPERLY INSTALLED.THE IMPROPER INSTALLATION MAY ALSO CAUSE AN OPEN CIRCUIT AND THE AIR BAG WARNING LIGHT TO ILLUMINATE.STARTING WITH VEHICLES PRODUCED IN SEPTEMBER 2001, FORD ADDING LENGTH TO THE CLOCKSPRING WIRE TO REDUCE THE LIKELIHOOD OF DAMAGE FROM IMPROPER INSTALLATION.ODI'S INVESTIGATION REVEALED 32 COMLAINTS (VEHICLE BUILT PRIOR TO SEPT. 2001) OF WARNING LIGHT BUT NO CRASHES, INJURIES, LAWSUITS OR CLAIMS.A SAFETY DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
Illustration