TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING). WHILE ATTEMPTING TO ACCELERATE AT 1 MPH, THE POWER STEERING ASSIST FAULT INDICATOR ILLUMINATED AND THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN …
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING). WHILE ATTEMPTING TO ACCELERATE AT 1 MPH, THE POWER STEERING ASSIST FAULT INDICATOR ILLUMINATED AND THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A SENSOR IN THE POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT SPOKE TO THE DEALER (GORNO FORD 22025 ALLEN RD, WOODHAVEN, MI 48183) WHO STATED THAT THERE WAS NO OPEN RECALL ON THE VEHICLE, AND THE CONTACT WOULD HAVE TO PAY A DIAGNOSTIC FEE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
NHTSA ODI #10993703
120,000 miles · May 30, 2017
Steering
POWER STEERING GOES IN AND OUT. SO FAR I'VE BEEN LUCKY THIS HASN'T HAPPENED AT HIGH SPEEDS.
NHTSA ODI #10992270
119,588 miles · May 26, 2017
Steering
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL SEIZED. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO MANEUVER. NO WARNING LIGHTS ILLUMINATED. A LOCAL DEALER WAS CONTACTED AT PHONE NUMBER: 770-941-9000, THAT INFORMED THE…
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL SEIZED. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO MANEUVER. NO WARNING LIGHTS ILLUMINATED. A LOCAL DEALER WAS CONTACTED AT PHONE NUMBER: 770-941-9000, THAT INFORMED THE CONTACT TO JIGGLE THE IGNITION THEN RESTART THE VEHICLE BUT FAILED TO START. THE VEHICLE WAS TAKEN TO A LOCAL DEALER AT METRO FORD, 9000 NW 7TH AVE, MIAMI, FL 33150, PHONE NUMBER: (305) 751-9711 BUT THE VEHICLE WAS NOT DIAGNOSED DUE TO DIAGNOSTIC FEES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE RECALL WAS REPAIRED BY THE PREVIOUS OWNER. THE FAILURE MILEAGE WAS 119,588.
NHTSA ODI #10991804
Mileage unknown · May 6, 2017
Steering
VEHICLE POWER STEERING STOP WORKING WHILE PARKED AND AS I STARTED IN THE FOLLOWING DAY, IT BECAME ALMOST IMPOSIBLE TO STEER WHILE DRIVING LET ALONG TRY TO PARK OR TURN,
NHTSA ODI #10983844
44,000 miles · Apr 19, 2017
Steering
MY CAR WAS RECALLED ONCE FOR POWER STEERING ACCORDING TO MY CAR'S HISTORY FORD UPDATED THE COMPUTER SYSTEM. HOWEVER FOR THE LAST SIX MONTHS MY POWER STEERING KEEPS FAILING. I NEVER KNOW WHEN I START THE CAR IF I WILL HAVE POWER STEERING. FORD STATES NO RECALL AND WILL NOT FIX THE PROBLEM FOR FREE. WHAT I READ STATES THAT IF …
Read full complaint
MY CAR WAS RECALLED ONCE FOR POWER STEERING ACCORDING TO MY CAR'S HISTORY FORD UPDATED THE COMPUTER SYSTEM. HOWEVER FOR THE LAST SIX MONTHS MY POWER STEERING KEEPS FAILING. I NEVER KNOW WHEN I START THE CAR IF I WILL HAVE POWER STEERING. FORD STATES NO RECALL AND WILL NOT FIX THE PROBLEM FOR FREE. WHAT I READ STATES THAT IF THE COMPUTER UPDATE DOES NOT WORK THAN A REPLACEMENT OF THE STEERING MUST BE DONE. THIS IS A MAJOR SAFETY ISSUE. I HAVE HAD TO CANCEL DOCTOR'S APPOINTMENTS BECAUSE THAT DAY I DID NOT HAVE POWER STEERING AND CAN NOT PARALLEL PARK. PLEASE I NEED HELP WITH THIS. I UNDERSTAND THAT SOME OTHER OWNERS ARE HAVING THE SAME ISSUE. MUST I GET INTO AN ACCIDENT BECAUSE OF LACK OF POWER STEERING BEFORE FORD CORRECTS THIS PROBLEM ONCE AND FOR ALL. PLEASE HELP I AM DESPERATE.
NHTSA ODI #10979252
115,381 miles · Apr 17, 2017
Steering
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. WHILE DRIVING 50 MPH, THE POWER STEERING MALFUNCTIONED AND MADE IT EXTREMELY DIFFICULT FOR THE CONTACT TO STEER THE VEHICLE LEFT OR RIGHT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,381. UPDATED 06/23/17*LJ *CN
NHTSA ODI #10978795
140,000 miles · Mar 1, 2017
Steering
MY 2009 MERCURY MARINER HAS LOST ITS POWER STEERING CAPABILITIES. WHEN RESEARCHING ONLINE, IT SHOWS A RECALL BASED ON THE POWER STEERING. RECORDS SHOW A FORD DEALER DID THE SOFTWARE UPDATE TO REMEDY THE PROBLEM. HOWEVER, THE CAR WASN'T HAVING ANY ISSUES WHEN THIS WAS DONE. NOW THAT THE CAR IS EXPERIENCING THE ISSUE BASED ON …
Read full complaint
MY 2009 MERCURY MARINER HAS LOST ITS POWER STEERING CAPABILITIES. WHEN RESEARCHING ONLINE, IT SHOWS A RECALL BASED ON THE POWER STEERING. RECORDS SHOW A FORD DEALER DID THE SOFTWARE UPDATE TO REMEDY THE PROBLEM. HOWEVER, THE CAR WASN'T HAVING ANY ISSUES WHEN THIS WAS DONE. NOW THAT THE CAR IS EXPERIENCING THE ISSUE BASED ON THE RECALL, FORD SAYS IT'S NOW OUT OF WARRANTY. I CAN'T IMAGINE I'M THE ONLY ONE OUT OF 741,000 PEOPLE WHO IS HAVING TO DEAL WITH THIS PROBLEM. AS IT STANDS, THE CAR'S STEERING IS MANUAL. FORD NEEDS TO DO SOMETHING TO SATISFY THEIR CUSTOMERS BECAUSE IT'S UNETHICAL TO FIX A PROBLEM WHEN THERE IS NO PROBLEM AND TURN YOUR BACK WHEN THERE IS A PROBLEM.
NHTSA ODI #10957820
103,200 miles · Dec 29, 2016
Steering
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT I…
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING) THE FAILURE MILEAGE WAS 103,200. UPDATED 02/21/17*LJ *TR
NHTSA ODI #10938440
109,228 miles · Dec 16, 2016
Steering
VEHICLE WAS STATIONARY. STARTED VEHICLE AND NO POWER STEERING. CALLED FORD WAS TOLD IT WAS FIXED ON JULY 29, 2014 DUE TO RECALL BUT SAME ISSUE HAS HAPPENED AGAIN. FORD REFUSES TO FIX, WAS TOLD WAS ALREADY FIXED AND NOTHING THEY CAN DO. WENT TO DEALERSHIP WHERE IT WAS BOUGHT NOW HAVE TO PAY OUT OF POCKET.
NHTSA ODI #10935880
189,000 miles · Nov 17, 2016
Steering
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT THERE WAS A SUDDEN LOSS OF POWER STEERING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER TO BE SERVICED FOR NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING), BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE…
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED THAT THERE WAS A SUDDEN LOSS OF POWER STEERING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER TO BE SERVICED FOR NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING), BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED AND DIAGNOSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 189,000.
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
2009 Mercury Mariner Problems, Complaints & Recalls | Skip That Year
Illustration