EXTREMELY DANGEROUS SITUATION EXISTS WHEREAS THE HEADLIGHTS CAN RANDOMLY FLICKER OFF DURING DRIVING, ONLY STOPPED BY KICKING THE LIGHT CONTROL MODULE ABOVE THE ACCELERATOR PEDAL REPEATEDLY WITH LIMITED AND TEMPORARY RESULTS. FIRST OCCURRENCE WAS ON THE INTERSTATE DURING THE NIGHT WITH MODERATE TRAFFIC. MULTIPLE OTHER TERRIFYING…
Read full complaint
EXTREMELY DANGEROUS SITUATION EXISTS WHEREAS THE HEADLIGHTS CAN RANDOMLY FLICKER OFF DURING DRIVING, ONLY STOPPED BY KICKING THE LIGHT CONTROL MODULE ABOVE THE ACCELERATOR PEDAL REPEATEDLY WITH LIMITED AND TEMPORARY RESULTS. FIRST OCCURRENCE WAS ON THE INTERSTATE DURING THE NIGHT WITH MODERATE TRAFFIC. MULTIPLE OTHER TERRIFYING OCCURRENCES AS WELL.
NHTSA ODI #11316976
218,000 miles · Jun 17, 2010
Exterior Lighting
TL* THE CONTACT OWNS A 1993 MERCURY GRAND MARQUIS. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE HEADLIGHTS FAILED. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE HEADLIGHTS WERE OPERATING AS NORMAL. THE CONTACT DISCOVERED THAT THE WIRING HARNESS WAS BURNED AND REPLACED THE HARNESS. THE FAILURE CONTINUED TO RECUR INTERMI…
Read full complaint
TL* THE CONTACT OWNS A 1993 MERCURY GRAND MARQUIS. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE HEADLIGHTS FAILED. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE HEADLIGHTS WERE OPERATING AS NORMAL. THE CONTACT DISCOVERED THAT THE WIRING HARNESS WAS BURNED AND REPLACED THE HARNESS. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN INTO THE DEALER FOR A DIAGNOSTIC OF THE FAILURE. THE FAILURE MILEAGE WAS 218,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10336838
Mileage unknown · Feb 6, 2001
Exterior Lighting
HEADLIGHT COVERS HAVE TURNED AN AMBER COLOR, AND ARE RESTRICTING AMOUNT OF LIGHT COMING THROUGH. *AK *SLC
NHTSA ODI #879915
Mileage unknown · Nov 20, 2000
Exterior Lighting
HEADLIGHT SWITCH REPLACED FOR THIRD TIME, DEALER CANNOT EXPLAIN WHY SHORTED OUT, SWITCH IS NOT INTERCHANGEABLE WITH NEWER OR OLDER MODELS. PLEASE ADD ADDITIONAL INFORMATION. PART NUMBER F2AZ-11654-A. *AK
NHTSA ODI #875242
Mileage unknown · Jul 12, 2000
Exterior Lighting
FAULTY HEAD LIGHT SWITCH ASSEMBLY RESULTING IN BURNING OF THE WIRING HARNESS. *MJS
NHTSA ODI #552985
Mileage unknown · Oct 20, 1999
Electrical SystemExterior Lighting
WHILE THE VEHICLE WAS IN THE PARKING GEAR, WITH IGNITION RUNNING, SMOKE STARTED COMING FROM UNDER THE DASH BY THE WIRING HARNESS. VEHICLE WAS DRIVEN TO THE DEALERSHIP THE NEXT DAY. VEHICLE WAS CHECKED OUT, AND THE BRAKE ON AND OFF SWITCH WAS REPLACED, WHICH KEPT THE VEHICLE FROM COMING OUT OF PARK. CONSUMER STILL EXPERIENCING…
Read full complaint
WHILE THE VEHICLE WAS IN THE PARKING GEAR, WITH IGNITION RUNNING, SMOKE STARTED COMING FROM UNDER THE DASH BY THE WIRING HARNESS. VEHICLE WAS DRIVEN TO THE DEALERSHIP THE NEXT DAY. VEHICLE WAS CHECKED OUT, AND THE BRAKE ON AND OFF SWITCH WAS REPLACED, WHICH KEPT THE VEHICLE FROM COMING OUT OF PARK. CONSUMER STILL EXPERIENCING ELECTRICAL PROBLEMS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #851240
Mileage unknown · Aug 26, 1999
Exterior Lighting
WATER GETS CAUGHT IN THE HEADLIGHT LENSES AND FOGS THEM UP, WHICH REDUCES THE DRIVER'S VISIBILITY. DEALER HAS VEHICLE AND IS REPLACING THE HEADLIGHTS. *AK
NHTSA ODI #845906
Mileage unknown · Apr 21, 1998
Exterior Lighting
HEADLIGHT LAMP IS DIRTY, AFFECTS VISIBILITY, ESPECIALLY AT NIGHT.
NHTSA ODI #534529
Mileage unknown · Jan 20, 1998
Exterior LightingPower Train
FAILED TORQUE CONVERTER CAUSED VEHICLE TO VIBRATE. AFTER TORQUE CONVERTER WAS REPAIRED ALL VEHICLE LIGHTING CEASED, INTERIOR AND EXTERIOR, AND THE SPEEDOMETER WAS ERRATIC. SPEEDOMETER READ 75-80 MPH WHEN VEHICLE WAS ACTUALLY GOING 20-25 MPH.
NHTSA ODI #529529
Mileage unknown · Dec 17, 1997
Exterior Lighting
HEAD LIGHT LENSES GET CLOUDY OVER TIME, CAUSING POOR VISIBILITY.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1993 Mercury Grand Marquis Problems, Complaints & Recalls | Skip That Year
Illustration