IllustrationMileage unknown · Jul 10, 2000
Electrical SystemEquipmentFuel System, Gasoline
HORN FAILED.*ET
NHTSA ODI #552943
1997 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
00–25K
625–50K
850–75K
775–100K
4100–150K
1150K+
26 reports with mileage · 50 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports2 fire reports2 injury reports
What owners actually said
76 reportsHORN FAILED.*ET
SEATBELT BUCKLE FAILED. IS BROKEN. I'M A BIT UPSET!!*AK
RIGHT SIDE PASSENGER DOOR LOCKED (STUCK) CLOSED, THE DOOR CANNOT BE OPENED FROM THE INSIDE OR THE OUTSIDE WITH A KEY, THE OUTSIDE HANDLE IS ALSO IN THE HALFWAY POSITION. NLM
BRAKE LINE CORRODED BY BATTERY ACID AND BROKE, RESULTING IN A SUDDEN LOSS OF BRAKE FUNCTION AND SUBSEQUENT COLLISION WITH VEHICLE THAT STOPPED AHEAD. BRAKE COMBINATION VALVE LOCATED IN FRONT OF BATTERY. ALL THE BRAKE LINES RUN PAST THE BATTERY FROM THE MASTER CYLINDER AND TO THE WHEELS AND ARE FULLY PROTECTED BY A PLASTIC COATIN…
Read full complaint
BRAKE LINE CORRODED BY BATTERY ACID AND BROKE, RESULTING IN A SUDDEN LOSS OF BRAKE FUNCTION AND SUBSEQUENT COLLISION WITH VEHICLE THAT STOPPED AHEAD. BRAKE COMBINATION VALVE LOCATED IN FRONT OF BATTERY. ALL THE BRAKE LINES RUN PAST THE BATTERY FROM THE MASTER CYLINDER AND TO THE WHEELS AND ARE FULLY PROTECTED BY A PLASTIC COATING EXCEPT THE LINE TO THE LEFT FRONT WHEEL. ON THIS LINE THE PLASTIC COATING STARTS AT THE VALVE AND STOPS JUST TO THE RIGHT OF THE BATTERY. THE LINE BROKE AT THE POINT WHERE THE COATING STOPS AND IS HEAVILY CORRODED BY BATTERY ACID FOR SEVERAL INCHES. I AM A MECHANICAL ENGINEER INVESTIGATING THIS ACCIDENT FOR ALLSTATE INSURANCE COMPANY AND WOULD BE HAPPY TO PROVIDE YOU WITH A COPY OF MY REPORT. *AK
I BOUGHT MY COUGAR IN 1997. AT 6,113 MILES THE FRONT ROTORS WERE WARPED AND HAD TO BE TURNED . AT 8,788 MILES THE ROTERS HAD TO BE REPLACED. AT 15,718 MILES THE ROTORS WERE WARPED AGAIN AND HAD TO BE TURNED AGAIN. AT 16,992 MILES THE ROTORS WERE WARPED AGAIN AND TURNED ONCE AGAIN. AT 20,990 MILES MORE PROBLEMS WITH THE BRAKES,PR…
Read full complaint
I BOUGHT MY COUGAR IN 1997. AT 6,113 MILES THE FRONT ROTORS WERE WARPED AND HAD TO BE TURNED . AT 8,788 MILES THE ROTERS HAD TO BE REPLACED. AT 15,718 MILES THE ROTORS WERE WARPED AGAIN AND HAD TO BE TURNED AGAIN. AT 16,992 MILES THE ROTORS WERE WARPED AGAIN AND TURNED ONCE AGAIN. AT 20,990 MILES MORE PROBLEMS WITH THE BRAKES,PREMIUM AFTERMARKET ROTORS AND PADS WERE ORDERED AND WERE INSTALLED AT 21,461 MILES.THEN AT 26,402 THE BRAKE PROBLEM CONTINUES THE ROTORS WERE TURNED AGAIN. I HAVE TRIED TO BE PATIENT WITH THE SERVICE DEPARTMENT AT CENTROPLEX FORD BUT THE LAST TIME THEY TURNED THE ROTORS THEY SAID THAT THEY DON'T KNOW WHAT TO DO TO FIX THE PROBLEM AND I AM VERY CONCERNED. MY WARRANTY WILL RUN OUT SOON AND I WOULD LIKE MY BRAKES FIXED FOR GOOD .
THE PANIC HORN WHICH IS A PART OF THEANTI-THEFT ALARM WENT OFF , CAUSING THE WIRE HARNESS UNDER THE HOOD TO BURN UP TWICE. DEALER HAS BEEN CONTACTED. *AK
WHILE DRIVING BRAKE DISC ROTORS WARPED, CAUSING EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. DEALER REPLACED BRAKE ROTORS NUMEROUS TIMES, BUT THE PROBLEM HAS REOCCURRED. PLEASE PROVIDE FURTHER INFORMATION. *AK
WHEN TRAVELING THE TRANSMISSION DOES NOT SHIFT INTO GEAR. ALSO, THERE IS VIBRATION IN THE FRONT END. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS YET TO REPLACE PARTS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
FRONT END PROBLEMS CAUSING EXCESSIVE VIBRATION (SEVERAL REPAIR ATTEMPTS), FRONT BRAKES ALSO EXPERIENCE LOCKING UP ON OCCASIONS, BOTH THESE FAILURES ARE CAUSING DIRECTIONAL CONTROL PROBLEMS. MJS
VEHICLE INVOLVED IN AN ACCIDENT AT APPROXIMATELY 30-40 MPH IMPACT, ANOTHER VEHICLE DROVE RIGHT IN FRONT OF CONSUMER'S VEHICLE, CAUSING CONSUMER'S VEHICLE TO HIT THE OTHER VEHICLE ON THE SIDE. BOTH AIR BAGS FAILED TO DEPLOY. CAN NHTSA HELP IN THIS MATTER OR PROVIDE FURTHER INFOMATION. *AK
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available