IllustrationTHIS IS THE SECOND TIME IT HAS HAD A BLOWN HEAD GASKET. IT IS NOT FIXED YET BECAUSE I CAN'T AFFORD IT. *NM
1991 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 73 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports6 fire reports5 injury reports
Engine And Engine Cooling complaints
17 reportsTHE CAR STARTS AND RUNS WELL. BUT EVER SO OFTEN WITHOUT ANY WARNING THE ENGINE WILL STALL, AND THEN IT WILL CRANK RIGHT UP. LUCKY FOR ME IT HASN'T STALLED WHILE I WAS MAKING A LEFT TURN WITH A SEMI BARRELING DOWN ON ME.
VEHICLE WAS ACTING SLUGGISH AND WHITE MOKE CAME FORM TAILPIPE. VEHICLE WAS GOING 35MPH AND OVERHEATED, CAUSING DRIVER TO PULL OVER. CONSUMER INDICATED THAT CONTINUING TO DRIVE WILL CAUSE HEAD TO WARP. DEALER WAS NOTIFIED. *AK *TT
CONSUMER COMPLAINS OF HEAD GASKET FAILURE. *JG
WHILE DRIVING 15-20 MPH VEHICLE BEGAN TO OVERHEAT, CONSUMER PULLED INTO SERVICE STATION TO HAVE VEHICLE INSPECTED, THE SERVICE MECHANIC STATED THAT THE HEAD GASKETS HAD BLOWN. DEALER HAS YET TO BE CONTATCED. PLEASE PROVIDE FURTHER DETAILS. *AK
HEADLIGHTS GO OFF WHILE DRIVING, BRAKES CONTINUE TO MAKE NOISE, KEY SWITCH PROB. RECALL REPAIR, HEATER BLOWS COLD, CAR DIED AFTER EXCEL. RESTARTED AND DROVE 50 FT. DIED AGAIN AND KNOW IN SHOP & BEEN TOLD GASKETS OR BUSTED HEAD. I LOVE THIS CAR AND HAVE TAKEN EXTRA CARE, ENGINE AND CAR KEEP SPOTLESS, CAR IS NEVER LEFT OUTSIDE. A…
Read full complaint
HEADLIGHTS GO OFF WHILE DRIVING, BRAKES CONTINUE TO MAKE NOISE, KEY SWITCH PROB. RECALL REPAIR, HEATER BLOWS COLD, CAR DIED AFTER EXCEL. RESTARTED AND DROVE 50 FT. DIED AGAIN AND KNOW IN SHOP & BEEN TOLD GASKETS OR BUSTED HEAD. I LOVE THIS CAR AND HAVE TAKEN EXTRA CARE, ENGINE AND CAR KEEP SPOTLESS, CAR IS NEVER LEFT OUTSIDE. ALL TOOK PLACE WITHIN 1 MO. IS IT ALL TIED TOGETHER WITH ONE THING? *AK
WHEN CONSUMER TOOK VEHICLE TO DEALER FOR CHECK UP,TECHNICIAN FOUND THAT ENGINE HAD A BLOWN HEAD GASKET WICH HAPPENED WITHOUT A WARNING. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
THE HEAD GASKET WENT BAD EVEN AFTER ROUTINE REGULAR MAINTENANCE AND ONLY 80,000 MILES ON THE VEHICLE. ACCORDING TO A LOCAL DEALERSHIP AND SEVERAL MECHANICS THIS IS EXTREMELY COMMON. I WAS FORTUNATE BECAUSE THE HEADS AND BLOCK WERE NOT CRACKED UNLIKE THE MAJORITY OF THE ONES THAT ARE SERVICED. IT SEEMS THAT IF THE 3.8 LITER HA…
Read full complaint
THE HEAD GASKET WENT BAD EVEN AFTER ROUTINE REGULAR MAINTENANCE AND ONLY 80,000 MILES ON THE VEHICLE. ACCORDING TO A LOCAL DEALERSHIP AND SEVERAL MECHANICS THIS IS EXTREMELY COMMON. I WAS FORTUNATE BECAUSE THE HEADS AND BLOCK WERE NOT CRACKED UNLIKE THE MAJORITY OF THE ONES THAT ARE SERVICED. IT SEEMS THAT IF THE 3.8 LITER HAS THIS PROBLEM THEN MAYBE THERE IS A DESIGN FLAW OR QUALITY PROBLEM WITH THE GASKET. THE OTHER PROBLEM IS WHEN HAVING THIS FIXED, THE STEERING PUMP FRONT GASKET USUALLY BREAKS WHEN THE BELT IS REMOVED, THIS SHOULD NOT HAPPEN. IF I HAD KNOWN ABOUT THIS DESIGN FLAW IN THIS ENGINE I WOULD HAVE NEVER PURCHASED THIS OR ANY FORD VEHICLES WITH A 3.8 LITER ENGINE. ALSO WHY DON'T THE SEAT BELTS LOCK? *AK
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
91V048000 · Power Train:automatic Transmission
Mar 18, 1991
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available