The contact owns a 2023 Mercedes-Benz Sprinter 3500. The contact stated that while driving 65 MPH, there was an abnormal metal grinding sound coming from the rear of the vehicle. While driving at various speeds, the vehicle went into LIMP Mode. The transmission was shifted into neutral(N) and the vehicle was restarted. The vehic…
Read full complaint
The contact owns a 2023 Mercedes-Benz Sprinter 3500. The contact stated that while driving 65 MPH, there was an abnormal metal grinding sound coming from the rear of the vehicle. While driving at various speeds, the vehicle went into LIMP Mode. The transmission was shifted into neutral(N) and the vehicle was restarted. The vehicle was taken to the dealer, who diagnosed the vehicle with pinion bearing failure and the LIMP Mode failure causing an Emissions issue. The rear axle, air charger GPS, turbo, and oil sensor were all replaced. The vehicle was taken to the dealer and was diagnosed with the same failure. The vehicle was repaired. The manufacturer was informed of the failure and a case was opened to discuss a buy-back offer for the failure. The failure mileage was approximately 9,600.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023-2024 Mercedes-Benz Sprinter vehicles. The spring U-bolts for the rear axle may have reduced strength due to improper heat-treatment, which can cause the rear axle to shift out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will replace the spring U-bolts, free of charge. Owner notification letters were mailed August 23, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDERB.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. A 12-Volt ground connection may not be secured properly, which can result in the ground connection overheating and a loss of drive power.
Consequence & remedy
Consequence: An overheated ground connection can increase the risk of a fire, and a loss of drive power can increase the risk of a crash.
Remedy: Dealers will inspect and repair the 12-Volt ground connection, as necessary free of charge. Owner notification letters were mailed May 3, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HVERSL.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. The main wiring harness may chafe against the drive shaft and short circuit, which can result in a loss of drive power, power steering, and brake system control.
Consequence & remedy
Consequence: A short circuit increases the risk of a fire. In addition, a loss of drive power, power steering, and brake system control increases the risk of a crash.
Remedy: Dealers will inspect the routing of the main wiring harness and correct it, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEFHAU.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. The front left suspension strut bolt may not be secured properly, which can result in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control can increase the risk of a crash.
Remedy: Dealers will inspect the front left suspension strut bolt connection and repair the body contact surface as necessary, free of charge. Owner notification letters were mailed January 31, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDDOR.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021-2023 Mercedes-Benz Sprinter and 2021 Freightliner Sprinter vehicles. The topcoat paint formula may cause the windows and interior lashing rails to be insufficiently bonded to the vehicle.
Consequence & remedy
Consequence: An insufficiently bonded window can detach during a crash, and objects secured to an insufficiently bonded interior lashing rail can detach, increasing the risk of injury.
Remedy: Dealers will inspect the paint adhesion and repair it as necessary, free of charge. Depending on the extent of any damage, DVUSA may offer to repurchase the vehicle. Interim notification letters, notifying owners of the safety risk, were mailed February 5, 2024. Owner notification letters were mailed November 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LACKHA.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2023 MERCEDES-BENZ Sprinter 3500 Problems, Complaints & Recalls | Skip That Year
Illustration