Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 21 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electronic Stability Control (esc). Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
THIS VEHICLE HAS HAD 4 SEPARATE WHEEL SPED SENSOR FAILURES. WHEN EACH INCIDENT OCCURRED, THE VEHICLE WILL ACCELERATE ON ITS OWN AND AT THE SAME TIME THE ABS WILL NOT ALLOW FULL BRAKING PRESSURE WHILE UNDERWAY. YOU WILL HEAR THE ABS SOUND LIKE IT'S SLIDING ON A SLIPPERY SURFACE IN ANY CONDITION. AS THE VEHICLE ACCELERATES AND B…
Read full complaint
THIS VEHICLE HAS HAD 4 SEPARATE WHEEL SPED SENSOR FAILURES. WHEN EACH INCIDENT OCCURRED, THE VEHICLE WILL ACCELERATE ON ITS OWN AND AT THE SAME TIME THE ABS WILL NOT ALLOW FULL BRAKING PRESSURE WHILE UNDERWAY. YOU WILL HEAR THE ABS SOUND LIKE IT'S SLIDING ON A SLIPPERY SURFACE IN ANY CONDITION. AS THE VEHICLE ACCELERATES AND BRAKING PRESSURE IS GREATLY REDUCED, IT IS SOMETIMES NECESSARY TO QUICKLY SHOVE THE VEHICLE IN NEUTRAL TO KEEP FROM HITTING ANYTHING AHEAD. WHEN THESE FAILURES OCCUR IT CAN BE AT ANY SPEED OR ON ANY SURFACE. THIS VEHICLE WAS PURCHASED NEW AND NOW HAS APPROXIMATELY 45,000 MILES. OCCASIONALLY, PRIOR TO THE DASH LIGHTS INDICATING A WHEEL SPEED SENSOR FAILURE, THE VEHICLE WILL ALSO CUT ALL POWER. THIS TYPICALLY HAS HAPPENED ON HARD ACCELERATION ONTO A HIGHWAY, BEING EQUALLY DANGEROUS TO DRIVE. THE VEHICLE IS JUST GOING OUT OF WARRANTY AND I HAVE TRIED TO WORK OUT A SOLUTION WITH MERCEDES WHO HAVE NOW STATED I HAVE NO CLAIM. A FINAL FACTOR IS THAT AT ABOUT 10,000 MILES THIS VEHICLE HAD A MASSIVE SHORT THAT LITERALLY MELTED THE BATTERY DOWN. I HAVE SUGGESTED TO MERCEDES THAT THAT INCIDENT, UNDER WARRANTY, MAY HAVE DONE SEROUS HARM TO THE ENTIRE ELECTRICAL SYSTEM/COMPUTERS.
NHTSA ODI #11374997
400 miles · Oct 28, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
SEE UPLOADED DOCUMENT
NHTSA ODI #11366869
39,000 miles · Oct 14, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
IN OCTOBER OF 2018 AT 28,860 ODOMETER MILES, THE PASSENGER REAR WHEEL SPEED SENSOR FAILED WHILE DRIVING FROM ATLANTA, GA TO WEST PALM BEACH, FL. CAUSING THE EPS, ABS, ANTI_COLLISION AND CRUISE CONTROL SYSTEM TO STOP FUNCTIONING WITH WARNING MESSAGES DISPLAYED ON THE DASH. I EXPERIENCED ERRATIC SPEEDS WHILE MANUALLY DRIVING HOME…
Read full complaint
IN OCTOBER OF 2018 AT 28,860 ODOMETER MILES, THE PASSENGER REAR WHEEL SPEED SENSOR FAILED WHILE DRIVING FROM ATLANTA, GA TO WEST PALM BEACH, FL. CAUSING THE EPS, ABS, ANTI_COLLISION AND CRUISE CONTROL SYSTEM TO STOP FUNCTIONING WITH WARNING MESSAGES DISPLAYED ON THE DASH. I EXPERIENCED ERRATIC SPEEDS WHILE MANUALLY DRIVING HOME. ON OCTOBER 3, 2020, AT 39,214 ODOMETER MILES, THE SAME ISSUE HAPPENED AGAIN, ONLY THIS TIME IT WAS THE FRONT PASSENGER WHEEL SPEED SENSOR THAT FAILED WITH ALL THE SAME WARNING LIGHTS AND DISABLED EPS, ABS, ANTI-COLLISION AND CRUISE CONTROL SYSTEMS BEING SHUT DOWN. IN BOTH CASES THE FAILED SENSORS WERE REPLACED UNDER THE MERCEDES-BENZ EMISSION WARRANTY. I AM VERY CONCERNED THAT THESE FAILURES ARE COMMON WITH THIS MODEL VEHICLE AND I WILL CONTINUE TO EXPERIENCE FAILURES OF THESE SENSORS AFTER THE WARRANTY EXPIRES. I HAVE REPLACED TWO OF THEM SO FAR WITH LESS THAN 40,000 MILES ON THE VEHICLE AND THERE ARE STILL TWO MORE ORIGINAL SENSORS YET TO FAIL.
NHTSA ODI #11364340
48,271 miles · Apr 6, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
WHILE DRIVING OUR 2015 MERCEDES SPRINTER 3500 ON I-5 SOUTH FROM OAKLAND, CA TO JOSHUA TREE NATIONAL PARK ON THURSDAY, MARCH 19 SUDDENLY OUR SPEED CONTROL QUIT FUNCTIONING AND THE ABS, ESP AND TRACTION CONTROL LIGHTS ON OUR INSTRUMENT PANEL LIGHTED UP. WE IMMEDIATELY CALLED A MERCEDES BENZ SERVICE DEPARTMENT IN BAKERSFIELD, CA …
Read full complaint
WHILE DRIVING OUR 2015 MERCEDES SPRINTER 3500 ON I-5 SOUTH FROM OAKLAND, CA TO JOSHUA TREE NATIONAL PARK ON THURSDAY, MARCH 19 SUDDENLY OUR SPEED CONTROL QUIT FUNCTIONING AND THE ABS, ESP AND TRACTION CONTROL LIGHTS ON OUR INSTRUMENT PANEL LIGHTED UP. WE IMMEDIATELY CALLED A MERCEDES BENZ SERVICE DEPARTMENT IN BAKERSFIELD, CA AND WERE TOLD THAT AS LONG AS THE VAN SEEMED TO BE DRIVING , BRAKING AND HANDLING NORMALLY WE DID NOT NEED TO BRING IT IN FOR SERVICE BUT COULD CONTINUE DRIVING. THE VAN DID SEEM TO BE RUNNING NORMALLY SO WE DROVE ON WITHOUT SPEED CONTROL. ABOUT 400 MILES LATER AS WE WERE DRIVING INTO JOSHUA TREE NATIONAL PARK THE BRAKES STARTED TO MAKE A LOUD CLICKING NOISE WHEN THE PEDAL WAS DEPRESSED COMPLETELY AND THE TRANSMISSION WOULD NO LONGER SHIFT OUT OF 2ND GEAR MAKING IT IMPOSSIBLE TO DRIVE OVER 30 MPH. WE HAD TO HAVE THE VAN TOWED 46 MILES BACK TO PALM SPRINGS, CA AND AWAIT THE MERCEDES BENZ SERVICE DEPARTMENT THERE OPENING ON MONDAY, MARCH 23. AT THE SERVICE DEPARTMENT THEY DIAGNOSED THE REAR WHEEL SPEED SENSORS HAD FAILED WITH ONLY 48,271 MILES ON THE ODOMETER. THE FOLLOWING DAY THEY REPLACED THE REAR WHEEL SPEED SENSORS AND THE VAN WAS RUNNING NORMALLY AGAIN. I HAVE RESEARCHED THE PROBLEM WITH THE WHEEL SPEED SENSORS ON MERCEDES BENZ SPRINTER VANS. IT SEEMS TO BE A COMMON PROBLEM AT LEAST FROM THE YEAR 2013-2016. IT IS UNACCEPTABLE THAT A VAN THAT MERCEDES PROMOTES FOR ITS UTILITY HAS THIS KIND OF FAILURE COMMONLY. IT IS A SIGNIFICANT SAFETY ISSUE. WE WERE DRIVING ON DRY PAVEMENT SO NOTICED NO PROBLEM WITH PERFORMANCE UNTIL THE BRAKES BEGAN TO MALFUNCTION AND THE VAN WOULD NOT SHIFT ABOVE 2ND GEAR. IF WE HAD BEEN ON WET OR SLICK ROADS THE LACK OF ANTI-LOCK BRAKES, TRACTION CONTROL AND ELECTRONIC STABILITY CONTROL WOULD HAVE MADE THE VAN DANGEROUS TO DRIVE. MERCEDES BENZ NEEDS TO DO SOMETHING TO REMEDY THIS COMMON FAILURE.
NHTSA ODI #11320295
32,000 miles · Sep 7, 2019
Service Brakes
WHILE DRIVING, THREE WARNING LIGHTS ILLUMINATED ADVISING I HAD LOST MY ABS AND MY CRUISE CONTROL FAILED. THE VEHICLE SOON WENT INTO LIMP MODE. BOTH REAR WHEEL ABS SPEED SENSORS FAILED AND WERE REPLACED BY A MERCEDES SPRINTER DEALER. I SOON DISCOVERED THIS IS A VERY COMMON FAILURE. THE VEHICLE ONLY HAD 32000 MILES ON IT WHEN THE …
Read full complaint
WHILE DRIVING, THREE WARNING LIGHTS ILLUMINATED ADVISING I HAD LOST MY ABS AND MY CRUISE CONTROL FAILED. THE VEHICLE SOON WENT INTO LIMP MODE. BOTH REAR WHEEL ABS SPEED SENSORS FAILED AND WERE REPLACED BY A MERCEDES SPRINTER DEALER. I SOON DISCOVERED THIS IS A VERY COMMON FAILURE. THE VEHICLE ONLY HAD 32000 MILES ON IT WHEN THE PROBLEM OCCURRED. THE SERVICE AGENT SAID IT WAS A VERY COMMON PROBLEM ON THE SPRINTER RV VEHICLES. I FEEL MERCEDES SHOULD FIX THE PROBLEM AS IT IS AN INHERENT SAFETY PROBLEM FOR THESE VEHICLES. I WAS TRAVELING 65 MPH ON AN INTERSTATE HIGHWAY WITH CRUISE CONTROL ENGAGED WHEN THE PROBLEM OCCURRED. THIS COULD HAVE BEEN A SAFETY ISSUE HAD I NEEDED THE BRAKES AT THAT MOMENT.
NHTSA ODI #11253828
3,500 miles · Sep 1, 2016
Service Brakes
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ SPRINTER 3500. WHEN THE BRAKE PEDAL WAS DEPRESSED AT VARIOUS SPEEDS, IT EXTENDED TO THE FLOORBOARD AND THE VEHICLE HESITATED TO RESPOND. AFTER THE BRAKE PEDAL WAS DEPRESSED A SECOND TIME, IT RESET BACK TO THE PROPER POSITION. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE COULD NOT…
Read full complaint
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ SPRINTER 3500. WHEN THE BRAKE PEDAL WAS DEPRESSED AT VARIOUS SPEEDS, IT EXTENDED TO THE FLOORBOARD AND THE VEHICLE HESITATED TO RESPOND. AFTER THE BRAKE PEDAL WAS DEPRESSED A SECOND TIME, IT RESET BACK TO THE PROPER POSITION. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,500. THE VIN WAS NOT AVAILABLE.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2012-2018 Mercedes Benz Sprinter 3500 and Freightliner Sprinter 3500 vehicles upfitted into campers or recreational vehicles. The Electronic Stability Control (ESC) unit may become disabled on these vehicles.
Consequence & remedy
Consequence: If ESC becomes disabled, vehicle driving stability may be impacted under certain driving conditions, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the rear-wheel speed sensor with a more robust sensor, free of charge. DVUSA issued owners an interim notification on March 10, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NC3DREZAHA.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the driver frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: DVUSA will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall is began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: DVUSA will notify owners, and dealers will replace the front passenger air bag module, free of charge. The recall began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Midwest will notify owners, and dealers will replace the fire extinguisher with a different brand, free of charge. The recall began on December 11, 2017. Owners may contact Kidde customer service for their replacement extinguisher at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015 Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles were manufactured without a protective plate on the front of the gas tank and a foam ring at the filler neck. As such, these vehicles may not comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence & remedy
Consequence: Without the protective plate and the foam ring installed, impacts may damage the tank resulting in a fuel leak that can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will replace the fuel tank, free of charge. The recall began on June 6, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans. These vehicles were manufactured without a reinforcement plate and protective bracket on the air bag control unit. As a result, the air bag control unit may not remain functional after the initial impact, possibly preventing additional air bags from deploying in response to a secondary impact.
Consequence & remedy
Consequence: If additional air bags do not deploy as intended, the occupants are at an increased risk of injury.
Remedy: DVUSA will notify owners, and dealers will install a reinforcement plate and protective bracket around the air bag control unit, free of charge. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015 Mercedes-Benz Sprinter 2500 and 3500 vehicles. The affected vehicles were manufactured without a driveshaft catch strap, allowing a loose driveshaft to strike the fuel tank. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence & remedy
Consequence: A loose driveshaft may strike and puncture the gas tank, resulting in a fuel leak, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will install a driveshaft catch strap, free of charge. The recall began on April 27, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015, to April 30, 2016. The affected vehicles are configured to have super-high roofs, but may not be equipped with the required crash pads.
Consequence & remedy
Consequence: If the required crash pads are missing, it can increase the risk of injury to a front passenger seat occupant if they are unbelted.
Remedy: DVUSA will notify owners, and dealers will install the required crash-pads, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015. The affected vehicles may have had multiple layers of paint applied, and as a result, in a crash, the windows may separate from the vehicle when the outer layer of paint peels from the layer below.
Consequence & remedy
Consequence: If the windows separate from the vehicle in a crash, the occupants are at a greater risk of injury.
Remedy: DVUSA will notify owners, and dealers will remove the windows and inspect the paintwork, repainting the vehicles as necessary, free of charge. This recall began August 4, 2016. Owners may contact DVUSA customer service at 1-770-705-2070.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015. The affected vehicles have a tire pressure label that incorrectly states a higher maximum load capacity than the vehicle is designed for.
Consequence & remedy
Consequence: The vehicle may be overloaded if loaded to the incorrect weight shown on the label, possibly resulting in axle or tire failure, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will replace the incorrect tire pressure label, free of charge. The recall began March 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE20014 · Rear Wheel Speed Sensor Failure
Opened Sep 21, 2020 · Closed Mar 30, 2021
Status: closed (inferred from source dates) · Service Brakes, Air:antilock:wheel Speed Sensor; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor
The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (unique VINs) in MY 2012-2018 Mercedes- Benz and Freightliner Sprinter vehicles upfitted to campers or recreational vehicles (RVs) representing 81 percent of all Sprinter RWSS reports. Complaint and warranty analysis indicated that the majority of incidents (approximately 99%) were related to RWSS moisture intrusion condition in the Sprinter 3500 5-ton variant, which accounts for 98 percent of upfit campers, where moisture build-up and crystal dendrite formation develop in parked RVs and lead to sensor failures. According to the Daimler Information Request (IR) response, if the wheel speed information is detected as implausible by the Electronic Stability Program (ESP) control unit, the ESP system enters a failsafe mode where:-Driver torque requests are no longer accepted;-Cruise control, if used, would be deactivated; -The ESP/ABS system shuts off; and -Multiple warning lamps and messages advise the operator to take the vehicle to the workshop. While the majority of reports involved only ABS and/or ESP warning lights and messages on the instrument cluster due to faulty sensor signals triggering a failsafe mode, some reports cited intermittent sensor failures resulting in increased vehicle speed while in cruise control and degraded ABS or ESP. Degraded ESP functionality may impact driving stability of the 5-ton vehicle.On Feb 3, 2021, following discussion with ODI, Daimler submitted a Defect Information Report (DIR) to NHTSA describing a defect in the RWSS disabling the ESP control unit functions in approximately 48,667 MY 2012 through 2018 Mercedes-Benz and Freightliner Sprinter 3500 vehicles manufactured from Jan 4, 2012 through Oct 25, 2018 (Recall 21V-042). In its DIR, Daimler indicated that RWSS sensor failures are prevalent in camper vans due to sustained periods of non-use, during which time the moisture may not dry out, remaining inside the plastic housing package. If the moisture within the RWSS dries and the RWSS returns to normal operation, the failsafe mode and the warning lights will disappear at the next ignition cycle, but the sensor fault remains stored within the ESP control unit and can be accessed through a diagnostic evaluation. ODI will continue to monitor field experience in Sprinter non-RVs and Sprinter 2500 RVs 3-ton and 3.5-ton variants (approximately 626 vehicles).Daimler will notify owners of the recalled vehicles and advise them to take their vehicle to a Mercedes-Benz or Freightliner Sprinter dealer, who will replace the RWSS with a repackaged sensor with high robustness against moisture intrusion. Daimler began notifying dealers and owners in Feb 2021. This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed at NHTSA.gov under the following ID numbers:11352380 11351299 11350521 11348969 11342776 11342464 11341988 11341151 11340388 11338230 11337921 11331832 11331829 11331476 11331427 11331066 11328671 11325768 11325693 11322814 11322346 11320295 11319376 11317336 11311647 11310621 11308318 11254223 11253828 11252220 11196530 11194330 11164250 11145019 11141273 11139000 11138785 11124129 11094122 11394837 11390889 11390039 11389262 11387883 11387713 11386418 11383887 11383866 11382947 11377384 11376615 11376973 11375781 11375403 11374997 11374151 11373892 11373111 11366293 11365920 11365594 11365355 11365194 11364253 11364346 11363990 11363787 11362948 113629
Additional source detail variants (2)
Service Brakes, Air:antilock:wheel Speed Sensor
The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (unique VINs) in MY 2012-2018 Mercedes- Benz and Freightliner Sprinter vehicles upfitted to campers or recreational vehicles (RVs) representing 81 percent of all Sprinter RWSS reports. Complaint and warranty analysis indicated that the majority of incidents (approximately 99%) were related to RWSS moisture intrusion condition in the Sprinter 3500 5-ton variant, which accounts for 98 percent of upfit campers, where moisture build-up and crystal dendrite formation develop in parked RVs and lead to sensor failures. According to the Daimler Information Request (IR) response, if the wheel speed information is detected as implausible by the Electronic Stability Program (ESP) control unit, the ESP system enters a failsafe mode where:-Driver torque requests are no longer accepted;-Cruise control, if used, would be deactivated; -The ESP/ABS system shuts off; and -Multiple warning lamps and messages advise the operator to take the vehicle to the workshop. While the majority of reports involved only ABS and/or ESP warning lights and messages on the instrument cluster due to faulty sensor signals triggering a failsafe mode, some reports cited intermittent sensor failures resulting in increased vehicle speed while in cruise control and degraded ABS or ESP. Degraded ESP functionality may impact driving stability of the 5-ton vehicle.On Feb 3, 2021, following discussion with ODI, Daimler submitted a Defect Information Report (DIR) to NHTSA describing a defect in the RWSS disabling the ESP control unit functions in approximately 48,667 MY 2012 through 2018 Mercedes-Benz and Freightliner Sprinter 3500 vehicles manufactured from Jan 4, 2012 through Oct 25, 2018 (Recall 21V-042). In its DIR, Daimler indicated that RWSS sensor failures are prevalent in camper vans due to sustained periods of non-use, during which time the moisture may not dry out, remaining inside the plastic housing package. If the moisture within the RWSS dries and the RWSS returns to normal operation, the failsafe mode and the warning lights will disappear at the next ignition cycle, but the sensor fault remains stored within the ESP control unit and can be accessed through a diagnostic evaluation. ODI will continue to monitor field experience in Sprinter non-RVs and Sprinter 2500 RVs 3-ton and 3.5-ton variants (approximately 626 vehicles).Daimler will notify owners of the recalled vehicles and advise them to take their vehicle to a Mercedes-Benz or Freightliner Sprinter dealer, who will replace the RWSS with a repackaged sensor with high robustness against moisture intrusion. Daimler began notifying dealers and owners in Feb 2021. This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed at NHTSA.gov under the following ID numbers:11352380 11351299 11350521 11348969 11342776 11342464 11341988 11341151 11340388 11338230 11337921 11331832 11331829 11331476 11331427 11331066 11328671 11325768 11325693 11322814 11322346 11320295 11319376 11317336 11311647 11310621 11308318 11254223 11253828 11252220 11196530 11194330 11164250 11145019 11141273 11139000 11138785 11124129 11094122 11394837 11390889 11390039 11389262 11387883 11387713 11386418 11383887 11383866 11382947 11377384 11376615 11376973 11375781 11375403 11374997 11374151 11373892 11373111 11366293 11365920 11365594 11365355 11365194 11364253 11364346 11363990 11363787 11362948 113629
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor
The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (unique VINs) in MY 2012-2018 Mercedes- Benz and Freightliner Sprinter vehicles upfitted to campers or recreational vehicles (RVs) representing 81 percent of all Sprinter RWSS reports. Complaint and warranty analysis indicated that the majority of incidents (approximately 99%) were related to RWSS moisture intrusion condition in the Sprinter 3500 5-ton variant, which accounts for 98 percent of upfit campers, where moisture build-up and crystal dendrite formation develop in parked RVs and lead to sensor failures. According to the Daimler Information Request (IR) response, if the wheel speed information is detected as implausible by the Electronic Stability Program (ESP) control unit, the ESP system enters a failsafe mode where:-Driver torque requests are no longer accepted;-Cruise control, if used, would be deactivated; -The ESP/ABS system shuts off; and -Multiple warning lamps and messages advise the operator to take the vehicle to the workshop. While the majority of reports involved only ABS and/or ESP warning lights and messages on the instrument cluster due to faulty sensor signals triggering a failsafe mode, some reports cited intermittent sensor failures resulting in increased vehicle speed while in cruise control and degraded ABS or ESP. Degraded ESP functionality may impact driving stability of the 5-ton vehicle.On Feb 3, 2021, following discussion with ODI, Daimler submitted a Defect Information Report (DIR) to NHTSA describing a defect in the RWSS disabling the ESP control unit functions in approximately 48,667 MY 2012 through 2018 Mercedes-Benz and Freightliner Sprinter 3500 vehicles manufactured from Jan 4, 2012 through Oct 25, 2018 (Recall 21V-042). In its DIR, Daimler indicated that RWSS sensor failures are prevalent in camper vans due to sustained periods of non-use, during which time the moisture may not dry out, remaining inside the plastic housing package. If the moisture within the RWSS dries and the RWSS returns to normal operation, the failsafe mode and the warning lights will disappear at the next ignition cycle, but the sensor fault remains stored within the ESP control unit and can be accessed through a diagnostic evaluation. ODI will continue to monitor field experience in Sprinter non-RVs and Sprinter 2500 RVs 3-ton and 3.5-ton variants (approximately 626 vehicles).Daimler will notify owners of the recalled vehicles and advise them to take their vehicle to a Mercedes-Benz or Freightliner Sprinter dealer, who will replace the RWSS with a repackaged sensor with high robustness against moisture intrusion. Daimler began notifying dealers and owners in Feb 2021. This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed at NHTSA.gov under the following ID numbers:11352380 11351299 11350521 11348969 11342776 11342464 11341988 11341151 11340388 11338230 11337921 11331832 11331829 11331476 11331427 11331066 11328671 11325768 11325693 11322814 11322346 11320295 11319376 11317336 11311647 11310621 11308318 11254223 11253828 11252220 11196530 11194330 11164250 11145019 11141273 11139000 11138785 11124129 11094122 11394837 11390889 11390039 11389262 11387883 11387713 11386418 11383887 11383866 11382947 11377384 11376615 11376973 11375781 11375403 11374997 11374151 11373892 11373111 11366293 11365920 11365594 11365355 11365194 11364253 11364346 11363990 11363787 11362948 113629
2015 MERCEDES-BENZ Sprinter 3500 Problems, Complaints & Recalls | Skip That Year
Illustration